2003 Ford F-550 Sd Owner Complaints

TL* THE CONTACT OWNS A 2003 FORD F-550 SD. WHILE DRIVING UNKNOWN SPEEDS, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK DISINTEGRATED. THE FLOAT FILTER AND FILTER WERE CLOGGED. THE CONTACT CALLED A LOCAL DEALER (VISION FORD, 1500 S WHITE SANDS BLVD, ALAMOGORDO, NM 88310) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 107,550.

NHTSA ID

11061627

Incident

Jan 1, 2015

Mileage

107,550 mi

WATTER SEPERATOR VALVE DUMPED FUEL ON THE TURBO CAUSING A FIRE.

NHTSA ID

10946265

Incident

Dec 31, 2016

Mileage

175,541 mi

I HAVE EXPERIENCED NUMEROUS ENGINE FAILURES, OF WHICH I HAVE THE RECEIPTS, ON MY F500 FORD WITH THE 6.0 DIESEL ENGINE, AT A COST TO ME OF OVER $7,000. AT THE TIME OF THE FAILURES, THE ENGINE WAS ONLY OUT OF WARRANTY FOR A SHORT PERIOD OF TIME. BECAUSE A DIESEL SHOULD LAST FOR A RELATIVELY LONG PERIOD OF TIME AND SHOULD NOT HAVE THESE TYPES OF PROBLEMS, I ASKED FORD TO COVER THE BILL. IN SHORT, FORD WOULD NOT GIVE ME THE TIME OF DAY OR ADMIT TO ANYTHING. I AM VERY CONCERNED AS I DON' T MAKE THE KIND OF MONEY IT TAKES TO CONTINUALLY INVEST IN AN ENGINE THAT SHOULD STILL RUN FINE. I HAVE ALSO DISCUSSED THIS WITH OTHERS THAT OWN THE SAME ENGINE AND HAVE FOUND THAT THE TYPE OF PROBLEMS THAT I'VE HAD ARE QUITE COMMON WITH THE 6.0 ENGINE. I HAVE ALL THE RECEIPTS AND EXPECT FORD TO TAKE RESPONSIBILITY FOR WHAT IS CLEARLY A POORLY BUILT ENGINE. I'M ALSO HAVING TROUBLE WITH THE AIR CONDITIONER FOR YEARS AND HAVE BEEN UNABLE TO FIND THE PROBLEM. I AWAIT YOUR REPLY AND CAN SEND YOU A COPY OF THE BILLS AND MY CORRESPONDENCE WITH FORD.

NHTSA ID

10481643

Incident

May 18, 2009

Mileage

80,687 mi

NORCOLD CORP. ISSUED SAFETY RECALL # 10E-049 ON/ABOUT OCTOBER 21, 2010 FOR REFRIGERATOR UNITS IN RECREATIONAL VEHICLES FOR A POTENTIAL "FIRE" IN THE COOLING UNIT(S). A CERTIFIED RV DEALER CONFIRMED FIRE DAMAGE TO UNIT OWNED AND OPERATED BY COMPLAINANT . NORCOLD CORP. HAS REFUSED TO HONOR SAFETY RECALL(S) AND REPAIR SAID DAMAGED UNITS. THE FIRE WAS CONTAINED TO THE REFRIGERATOR UNIT ONLY HOWEVER ITS A TOTAL LOST. THERE ARE MILLIONS OF SIMILAR DEFECTIVE REFRIGERATOR UNITS BEING USED ON THE NATIONAL'S HIGHWAYS BY UNSUSPECTING RV OWNERS POSING A SERIOUS SAFETY AND HAZARDOUS POTENTIAL FOR A CATASTROPHIC EVENT THAT WILL ENDANGER THE TRAVELING PUBLIC. *TR

NHTSA ID

10461248

Incident

Mar 12, 2012

Mileage

25,000 mi

TL*THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH, THE VEHICLE STALLED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FUEL TANK INNER LINING WAS DE-LAMINATING AND BEING DRAWN INTO THE FUEL SYSTEM. AS A TEMPORARY REMEDY, THE CONTACT DECIDED TO DE-LAMINATE THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.

NHTSA ID

10418001

Incident

Aug 2, 2011

Mileage

100,000 mi

TL*THE CONTACT OWNS A 2003 FORD F550. THE CONTACT STATED THAT THE FUEL TANK HAD DELAMINATED AND CAUSED THE FUEL TANK TO CLOGGED UP. THE FAILURE ALSO CAUSED THE VEHICLE TO LOSE POWER AND STALL WHILE DRIVING UPHILL. THE WAS RESPONSIBLE FOR PAYING $900 TO REPLACE THE FUEL TANK SINCE THERE WERE NO WARRANTIES OR RECALLS. THE MANUFACTURER CONFIRMED THAT THERE WERE NO RECALLS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000.

NHTSA ID

10389840

Incident

Nov 23, 2010

Mileage

75,000 mi

I HAVE 2 FORD F550 TRUCKS (2001,2003). BOTH TRUCKS WITH VERY LOW MILEAGE (37K, 56K MILES). BOTH DIESEL ENGINES. BOTH HAVE ONLY HAD EITHER SHELL OR CHEVRON FUEL PUT IN THEM. NO BIO FUELS. THE INTERIOR OF BOTH MY TRUCKS FUEL TANKS ARE DELAMINATING AND CAUSING THE VARIOUS FUEL FILTERS TO CLOG WITH A METALLIC DEBRIS AND RUST. FORD MOTOR COMPANY IS BLAMING THE DELAMINATING ON THE FUEL USED IN THE TRUCKS. MY DEALER (WESTLIE FORD, CAMAS, WASHINGTON) WHERE I PURCHASED THESE TRUCKS CANNOT WARRANTY THE REPLACEMENT TANKS NEEDED TO REMEDY THIS PROBLEM. THIS IS AN EPIDEMIC FOR FORD MOTOR COMPANY! WORD HAS IT FORD HAS FIXED THE PROBLEM WITH THE NEW COATING ON THE NEW TANKS BUT, I CAN FIND NO ANNOUNCEMENT FROM FORD MOTOR COMPANY SAYING SO. AVERAGE COST TO REPLACE THIS TANK RUNS BETWEEN $1,500 - $2,500 DOLLARS. HOW MANY PEOPLE MUST DIE WHEN THEIR FUEL SYSTEMS GET CLOGGED BY THE DELAMINATING PARTICLES OF THE FUEL TANK AND STOP DEAD ON A FREEWAY OR FOGGY NIGHT? FORD MOTOR COMPANY SHOULD FIX THIS PROBLEM! *TR

NHTSA ID

10360708

Incident

Oct 13, 2010

Mileage

37,000 mi

TL* THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SEVERE LOSS OF POWER AND SMOKE WAS COMING FROM THE EXHAUST PIPE, DUE TO THE UNISON RINGS FAILING. THE RINGS ARE A PART OF THE TURBO CHARGER ON THE ENGINE AND THE CONTACT HAD TO HAVE THEM REPLACED TWICE. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE AND THAT IT WAS NOT COVERED UNDER THE WARRANTY. THE DEALER PLACED NICKEL PLATED RINGS INSTEAD OF THE STEEL RINGS ON THE VEHICLE AND THE PROBLEM SEEMS TO BE RESOLVED. THE FAILURE MILEAGE WAS 1038 AND THE CURRENT MILEAGE WAS 9500.

NHTSA ID

10353454

Incident

Sep 21, 2004

Mileage

1,038 mi

HERCULES S-209 TIRE BLEW ALL TREAD LOST MAJOR SEPARATIONS OTHER TIRES NOTICE WIDESPREAD MINOR CRACKING. *TR

NHTSA ID

10351117

Incident

Mar 1, 2010

FUEL TANK DELAMINATION. CLOGS FUEL SYSTEM, AND TRASHES INJECTORS AND PUMPS. NEW TANK, INJECTORS, PUMP. CLEAN FUEL SYSTEM. FORD SAYS BIOFUEL, NEVER USE BIOFUEL. *TR

NHTSA ID

10334114

Incident

Jul 15, 2009

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2003 FORD F550 SD. WHILE DRIVING AT APPROXIMATELY 45-50 MPH, THE VEHICLE WOULD EXHIBIT EXCESSIVE SHAKING AND WOULD LOSE POWER. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE INDEPENDENT MECHANIC ADVISED THAT THE INSIDE LINING OF THE FUEL TANK WAS PEELING AND CLOGGING THE FUEL LINES. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 48,000.

NHTSA ID

10330466

Incident

May 4, 2010

Mileage

48,000 mi

TL* THE CONTACT OWNS A 2003 FORD F-55O. WHILE DRIVING THE VEHICLE STALLED WITHOUT WARNING. HE WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD-WAY. THE VEHICLE WAS TOWED TO A FORD DEALER AND A TECHNICIAN DISCOVERED AN INTERNAL OIL LEAK FROM THE PUMP. THE REPAIRS WERE PERFORMED UNDER WARRANTY. SEVERAL DAYS AFTER THE REPAIR AN IDENTICAL FAILURE OCCURRED. A TECHNICIAN FROM THE DEALER STATED THAT THE FUEL TANK DELAMINATED DUE TO THE DIESEL FUEL. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 101000. THE CURRENT MILEAGE WAS 102000.

NHTSA ID

10297562

Incident

Dec 24, 2009

Mileage

101,000 mi

ENGINE FAILED AND VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $2223.41. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR

NHTSA ID

10295487

Incident

Oct 8, 2009

Mileage

57,493 mi

ENGINE FAILED AND VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED WHICH CAUSED DEBRIS TO MOVE THROUGH THE FUEL FILTER AND ENGINE. THE ENGINE HAD O BE REPLACED. THE TANK HAD TO BE REPLACED. THE COST: $10,345.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR

NHTSA ID

10293747

Incident

Jan 2, 2008

Mileage

54,500 mi

VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $1600.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR

NHTSA ID

10293031

Incident

Oct 26, 2009

Mileage

78,892 mi

VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $1600.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR

NHTSA ID

10293027

Incident

Nov 12, 2009

Mileage

60,506 mi

TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. WHILE IDLING, THE VEHICLE SHAKES AND LUNGES FORWARD WITHOUT WARNING. THE VEHICLE ALMOST LUNGED INTO TRAFFIC WHILE AT IDLING AT A STOP LIGHT ON ONE OCCASION. A COMPONENT WAS REPLACED BY THE PREVIOUS OWNER, BUT THE FAILURE STILL PERSISTS. THE CONTACT FEELS THAT A CRASH COULD OCCUR. THE CURRENT MILEAGE WAS 47,000 AND FAILURE MILEAGE WAS 46,000.

NHTSA ID

10273607

Incident

May 30, 2009

Mileage

46,000 mi

TRUCK WAS RUNNING ROUGH AND WAS LOOSING POWER. THEY REPLACED THE GAS TANK INJECTORS AND A PUMP. THE DEALER STATED THAT THE DIESEL WAS EATING AWAY AT THE LINER OF THE TANK. MY TRUCK IS ONLY 5 YEARS OLD. IT HAS COST HUNDREDS OF DOLLARS TO FIX. THE TRUCK IS IN THE SHOP RIGHT NOW FOR SAME PROBLEMS NO POWER. *TR

NHTSA ID

10260321

Incident

Dec 20, 2008

Mileage

31,000 mi

TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. WHILE DRIVING LESS THAN 70 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY FOLLOWING, FLAMES APPEARED UNDER THE HOOD OF THE VEHICLE. THE FIRE WAS DESCRIBED AS "VIOLENT" WITH FLAMES AT LEAST 70 FEET HIGH. THE POLICE AND FIRE DEPARTMENTS WERE CALLED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE CONTACT HAS SUPPORTING DOCUMENTATION, INCLUDING VIDEOS AND PHOTOS. THE FAILURE AND CURRENT MILEAGES WERE 125,000.

NHTSA ID

10251394

Incident

Dec 9, 2008

Mileage

125,000 mi

2004 FORD SUPER DUTY W 6.0 LITER DIESEL. FUEL TANK INTERNAL COATING IF FLAKING OFF. ENGINE LOOSES POWER AND STOPS WITHOUT WARNING. MOST OF TANK HAS PEELED OFF WHICH PLUGS UP FUEL STRAINER IN TANK. TRUCK WAS TOWED AND THIS WASHED THE DEFECTIVE MATERIAL FROM THE FUEL STRAINER. NO CODES WERE DETECTED. THIS HAS HAPPENED 2-3 TIMES BEFORE WE CAUGHT IT. TANK AND INTERNAL PUMP WERE REPLACED AT ABOUT 120,000 MILES AT MY COST. I HAVE ALL THE PARTS. VEHICLE WILL LOOSE POWER IMMEDIATELY WITHOUT WARNING. *TR

NHTSA ID

10251041

Incident

Nov 10, 2008

Mileage

125,000 mi

TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. ON SEPTEMBER 14, 2008, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE BEGAN STALLING. THE FAILURE PERSISTED FOR TWO DAYS. THE CONTACT PARKED THE VEHICLE AT HIS RESIDENCE AND ATTEMPTED TO START THE ENGINE THE FOLLOWING DAY, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE FUEL TANK DELAMINATED, CAUSING PLASTIC DEBRIS TO FLOW THROUGH THE FUEL LINES, FUEL PUMP, AND FUEL FILTER. AS A RESULT, THE FUEL PUMP DOES NOT PUMP FUEL TO THE FUEL INJECTORS, WHICH PREVENTS THE VEHICLE FROM STARTING. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL; THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE VEHICLE IS STILL IN THE POSSESSION OF THE DEALER AND HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 73,000. UPDATED 11/14/08. *LJ UPDATED 11/18/08. *JB

NHTSA ID

10242923

Incident

Sep 15, 2008

Mileage

63,669 mi

TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. THE CONTACT RECEIVED A RECALL NOTICE FOR THE CRANKSHAFT POSITION SENSOR. HE TOOK THE VEHICLE TO THE DEALER TO BE SERVICED UNDER THE RECALL. THE VEHICLE COULD NOT BE RESTARTED. THE DEALER STATED THAT THE WIRING HARNESS MELTED AND NEEDED TO BE REPLACED. THE CONTACT ASKED THE DEALER IF HE COULD SEE THE DEFECTIVE WIRING HARNESS AND THE DEALER STATED THAT THEY THREW IT AWAY. THE REPAIR COST $1,273.35. THERE WERE NO FAILURES PRIOR TO THE RECALL REMEDY. THE MANUFACTURER STATED THAT NOTHING COULD BE DONE. THE CURRENT MILEAGE WAS 58,201 AND FAILURE MILEAGE WAS 58,100. UPDATED 05/12/08 *BF THE FAILURE WAS AN ELECTRICAL PLUG. THE DEALER STATED THE TRUCK HAD A SENSOR WHICH WAS NOT COMPATIBLE WITH THE NEW CAMSHAFT POSITION SENSOR.

NHTSA ID

10224611

Incident

Jul 4, 2007

Mileage

58,100 mi

TL*THE CONTACT OWNS A 2003 FORD F550. WHILE TOWING A VEHICLE AT 45 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE FAILURE CAUSED A MAJOR BACK UP THAT INVOLVED THE LOCAL POLICE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE FUEL INJECTORS WERE RECENTLY REPLACED. THE DEALER STATED THAT THE FAILURE WAS DUE TO THE FUEL INJECTOR. THE CURRENT AND FAILURE MILEAGES WERE 43,500. UPDATED 02-14-08. *KB THE FUEL MODULE, FUEL PUMP AND TURBO CHARGER WERE REPLACED. UPDATED

NHTSA ID

10214546

Incident

Jan 7, 2008

Mileage

43,500 mi

TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. THE DEALER NOTICED THAT THE LUG NUTS HOLLOWED OUT THE STEEL RIMS DURING A ROUTINE INSPECTION. THE THREE RIMS AND REAR STUDS OF THE VEHICLE WERE REPLACED. THE CURRENT MILEAGE WAS 133,000 AND FAILURE MILEAGE WAS 132,000.

NHTSA ID

10204691

Incident

Sep 12, 2007

Mileage

132,000 mi

FUEL INJECTORS FAIL CAUSING VEHICLE TO SHUTDOWN. *NM

NHTSA ID

10183512

Incident

Nov 11, 2005

Mileage

28,798 mi