2003 Ford F-550 Sd

IN A DECEMBER 3, 2007 LETTER, FORD ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO REPLACE THE CAM POSITION SENSOR (CPS) IN APPROXIMATELY 1.2 MILLION SUBJECT VEHICLES TO ADDRESS REPORTS OF ENGINE STALLING.A NEW DESIGN CPS WITH IMPROVED PERFORMANCE AND DURABILITY WILL BE INSTALLED AS A REMEDY.OWNER NOTIFICATIONS WILL BEGIN IN DECEMBER 2007. THE SUBJECT VEHICLES ARE DURABLE, FULL-SIZED, MEDIUM DUTY TRUCKS COMMONLY USED FOR COMMERCIAL PURPOSES, RESCUE/EMERGENCY RESPONSE, AND COMMERCIAL OR RECREATIONAL TOWING.CPS FAILURE IS COMPARABLE TO UNEXPECTEDLY TURNING THE KEY OFF SINCE THE SIGNAL IT PRODUCES IS VITAL TO THE ELECTRONIC ENGINE CONTROL SYSTEM.CPS SIGNAL LOSS TERMINATES FUEL INJECTION RESULTING IN AN ENGINE STALL.ONCE STALLED, THE ENGINE MAY RESTART RIGHT AWAY, OR MAY RESTART AFTER A DELAY (TYPICALLY 5 TO 10 MINUTES), OR MAY NOT RESTART AT ALL.IN ADDITION TO EXPOSING THE DRIVER AND OTHER MOTORISTS TO CRASH RISK DUE TO LOSS OF MOTIVE POWER OR VEHICLE DISABLEMENT, ENGINE STALLING ALSO EFFECTS THE POWER ASSISTED STEERING AND BRAKING. THROUGH CONSUMER INTERVIEWS, ODI DETERMINED THAT CPS FAILURES OCCURRED WITHOUT ANY FORM OF WARNING, AT ANY VEHICLE SPEED (50% AT HIGHWAY SPEEDS), AND UNDER ANY DRIVING CONDITION, SUCH AS ACCELERATING.CONSUMERS REPORTED THAT ABOUT A THIRD OF THE VEHICLES FAILED TO RESTART, WITH ANOTHER THIRD REPORTING DELAYED RESTARTING.HALF THE VEHICLES THAT DID RESTART EXPERIENCED ANOTHER STALL ON THE SAME OR A SUBSEQUENT DRIVE CYCLE (BEFORE CPS REPLACEMENT) RE-EXPOSING THOSE CONSUMERS TO THE RISKS ASSOCIATED WITH A STALLING EVENT.IN THEIR VOQ REPORTS, HALF OF THE ODI COMPLAINANTS DESCRIBED DIFFICULTY CONTROLLING THE VEHICLE DUE TO LOSE OF POWER ASSIST SYSTEMS, ESPECIALLY THOSE WHO WERE TOWING AT THE TIME OF THE INCIDENT. THE ONE ALLEGED INJURY INCIDENT OCCURRED IN AN INTERSECTION WHEN A SUBJECT VEHICLE STALLED WHILE TURNING ACROSS ONCOMING LANES OF TRAFFIC.ALTHOUGH UNSUBSTANTIATED, THE COMPLAINANT ALLEGED AN INJURY TO A CHILD OCCUPANT DURING ODI'S INTERVIEW.THE OTHER CRASH ALLEGATIONS MOSTLY INVOLVED LOW SPEED, LOSS OF CONTROL INCIDENTS OFTEN CAUSED BY LACK OF POWER ASSIST; NO INJURIES ARE REPORTED IN THESE INCIDENTS, AND PROPERTY DAMAGE, IF ANY, WAS MINIMAL.CONSUMERS ALSO REPORTED OTHER INCIDENTS WITH SIGNIFICANT SAFETY RISKS, SUCH AS DISABLEMENT IN A LANE OR ON A SHOULDER OF A HIGH-SPEED ROADWAY OR INTERSTATE, OR EXTENDED DISABLEMENT IN REMOTE AREAS DURING SEVERE WEATHER CONDITIONS. THE POPULATION ABOVE IS FORD'S ESTIMATE OF THE 1.4 MILLION SUBJECT VEHICLES PRODUCED THAT ARE CURRENTLY REGISTERED.THE FORD COMPLAINT AND WARRANTY COUNTS NOTED ABOVE ARE CURRENT AS OF FORD'S LAST SUBMISSION DATED JUNE 21, 2007; THEY DO NOT INCLUDE F-450, F-550, OR ECONOLINE COUNTS AS THESE PRODUCTS WERE NOT FORMALLY WITHIN SCOPE OF THE INVESTIGATION WHEN FAILURE INFORMATION WAS REQUESTED.WARRANTY DATA ANALYSIS INDICATES THAT ABOUT HALF THE CLAIMS INVOLVED A STALL WHILE DRIVING EVENT ( FORD'S ASSESSMENT) AND THAT POOR CPS DURABILITY WAS A LONGSTANDING CONCERN.FORD REPORTED THAT THE NEW CPS DESIGN SHOULD MEET OR EXCEED THEIR 10 YEAR, 150K MILE LIFE EXPECTANCY DESIGN REQUIREMENT.

IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.

FAILURE COUNTS FROM ODI?S ANALYSIS ARE STATED ABOVE; SEE THE ADDITIONAL PROBLEM EXPERIENCE DISCUSSION IN THE SUMMARY REPORT.FORD DATA CONTAINED DUPLICATIVE REPORTS FOR 4 ODI COMPLAINTS AND 1 CRASH.THREE CRASHES WERE ALLEGEDLY DUE TO INTERMITTENT OPERATION OF THE ELECTRONIC THROTTLE CONTROL (ETC) PEDAL, ONE CRASH OCCURRED WHEN AN ETC DISABLED VEHICLE WAS STRUCK BY ANOTHER MOTORIST, ONE REPORT CONTAINED NO DETAIL.THE INJURIES WERE MINOR.AN ISSUE INVOLVING FIXED ETC PEDALS WAS INVESTIGATED ALSO, HOWEVER FAILURE REPORTS AND POPULATIONS ARE NOT SHOWN ABOVE; SEE SUMMARY REPORT FOR DETAIL.ALTHOUGH FORD HAS USED ETC BASED THROTTLE CONTROL SYSTEMS FOR MANY YEARS, THE PAP FEATURE WAS NEW FOR MY 2002.THE SUBJECT ETC SENSOR PRODUCES TWO OUTPUT SIGNALS WHICH THE ENGINE MANAGEMENT SYSTEM (EMS) UTILIZES TO:1) DETERMINE FUELING REQUIREMENTS; AND 2) PERFORM SENSOR DIAGNOSTICS.ONE SIGNAL IS LINEARLY PROPORTIONAL TO THROTTLE PEDAL POSITION; THE SECOND IS A DIGITAL SIGNAL.BY DESIGN, THE DETECTION OF A SENSOR FAULT RESULTS IN THE ENGINE RETURNING TO (OR REMAINING AT) THE IDLE STATE.FORD IDENTIFIED A DEFECT IN THE PAP ETC SENSOR WHICH PREMATURELY AFFECTED AN OUTPUT SIGNAL; THE MIGRATION OF INTERNAL SENSOR LUBRICANT CAUSED A LOSS OF PROPORTIONAL SIGNAL.THE FAILURE MECHANISM IS PROGRESSIVE AND AS THE SENSOR DETERIORATES, THE EMS WILL DETECT A FAULT, STORE A FAULT CODE, ILLUMINATE A WARNING LAMP, AND THE ENGINE MAY REMAIN AT/RETURN TO IDLE.IN THE EARLY STAGES, NORMAL OPERATION CAN BE REGAINED BY PEDAL RE-APPLICATION.THE FAILURE PROGRESSES UNTIL THE ENGINE REMAINS AT IDLE.THE ENGINE DOES NOT STALL, POWER ASSISTED STEERING AND BRAKING SYSTEMS ARE UNAFFECTED. FORD CORRECTED THE ETC SENSOR DEFECT AND CONDUCTED FIELD SERVICE ACTION (FSA) 03B03 TO REPLACE ETC PEDALS, ADDRESSING 50% OF VEHICLES.AT AGENCY REQUEST TO IMPROVE COMPLETION RATE, FORD EXTENDED FSA 03B03 FOR 6 MONTHS.BASED ON ODI'S ANALYSIS OF AVAILABLE DATA, FORD'S ACTION HAS APPROPRIATELY RESOLVED THE ETC SENSOR PROPLEM IN THE SUBJECT VEHICLES.THE CLOSING OF THE INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST, AND SHOULD NOT BE CONSIDERED AS HAVING ANY PRECEDENTIAL VALUE OR EFFECT BINDING THE AGENCY IN FUTURE DEFECT INVESTIGATIONS. SEE THE ATTACHED SUMMARY REPORT FOR ADDITIONAL INFORMATION.

TL* THE CONTACT OWNS A 2003 FORD F-550 SD. WHILE DRIVING UNKNOWN SPEEDS, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK DISINTEGRATED. THE FLOAT FILTER AND FILTER WERE CLOGGED. THE CONTACT CALLED A LOCAL DEALER (VISION FORD, 1500 S WHITE SANDS BLVD, ALAMOGORDO, NM 88310) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 107,550.

NHTSA ID

11061627

Incident

Jan 1, 2015

Mileage

107,550 mi

WATTER SEPERATOR VALVE DUMPED FUEL ON THE TURBO CAUSING A FIRE.

NHTSA ID

10946265

Incident

Dec 31, 2016

Mileage

175,541 mi

I HAVE EXPERIENCED NUMEROUS ENGINE FAILURES, OF WHICH I HAVE THE RECEIPTS, ON MY F500 FORD WITH THE 6.0 DIESEL ENGINE, AT A COST TO ME OF OVER $7,000. AT THE TIME OF THE FAILURES, THE ENGINE WAS ONLY OUT OF WARRANTY FOR A SHORT PERIOD OF TIME. BECAUSE A DIESEL SHOULD LAST FOR A RELATIVELY LONG PERIOD OF TIME AND SHOULD NOT HAVE THESE TYPES OF PROBLEMS, I ASKED FORD TO COVER THE BILL. IN SHORT, FORD WOULD NOT GIVE ME THE TIME OF DAY OR ADMIT TO ANYTHING. I AM VERY CONCERNED AS I DON' T MAKE THE KIND OF MONEY IT TAKES TO CONTINUALLY INVEST IN AN ENGINE THAT SHOULD STILL RUN FINE. I HAVE ALSO DISCUSSED THIS WITH OTHERS THAT OWN THE SAME ENGINE AND HAVE FOUND THAT THE TYPE OF PROBLEMS THAT I'VE HAD ARE QUITE COMMON WITH THE 6.0 ENGINE. I HAVE ALL THE RECEIPTS AND EXPECT FORD TO TAKE RESPONSIBILITY FOR WHAT IS CLEARLY A POORLY BUILT ENGINE. I'M ALSO HAVING TROUBLE WITH THE AIR CONDITIONER FOR YEARS AND HAVE BEEN UNABLE TO FIND THE PROBLEM. I AWAIT YOUR REPLY AND CAN SEND YOU A COPY OF THE BILLS AND MY CORRESPONDENCE WITH FORD.

NHTSA ID

10481643

Incident

May 18, 2009

Mileage

80,687 mi

NORCOLD CORP. ISSUED SAFETY RECALL # 10E-049 ON/ABOUT OCTOBER 21, 2010 FOR REFRIGERATOR UNITS IN RECREATIONAL VEHICLES FOR A POTENTIAL "FIRE" IN THE COOLING UNIT(S). A CERTIFIED RV DEALER CONFIRMED FIRE DAMAGE TO UNIT OWNED AND OPERATED BY COMPLAINANT . NORCOLD CORP. HAS REFUSED TO HONOR SAFETY RECALL(S) AND REPAIR SAID DAMAGED UNITS. THE FIRE WAS CONTAINED TO THE REFRIGERATOR UNIT ONLY HOWEVER ITS A TOTAL LOST. THERE ARE MILLIONS OF SIMILAR DEFECTIVE REFRIGERATOR UNITS BEING USED ON THE NATIONAL'S HIGHWAYS BY UNSUSPECTING RV OWNERS POSING A SERIOUS SAFETY AND HAZARDOUS POTENTIAL FOR A CATASTROPHIC EVENT THAT WILL ENDANGER THE TRAVELING PUBLIC. *TR

NHTSA ID

10461248

Incident

Mar 12, 2012

Mileage

25,000 mi

TL*THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH, THE VEHICLE STALLED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FUEL TANK INNER LINING WAS DE-LAMINATING AND BEING DRAWN INTO THE FUEL SYSTEM. AS A TEMPORARY REMEDY, THE CONTACT DECIDED TO DE-LAMINATE THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.

NHTSA ID

10418001

Incident

Aug 2, 2011

Mileage

100,000 mi

TL*THE CONTACT OWNS A 2003 FORD F550. THE CONTACT STATED THAT THE FUEL TANK HAD DELAMINATED AND CAUSED THE FUEL TANK TO CLOGGED UP. THE FAILURE ALSO CAUSED THE VEHICLE TO LOSE POWER AND STALL WHILE DRIVING UPHILL. THE WAS RESPONSIBLE FOR PAYING $900 TO REPLACE THE FUEL TANK SINCE THERE WERE NO WARRANTIES OR RECALLS. THE MANUFACTURER CONFIRMED THAT THERE WERE NO RECALLS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000.

NHTSA ID

10389840

Incident

Nov 23, 2010

Mileage

75,000 mi

I HAVE 2 FORD F550 TRUCKS (2001,2003). BOTH TRUCKS WITH VERY LOW MILEAGE (37K, 56K MILES). BOTH DIESEL ENGINES. BOTH HAVE ONLY HAD EITHER SHELL OR CHEVRON FUEL PUT IN THEM. NO BIO FUELS. THE INTERIOR OF BOTH MY TRUCKS FUEL TANKS ARE DELAMINATING AND CAUSING THE VARIOUS FUEL FILTERS TO CLOG WITH A METALLIC DEBRIS AND RUST. FORD MOTOR COMPANY IS BLAMING THE DELAMINATING ON THE FUEL USED IN THE TRUCKS. MY DEALER (WESTLIE FORD, CAMAS, WASHINGTON) WHERE I PURCHASED THESE TRUCKS CANNOT WARRANTY THE REPLACEMENT TANKS NEEDED TO REMEDY THIS PROBLEM. THIS IS AN EPIDEMIC FOR FORD MOTOR COMPANY! WORD HAS IT FORD HAS FIXED THE PROBLEM WITH THE NEW COATING ON THE NEW TANKS BUT, I CAN FIND NO ANNOUNCEMENT FROM FORD MOTOR COMPANY SAYING SO. AVERAGE COST TO REPLACE THIS TANK RUNS BETWEEN $1,500 - $2,500 DOLLARS. HOW MANY PEOPLE MUST DIE WHEN THEIR FUEL SYSTEMS GET CLOGGED BY THE DELAMINATING PARTICLES OF THE FUEL TANK AND STOP DEAD ON A FREEWAY OR FOGGY NIGHT? FORD MOTOR COMPANY SHOULD FIX THIS PROBLEM! *TR

NHTSA ID

10360708

Incident

Oct 13, 2010

Mileage

37,000 mi

TL* THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SEVERE LOSS OF POWER AND SMOKE WAS COMING FROM THE EXHAUST PIPE, DUE TO THE UNISON RINGS FAILING. THE RINGS ARE A PART OF THE TURBO CHARGER ON THE ENGINE AND THE CONTACT HAD TO HAVE THEM REPLACED TWICE. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE AND THAT IT WAS NOT COVERED UNDER THE WARRANTY. THE DEALER PLACED NICKEL PLATED RINGS INSTEAD OF THE STEEL RINGS ON THE VEHICLE AND THE PROBLEM SEEMS TO BE RESOLVED. THE FAILURE MILEAGE WAS 1038 AND THE CURRENT MILEAGE WAS 9500.

NHTSA ID

10353454

Incident

Sep 21, 2004

Mileage

1,038 mi

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.

This SKU is a Transmission Line. The customer communication requested return of unsold inventory to inspect the connector. The transmission line connector may have an incorrect thread size, which will prevent it from being installed.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the upper left corner. Select the utility knife in the bottom left corner. Select Update/Special Function and enter 53061 in the blue box then press the tick mark. The screen will go back to the system utilities page. Navigate to the toolbox tab and run the Programmable Module Installation (PMI) on the VSM. The procedure will prompt you to manually enter the as-built into the VSM. Obtain the as-built data from PTS > OASIS > As-Built.

FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE