2007 Ford F-550 Sd Problems

I HAVE A 2007 FORD F-550 WITH ONLY 31000 MILES AND THE VEHICLE LOST POWER AND STALLED OUT ON SIDE OF ROAD. WHEN FORD DEALERSHIP CHECKED THE VEHICLE IT WAS FOUND THAT THE FUEL TANK LINER HAD DETERIORATED AND RUSTED CAUSING DEBRIS TO ENTER INTO THE FUEL SYSTEM WHICH DAMAGED THE FUEL PUMP, INJECTORS AND OTHER PARTS OF THE FUEL SYSTEM. AFTER TALKING WITH OTHER FORD DEALERSHIPS WE FOUND OUT THAT THIS HAS BEEN A PROBLEM WITH OTHER VEHICLES THAT HAVE THIS SAME TANK. IF FORD WOULD HAVE RECALLED THE TANK OR AT LEAST MADE IT KNOWN TO THE OWNERS THAT THERE WAS A PROBLEM ALL THE DAMAGE WOULD NOT HAVE HAPPENED. THIS HAS COST US ALREADY $2658 TO THE FORD DEALERSHIP AND WE HAVE ABOUT $1500 MORE TO SPEND TO CORRECT THE PROBLEM----ALL BECAUSE FORD WOULD NOT EVEN LET US KNOW THERE WAS A PROBLEM THAT COULD HAVE BEEN FIXED FOR A LOT LESS.

FORD GAS TANK DELAMINATION. LOSS OF POWER. ENGINE MISSING. THIS HAS BROUGHT ME EXTREME HEARTACHE AT THE WORST TIME. I AM A SEASONAL WORKER WHO RELIES SOLELY ON HIS TRUCK. WITHOUT IT I AM OUT OF BUSINESS. IT WILL COST ME ANYWHERE FROM $2,000 TO $6,000 TO FIX IT. AND I SIMPLY DON'T HAVE IT. *TR

TL* THE CONTACT OWNED A 2007 FORD F-550. THE CONTACT STATED THAT WHILE THE TRANSMISSION WAS IN THE PARK POSITION AND WITH THE ENGINE IDLING SUDDENLY FLAMES WERE PRESENT COMING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE INCIDENT THE VEHICLE WAS DESTROYED. A REPORT WAS TAKEN BY THE SHERIFF'S DEPUTY. THE OWNER, A FIRE DEPARTMENT DIRECTOR, DETERMINED THAT THE FIRE WAS CAUSED BY A FAULTY ENGINE TURBO CHARGER. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 6,000. THE CONSUMER STATED 2007 BRUSH TRUCK IS GOING BACK TO WEIS FIRE SAFTEY IN KANSAS FOR A REBUILD. THE CONSUMER STATED THE INSURANCE COMPANY DEEMED THE TURBO CHARGER AS THE CAUSE OF THE FIRE.

TL* THE CONTACT OWNS A 2007 FORD F-550 SD. THE CONTACT STATED THE VEHICLE WAS LEAKING COMPRESSION FROM THE CYLINDERS INTO THE COOLANT SYSTEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A MALFUNCTIONED HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000.

The contact owns a 2007 Ford F-550. The contact stated while driving 50 mph, the vehicle inadvertently stalled and lost power. There were no warning lights illuminated. The contact veered to the side of the roadway and was able to restart the vehicle. The contact stated that the failure recurred the same day while pulling to a parking lot. The contact contacted the manufacturer of the battery control circuit who instructed the contact to do a jumper wire to bypass the vehicle issue. The contact stated that the issue was resolved. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The contact contacted the manufacturer to advise that the recall repair for NHTSA Campaign Number: 13V265000 (Electrical System) was not completed effectively however, the manufacturer informed the contact that the dealer needed to verify the information. The dealer was made aware of the failure and informed the contact they could not assist. The approximate failure mileage was 45,720.

2007 FORD F-550. CONSUMER WRITES IN REGARDS TO BATTERY CONTROL CENTER SAFETY RECALL. *LD *JS

REAR BRAKE PADS ONLY LAST 7,000 - 10,000 MILES, AND REAR BRAKE CALIPERS ARE OVERHEATING BLOWS OUT CALIPER SEAL. THE TRUCK HAS BEEN TO FORD AND WAS TOLD THIS WAS NORMAL. ALSO TOOK VEHICLE TO 2 OTHER REPAIR SHOPS AND THEY HAVE REPLACED EVERY BRAKE PART ON THE TRUCK EXCEPT THE MASTER CYLINDER, ABS MODULE, STEEL LINES. THE BRAKE PRESSURE TO THE FRONT AND REAR WHEELS WAS CHECKED AT THE LAST FAILURE AND THEY ARE THE SAME PRESSURE. THE REAR BRAKES HAVE BEEN REPLACE ABOUT 15 TIMES IN 123,000 MILE ON VEHICLE. WE HAVE AN IDENTICAL TRUCK TO THIS IN OUR FLEET AND THE REAR BRAKES LAST ABOUT 80,000 MILES. *TR

TL*THE CONTACT OWNS A 2007 FORD F550. THE CONTACT STATED THAT THE BRAKES FAIL WHEN DRIVING DOWNHILL OR ON ANY SURFACE. THE BRAKES CAUSE THE VEHICLE TO BUCK VIOLENTLY WHENEVER THE BRAKE PEDAL IS DEPRESSED. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE; HOWEVER, THEY SWITCHED SOME PARTS IN THE VEHICLE. THE FAILURE PERSISTS AND IS BECOMING WORSE. THE FAILURE MILEAGE WAS 29,000.

PURCHASED BRAND NEW FORD F-550 ON 11/27/06. ON A ROAD TRIP ON 11/28/06 THE WIFE AND I NOTICED A VERTICAL SHIMMY AT 50MPH. WE CONTINUED TO ACCELERATE AND THE SHIMMY STOPPED UNTIL WE HIT 60MPH AND A HORIZONTAL SHAKING BEGAN. THE SHAKING IS INTERMITTENT BUT QUITE PRONOUNCED. SEVERAL TRIPS TO THE DEALERSHIP FAILED TO CORRECT THE PROBLEM. AT TIMES, AFTER HITTING A BUMP IN THE ROAD, AN UNCONTROLLABLE VIBRATION WITH SHAKE THE ENTIRE VEHICLE FOR SEVERAL SECONDS. THE VIBRATIONS CONTINUE TO THIS DAY VIRTUALLY EVERY TIME THE VEHICLE IS DRIVEN. *TR

TL* THE CONTACT OWNS A 2007 FORD F-550 SD. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE BRAKE LIGHTS AND TURN SIGNAL LIGHTS FAILED. THE CONTACT NOTIFIED THE DEALER AND THEY STATED THAT THE MULTI- FUNCTION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.

TL* THE CONTACT OWNS A 2007 FORD F-550 SD. THE CONTACT STATED THAT THE TRANSFER CASE FAILED AND CAUSED THE CARPET TO CATCH FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED. MIKE THOMPSON'S RV SUPER STORE (902 RV CENTER DR, COLTON, CA 92324, (909) 318-2175) DIAGNOSED THAT THE TRANSFER CASE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

PURCHASED BRAND NEW FORD F-550 ON 11/27/06. ON A ROAD TRIP ON 11/28/06 THE WIFE AND I NOTICED A VERTICAL SHIMMY AT 50MPH. WE CONTINUED TO ACCELERATE AND THE SHIMMY STOPPED UNTIL WE HIT 60MPH AND A HORIZONTAL SHAKING BEGAN. THE SHAKING IS INTERMITTENT BUT QUITE PRONOUNCED. SEVERAL TRIPS TO THE DEALERSHIP FAILED TO CORRECT THE PROBLEM. AT TIMES, AFTER HITTING A BUMP IN THE ROAD, AN UNCONTROLLABLE VIBRATION WITH SHAKE THE ENTIRE VEHICLE FOR SEVERAL SECONDS. THE VIBRATIONS CONTINUE TO THIS DAY VIRTUALLY EVERY TIME THE VEHICLE IS DRIVEN. *TR