2005 Ford F-650 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Ford F-650 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes350.0%
- Fuel system116.7%
- Powertrain (other)116.7%
- Tires & wheels116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
I OWN AN 05 F650 AND A 07 F650 BOTH HAVE FRONT END PROBLEMS AS WELL AS BRAKE PROBLEMS SPOKE WITH FORD THEY WERE NOT WILLING TO WARRANTY A PRODUCT UNDER WARRANTY. *TR
I AM WRITING IN REFERENCE TO A RECALL NOTICE I RECEIVED ON OCTOBER 11, 2005 REGARDING A POSSIBLE DRIVELINE PARKING BRAKE ANCHOR BOLT FRACTURE ON MY F-650 FORD TRUCK. I PURCHASED THIS TRUCK FROM HUBCO FORD IN ALLENTOWN PA. IT HAS SINCE COME TO MY ATTENTION THAT HUBCO FORD, WHERE I PURCHASED THIS VEHICLE, HAS CLOSED ITS DOORS AND NO LONGER CAN SERVICE THIS VEHICLE. NOT ONLY WAS I NEVER NOTIFIED OF THE CLOSURE, BUT ALSO, THE CLOSEST SERVICE CENTER THAT CAN HANDLE THIS SIZE TRUCK, IS LOCATED IN ANOTHER STATE. THIS REPAIR MAY ONLY REQUIRE LESS THAN HALF A DAY TO FIX, BUT IT IS GOING TO TAKE AT LEAST THAT LONG OR BETTER GETTING THE TRUCK THERE AND BACK. THIS HAS CREATED A HARDSHIP IN TRYING TO GET THIS VEHICLE REPAIRED. I BELIEVE THAT IT IS FORD''S RESPONSIBILITY TO NOTIFY CUSTOMERS WHEN A DEALERSHIP HAS CLOSED ITS'' DOORS AND THERE IS NO ONE ELSE WITHIN A 100 MILE RANGE THAT NOT ONLY CAN''T REPAIR THIS VEHICLE, BUT THERE ARE NO DEALERSHIP TO HANDLE POSSIBLE FUTURE PURCHASES OF A VEHICLE LIKE THIS. IT IS MY BELIEF THAT I AM NOT THE ONLY PERSON FROM THIS AREA THAT IS NOW FACED WITH THIS PROBLEM. I SINCERELY THINK THAT FORD CORPORATION NEEDS TO CONSIDER ITS CUSTOMERS NEEDS AND PROVIDE FOR AN ALTERNATIVE METHOD OF REPAIRING THIS VEHICLE, WITHOUT CREATING SUCH HARDSHIP ON THE CUSTOMER. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 FORD F-650 SUPER DUTY. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE FUEL TANK WAS REPLACED. THE FAILURE RECURRED APPROXIMATELY FIVE TIMES. AFTER EACH FAILURE, THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR FACILITY WHERE THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 150,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 FORD F-650 SD. THE CONTACT STATED THAT THE CLUTCH MASTER CYLINDER FAILED BY NOT DISENGAGING THE CLUTCH IN TIME. THE CONTACT APPLIED THE BRAKES TO STOP THE VEHICLE. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR CALL THE MANUFACTURER. THE CONTACT REPLACED THE CLUTCH MASTER CYLINDER AS WELL AS THE CLUTCH. THE REPAIR ONLY REMEDIED THE ISSUE TEMPORARILY. THE FAILURE MILEAGE WAS 103,460.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
2005 FORD F-650 RIGHT REAR TIRE BLEW OUT. WHEN THE BLOW OUT OCCURRED THE DEBRIS RUPTURED THE AIR BRAKE LINE ON ANOTHER VEHICLE. *KB (OHIO TRAFFIC CRASH REPORT)*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .