2021 Ford F-650 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2021 Ford F-650, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes233.3%
- Fuel system233.3%
- Other / unspecified116.7%
- Powertrain (other)116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The driver reported an intermittent burnt oil smell from rear of truck. We found the axle leaking gear oil, with gear oil soaking the brake pads and pooling in the wheel. Took to Ford dealer, where it was confirmed by the dealer and repaired under warranty.
The contact owns a 2021 Ford F-650. The contact stated while releasing the brake pedal and driving from a complete stop, the brake pedal made abnormal sounds. The contact also stated that the parking brake was not operative. The vehicle was taken to the dealer who diagnosed that no issues were found regarding the brake pedal and the abnormal sounds. However, the parking brake was repaired. The contact stated that the brake pedal continued to make abnormal sounds while driving from a complete stop. The ABS and traction control warning lights were illuminated. The vehicle was taken to the dealer where the ABS and the traction control sensors were replaced on the rear passenger’s side of the vehicle; however, the failure persisted. The dealer then replaced the master cylinder however, the brake pedal continued to make abnormal sounds while driving from a complete stop. Additionally, the contact stated that he smelled a burning odor coming from the rear passenger's side of the vehicle. The vehicle was taken to the dealer where it was diagnosed that the brake caliper needed to be replaced; however, the parts for repair were not available. The manufacturer was notified of the failure and advised that the parts were not available. The vehicle was not repaired. The failure mileage was approximately 5,700.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2021 Ford F-650. The contact stated while an employee was driving 65 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended and stalled. The driver pulled to the right side of the road and waited for towing assistance. Several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V455000(Fuel System, Gasoline). The manufacturer was notified of the failure but no assistance was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 146,000.
The contact owns a 2021 Ford F-650. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure until after the recall was repaired; however, the contact was charged for the recall repair. VIN tool confirms parts not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The driver reported an intermittent burnt oil smell from rear of truck. We found the axle leaking gear oil, with gear oil soaking the brake pads and pooling in the wheel. Took to Ford dealer, where it was confirmed by the dealer and repaired under warranty.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The driver reported an intermittent burnt oil smell from rear of truck. We found the axle leaking gear oil, with gear oil soaking the brake pads and pooling in the wheel. Took to Ford dealer, where it was confirmed by the dealer and repaired under warranty.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .