Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain (other) reportsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
10
Latest Jan 9, 2025
Share of all reportsThis category as a share of every owner report on file for this model year. One report can name more than one component, so the categories overlap.
29%
of 35 total
Crash or fire reportedReports in this category whose submitter recorded that a crash or a fire occurred. The reporter's own answer on the NHTSA form, not a verified finding.
1
Injuries or deaths reportedTotals the submitters entered on their own reports in this category. Not verified by NHTSA and not a casualty statistic.
1
What this page shows
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2018 Ford Fiesta submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 10 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Owner reports naming powertrain
Shown in the owner’s own words, exactly as filed
Powertrain (other)
Filed Jan 9, 2025
Hello, I have zero idea why I am emailing, I may be secretly hoping for...anything. I drive a 2018 Ford Fiesta SE, I have owned it since 2019 as that is when I purchased it used. Over the weekend I experienced transmission issues and an auto shop informed me that I am in need of a transmission rebuild due to the clutch going out. The estimated cost is 3.4k. I came across this article from 2019: [XXX] Within the article Ford notes: "The transmissions (dual-clutch automatic transmissions known as DPS6 designed for fuel efficiency) were introduced in the 2011 model year Fiesta and 2012 Focus. They were used until the Focus was discontinued with the 2018 model year and until the 2019 Fiesta". The article then goes onto state: "technical analysis, warranty data and customer feedback show that the DPS6 transmission in Focus and Fiesta vehicles from 2016 (model year) through 2019 MY are improved from prior model years. They perform well and have competitive levels of customer satisfaction.” But I don't believe that to be true given the clutch issues that have just happened with my 2019 Ford Fiesta. It gets a bit more odd because I think Ford is lying about the 2019 model year being 'improved'. The mechanic I am going through put a pause on rebuilding my transmission because Ford reached out to them with potential fixes per an 'internal bulletin'. Those potential fixes include a redesigned clutch kit for the transmission...why would that be a thing if my model year was 'improved'. Also, they are not covering any repairs. I don't even know if I have the right to demand that they do? Given my model year wasn't included in the lawsuit, despite it being the last year Ford made the Fiesta. I also did find this update [XXX] I just want help or something done. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ID
11635077
Incident
Jan 2, 2025
Powertrain (other)
Filed Dec 4, 2023
The contact owns a 2018 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power and the "Transmission Malfunction Service Now” message was displayed. The contact was able to pull over to the shoulder of the roadway. The contact stated that the RPM's increased rapidly, but the vehicle did not respond. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a persistent failure. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 74,000.
NHTSA ID
11558375
Incident
Nov 23, 2023
Mileage
74,000 mi
Powertrain (other)
Filed Nov 27, 2023
Since around 20,000 miles, my 2018 Ford Fiesta SE has had a grinding noise after shifting at certain gears. I got the car serviced at that time. Now I'm at 70,000 miles and the noise has persisted, and has gotten worse. My transmission slipped at 0mph when I was accelerating, almost causing me to lose control of my car.
NHTSA ID
11556942
Incident
Nov 27, 2023
Powertrain (other)
Filed May 16, 2022
The contact owns a 2018 Ford Fiesta. The contact stated that while driving approximately 5 MPH, the vehicle suddenly stalled. The engine failure message was displayed. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 37,000.
NHTSA ID
11464823
Incident
Feb 2, 2022
Mileage
37,000 mi
Powertrain (other)
Filed May 4, 2022
The component that failed was the clutch pedal assembly. The part is currently still installed in the vehicle. The clutch pedal randomly will stay full depressed, and requires manually reaching and grabbing the pedal to pull it out. The operator being distracted because they cant get the car into the correct gear and have to pull off the road to reset/pull the clutch pedal back into position. The component has not be inspected. There were no warning signs or symptoms before the failure happened.
NHTSA ID
11463360
Incident
Feb 24, 2022
Powertrain (other)
Filed Mar 3, 2021
Crash reported1 death reported
VEHICLE DRIVING ON INTERSTATE WHEN A VIBRATION WAS FELT THROUGH THE STEERING WHEEL, THEN THE VEHICLE STARTED LOSE POWER. GEAR SHIFT STILL IN DRIVE ENGINE STILL RUNNING AND COASTED TO A STOP ON SIDE OF HIGHWAY. VEHICLE WAS REAR ENDED FOUND OUT THAT THE LEFT DRIVE AXLE HAD BECOME DISCONNECTED AT THE TRANSMISSION END. WHEN THIS HAPPENS THE SV HAS NO WAY TO MAINTAIN A SAFE SPEED.-++++++*DT*DT*DT*JB*JB*DT*JB*DT
NHTSA ID
11398847
Incident
Apr 26, 2019
Mileage
23,133 mi
EnginePowertrain (other)
Filed Jun 11, 2020
CAR SHUDDERS UPON ACCELERATION FROM STANDSTILL. LOSES POWER SEVERELY GOING UPHILL. ENGINE/TRANSMISSION SHAKES SHUDDERS ENGINE RACES AND QUICKLY ACCELERATES AFTER LOSS OF POWER THEN DECREASES AGAIN. WHEN MOVING FROM STOP CAR SHUDDERS MAKES A GRINDING NOISE AND THEN SLOWLY ACCELERATES BEFORE DECREASING RPM AND THEN RACES AGAIN. *TR
NHTSA ID
11328346
Incident
Jun 20, 2019
Mileage
10,000 mi
EnginePowertrain (other)
Filed Apr 15, 2020
WHILE DRIVING THE AUTOMATIC TRANSMISSION SHUTTERS WHEN GOING INTO SECOND GEAR AND STALLS BEFORE ACCELERATING. SOME TIMES THE CAR WON'T START AND IT'S NOT RELATED TO THE BATTERY OR THE STARTER. IT ALSO HAD A PURGE VALVE REPLACEMENT THREE MONTHS AFTER PURCHASE. A FEW MONTHS LATER I HAD TO REPLACE IT AGAIN THIS TIME IT WASN'T UNDER WARRANTY. I PURCHASED THIS CAR BRAND NEW IN 2018 AND IT HAD ALL THESE ISSUES IN 2018 AND OCTOBER OF 2019 IS WHEN THE TRANSMISSION BEGAN TO SHUTTER. *TR
NHTSA ID
11321226
Incident
Aug 1, 2019
Mileage
70,000 mi
Powertrain (other)
Filed Jul 29, 2019
THE CAR WAS DRIVING AT 68 MPH AND APPROXIMATELY 2500 RPM STARTED TO LOOSE SPEED DOWN SLIGHT HILL AND RPMS INCREASED TO 5,500 RPM. LET OFF THE ACCELERATOR 3 SECONDS RPMS DECREASED REAPPLIED ACCELERATOR AND OPERATED PROPERLY.
NHTSA ID
11240281
Incident
Jun 8, 2019
Mileage
9,200 mi
Powertrain (other)Suspension
Filed Jun 20, 2019
BEEN NOTICING NOW WITH THE FORD FIESTA 2018 THAT MY THIRD GEAR. LOSES THE GRIP GOING UP HILL. BEEN LIKE THIS FOR A FEW WEEKS. I HAVE TAKEN THE CAR TO THE DEALER. TWO TIMES HAVE THEY REPAIR IT. YET, SADLY SEEMS THAT THIS WILL BE THE THIRD AND FINAL TIME. CAN'T BELIEVE FORD DOESN'T DO DURABLE MANUALS ANYMORE. THE ISSUES ARE A LOT ON THE HIGHWAY. CAN'T AFFORD A CRASH OR ACCIDENT.
NHTSA ID
11221498
Incident
Jun 7, 2019
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.