2012 Ford Flex Steering Problems

There is serious safety trouble occurring with the power steering components, and the brake system. I went to the Ford dealership and they said the recalls weren’t fixed back in 2015. And those recalls are the same issues that are occurring with my 2012 Ford Flex SE now. I just bought this vehicle and there is grinding noise when steering my vehicle and the ABS brake system comes on as soon as I crank up the vehicle and the brake goes down to the floor too loosely. The dealership says these potential recalls were noted for this 2012 Ford Flex in 2015. But the owner at the time didn’t have them fixed then because not all 2012 Ford Flex received the recalls at the same time. And the power steering components and brake system problems are very unsafe while I’m driving the vehicle and as I was told could cause a fatal car accident if not fixed.

NHTSA ID

11707935

Incident

Dec 24, 2025

The contact owns a 2012 Ford Flex. The contact stated that while driving at approximately 30 MPH, the ABS and the ESC warnings illuminated. The contact stated that she had recently heard an abnormal grinding sound while turning the steering wheel. The contact had taken the vehicle to an independent mechanic, where it was diagnosed and determined that the ABS sensor needed to be replaced. The contact stated that the mechanic had heard the abnormal sound coming from the steering wheel but had not run a diagnostic test. The vehicle was not repaired. The contact had researched online and had related the failure to NHTSA Campaign Number: 15V340000(Steering), however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.

NHTSA ID

11707853

Incident

Dec 25, 2025

Mileage

180,000 mi

Ford said the recall was fixed 10 years ago, however it went out on me last night. It's been towed to the Folsom Ford dealership in California, they quoted me $3,000 to fix my power steering assistant failure that had a Safety recall and it was a 'safety recall'. I couldn't steer my car. Very scary! please investigate this and make sure that it was fixed right the first time. it should not have gone out. I hardly drive my car. thank you

NHTSA ID

11656456

Incident

Apr 23, 2025

The contact owns a 2012 Ford Flex. The contact stated while the vehicle was parked, the vehicle intermittently became difficult to maneuver. The failure occurred on several occasions, including while the contact was driving. An unknown warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the power steering control module needed to be reprogrammed. The contact researched and was made aware of NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11645654

Incident

Feb 28, 2021

Mileage

40,000 mi

vehicle power steering stops working. Manual steering is extremely difficult to operate.

NHTSA ID

11644653

Incident

Dec 2, 2024

The contact owns a 2012 Ford Flex. The contact stated while his granddaughter was driving 10 MPH and attempting to leave a parking lot, the steering wheel became difficult to maneuver. After the failure occurred, the "Power Steering Assist Fault" message was displayed. The vehicle was parked, and then the contact drove the vehicle to an independent mechanic. The contact was awaiting a diagnostic test from the independent mechanic but was informed that the rack and pinion might need to be replaced and the power train control module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact researched online and became aware of NHTSA Campaign Numbers: 15V340000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 108,000.

NHTSA ID

11605133

Incident

Jul 1, 2024

Mileage

108,000 mi

The contact owns a 2012 Ford Flex. The contact stated while driving 60 MPH, the steering wheel stiffened while attempting to steer the vehicle to the left. The power steering failure message was displayed. The contact used excessive force to steer the vehicle to the shoulder of the highway where the vehicle remained. The contact called the dealer and was informed that the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The contact was referred to the manufacturer who then referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ID

11533612

Incident

Jul 18, 2023

Vehicle power steering will stop working while driving and notification of (power steering assist failure) will appear. Vehicle becomes extremely unsafe to operate as the steering wheel is very difficult to move. I reached out to Ford and was advised that the recall for this was already repaired and a second recall was opened for vehicles that still had the issue. They advised that the recall only extended the warranty to 10 years and my vehicle is a few months past the 10 year mark with exceptions only made for mileage. My vehicle only has 48,000 miles.

NHTSA ID

11524479

Incident

Mar 10, 2023

The contact owns a 2017 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel started to wobble back and forth then up and down. The contact stated that the steering wheel started to shift upward and downward. No warning lights were illuminated. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 110,000.

NHTSA ID

11518318

Incident

Apr 21, 2023

Mileage

110,000 mi

Recall on power steering rack and pinion but my model didn't get covered in this recall and this the second time my service advance track came on and it's totally hard to turn my steering and I took it to Ford dealership in merced ca just to see if the cam turn off my service advance traction they said no because the rack and pinion is bad. . .....

NHTSA ID

11516737

Incident

Aug 1, 2022

Complete loss of power steering and steering effectiveness. Warning message on display said “power steering assist fault”.

NHTSA ID

11512341

Incident

Mar 17, 2023

I went to my local dealership on request of the campaign recall for my associated vin The vehicle has a EPAS STEERING EFFORTS Details Description EPAS STEERING EFFORTS Campaign# 15N01 I was driving and lost control because the power steering went out brought it to my local Ford grieco fort Lauderdale and they diagnosed it as a bad power steering rack pinion which was included in the vin report recall however they stated it's 5 months over expiration which it should of never expired since it's a really bad safety issue. I called Ford directly they told me to contact you in regards to adding a valid recall back onto my vin

NHTSA ID

11473310

Incident

Jul 7, 2022

WIFE RETURNED TO HER CAR AFTER A DAY OF DRIVING TO FIND THE POWER STEERING HAD SUDDENLY STOPPED WORKING. SHE DECIDED TO DRIVE IT HOME AND IT HAD MOMENTS WHERE THE POWER STEERING FUNCTIONED AND LUCKILY SHE GOT IT HOME. I CONTACTED FORD BUT THEY ADVISED ME THAT THERE IS NO ACTIVE BULLETIN FOR THIS PARTICULAR MODEL SO WE WOULD JUST NEED TO FIX IT.

NHTSA ID

11360858

Incident

Sep 22, 2020

Mileage

84,500 mi

TL* THE CONTACT OWNS A 2012 FORD FLEX. THE CONTACT STATED THAT AFTER ENTERING THE VEHICLE, THE STEERING WHEEL SEIZED. THE CONTACT STATED THAT THE POWER STEERING ASSIST WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS ABLE TO DISENGAGE AND DRIVE. THE CONTACT STATED SHE CONTINUED TO EXPERIENCE THE FAILURE. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO LOCAL DEALER PENSKE FORD LOCATED AT 8970 LA MESA BLVD, LA MESA, CA 91942, (619) 464-7777, WHERE IT WAS DIAGNOSED WITH NEEDING STEERING GEAR TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 116,062. *DT

NHTSA ID

11354308

Incident

Aug 19, 2020

Mileage

116,062 mi

I'VE HAD PROBLEMS WITH POWER STEERING FAULTING. I'VE CALLED DEALER AND THEY SAID THEY DIDN'T KNOW ANYTHING ABOUT IT. I WOULD TURN OFF CAR AND IT WOULD WORK AGAIN BUT NOW IT WON'T. THERE IS NO POWER STEERING. THIS HAPPENED AT HOME WHEN I FIRST TURN ON CAR

NHTSA ID

11322875

Incident

Apr 20, 2020

Mileage

85,868 mi

TL* THE CONTACT OWNS A 2012 FORD FLEX. THE CONTACT STATED THE STEERING WHEEL FAILED. THE CONTACT WAS UNABLE TO TURN THE STEERING WHEEL. THERE WAS NO WARNING LIGHT BEFORE DURING OR AFTER THE FAILURE OCCURRED. THE CONTACT WAITED A FEW MINUTES FOR THE STEERING WHEEL TO UNLOCK. THE CONTACT SPOKE WITH (AIRPORT FORD DEALER 8001 BURLINGTON PIKE, FLORENCE KY 41042, (859)371-4750 REGARDING THE FAILURE. THE DEALER ADVISED THAT THERE WAS AN EXTENDED WARRANTY FOR THE STEERING RACK AND THE REPAIR WAS NOT PERFORMED UNTIL THE STEERING WHEEL HAD COMPLETELY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 59,620.

NHTSA ID

11306303

Incident

Jan 23, 2020

Mileage

59,620 mi

MY WIFE STARTED HAVING PROBLEMS WITH HER 2012 FORD FLEX POWER STEERING LAST WEEK. THE MECHANIC INSTALLED A NEW PUMP BUT THAT DID NOT FIX THE ISSUE. THE MECHANIC THEN SEARCHED THE NHTSA DATABASE AND FOUND A RECALL NOTICE FOR 2012 FORD FLEX VEHICLES (STEERING POWER ELECTRIC SYSTEM). HOWEVER, THE LOCAL FORD DEALER SAID OUR VIN WAS NOT INCLUDED IN THE RECALL. I AM HOPING THAT ENOUGH OTHER PEOPLE HAVE HAD A SIMILAR PROBLEM SO FORD WILL ADDRESS THIS ISSUE. THE FORD DEALER AND THE LOCAL MECHANIC AGREED THAT MY WIFE SHOULD NOT BE DRIVING THE VEHICLE DUE TO THE DIFFICULTY WITH MAKING TURNS. PLEASE LET ME KNOW IF OTHERS HAVE REPORTED THIS ISSUE SO WE CAN ADDRESS IT WITH FORD.

NHTSA ID

11242120

Incident

Aug 2, 2019

I AM NOT SURE IF I HAVE TAKATA AIR BAGS, HOWEVER THE AIR BAG LIGHT HAS BEEN ON FOR OVER A YEAR. THE STEERING TAKES ADDITIONAL STRENGTH TO TURN AT LOWER SPEEDS. IT DOES NOT MATTER WHERE THE CAR IS DRIVEN FOR THE STEERING ISSUE, IT HAPPENS ON CITY STREETS, THE HIGHWAY IF TURNING AT SLOWER SPEEDS. THE RACK AND PINION AND POWER STEERING PUMP HAVE BEEN REPLACED DID NOT FIX THE ISSUE.

NHTSA ID

11230509

Incident

Apr 16, 2018

POWER STEERING ASSIST FAILS; DRIVING AND THE POWER STEERING STOPS WORKING, SOMETIMES UNEXPECTEDLY. VERY DANGEROUS! IT IS SPORADIC--SOMETIMES IT WORKS AND OTHER TIMES IT DOES NOT WORK. USUALLY HAPPENS WHEN STATIONARY, AND TURNING IT ON--POWER STEERING WILL NOT ENGAGE FOR SEVERAL SECONDS. ONCE IT HAPPENED WHEN DRIVING AND I WAS LUCKY TO PULL OVER CAR. TURNED IT OFF AND BACK ON AND IT STARTED WORKING.

NHTSA ID

11022692

Incident

Sep 8, 2017

Mileage

50,000 mi

I WAS BACKING MY CAR INTO A PARKING SPACE, TURNING MY WHEEL ALL THE WAY TO THE RIGHT WHEN I HEARO AND FELT A NOISE IN THE STEERING COLUMN AND THEN ALL POWER STEERING ASSIST COMPLETELY ENDED MAKING THE CAR GO INTO MANUAL STEERING MODE. VERY DIFFICULT TO STEER AND POTENTIALLY HAZARDOUS BEING SO SUDDEN. THERE IS A RECALL OUT FOR THE POWER ASSIST STEERING ALREADY AND MY FLEX FITS ALL THE SAME CRITERIA AS THE RECALL YET ITS NOT INVOLVED IN THE RECALL. SAME PLANT, SAME BUILDING YEAR, SAME MODEL YEAR, AND SAME AREA AFFECTED AS OTHER CARS IN THE RECALL BUT MY VIN ISN'T INCLUDED. THIS IS NOTHING THAT I'VE DONE TO THE VEHICLE PERSONALLY TO MAKE THE POWER STEERING MALFUNCTION. I BELIEVE IT'S A MANUFACTURER ERROR THAT NEEDS REPLACED IN THE RECALL. IT COULD HAVE BEEN VERY DANGEROUS AS I WAS IN AN ELEMENTARY SCHOOL PARKING LOT WITH ALOT OF LITTLE KIDS WALKING AROUND ALSO HAVE 3 IN THE CAR WITH ME. MY HUSBAND WAS LIED TO MULTIPLE TIMES OVER THE PHONE FROM FM EMPLOYEES ABOUT THE NATURE OF THIS RECALL AND HOW OR WHY OUR VEHICLE WASN'T INCLUDED. OUR VEHICLE CAME OUT OF THE SAME PLANT DURING THE SAME TIME THE OTHER AFFECTED VEHICLES DID AND IS HAVING THE SAME ISSUES AS THOSE AFFECTED AND SHOULD BE COVERED UNDER THE RECALL.

NHTSA ID

10898989

Incident

Aug 24, 2016

WHILE DRIVING I EXPERIENCED A TOTAL LOSS OF POWER STEERING AND THE DASHBOARD FLASHED "POWER ASSIST FAILURE". THIS HAPPENED FOUR TIMES OVER THE COURSE OF TWO WEEKS. I'VE TAKEN THE CAR IN TO SOUND FORD IN RENTON, WA AND WAS TOLD THAT THIS IS A KNOWN RECALL ISSUE (#15S18). MY COMPLAINT IS WITH REGARD TO THE PART NEEDED TO REPAIR THE PROBLEM. BOTH THE DEALER AND THE FORD CUSTOMER RELATIONSHIP CENTER HAVE TOLD ME THAT THE PART ( A STEERING GEAR) IS ON ENDLESS BACKORDER DUE TO MANUFACTURING DELAYS. DRIVING THE CAR AT THIS POINT IS DANGEROUS AND I'M LOOKING FOR SUPPORT IN GETTING THE REPLACEMENT PART FROM FORD AND HAVING THE REPAIR DONE.

NHTSA ID

10823784

Incident

Jan 4, 2016

Mileage

45,000 mi

I WAS DRIVING IN TRAFFIC WHEN A WARNING SOUNDED AND MY DASHBOARD DISPLAYED THE MESSAGE "POWER STEERING ASSIST FAILURE". STEERING BECAME EXTREMELY DIFFICULT. I PULLED INTO A SERVICE STATION AND SHUT OFF THE ENGINE. WHEN I RESTARTED THE ENGINE, THE STEERING PROBLEM HAD RESOLVED ITSELF. APPROXIMATELY AN HOUR LATER, THE SAME PROBLEM REPEATED ITSELF. AN INTERNET SEARCH REVEALED THAT MANY OTHER DRIVERS OF FLEX VEHICLES HAVE EXPERIENCED THE SAME PROBLEM. I CONTACTED FORD AND THEY SAID, WHILE OTHER FORD MODELS HAVE BEEN RECALLED FOR A SIMILAR PROBLEM, THE FLEX IS NOT NAMED IN ANY OF THEIR NOTICES. AT THIS TIME THEY SAID THEY HAVE NO PLAN FOR ANY FOLLOW-UP ACTION. BECAUSE OF THE LOSS OF STEERING CONTROL THIS IS A SAFETY ISSUE THAT SHOULD BE ADDRESSED BEFORE SOMEONE GETS KILLED. *TR

NHTSA ID

10630416

Incident

Aug 30, 2014

Mileage

56,100 mi

TRAVELING STRAIGHT DOWN A MAIN, 2 LANE ROAD, THE VEHICLE CHIMED AND I RECEIVED TWO ERRORS ON THE DIAGNOSTIC SCREEN. FIRST WAS FOR POWER STEERING ASSIST FAULT AND THE SECOND WAS ADVANCE TRAC FAULT. THE POWER STEERING ASSIST WAS DISABLED AND THE STEERING WHEEL HAD GONE STIFF. I WAS ABLE TO DO A ROLLING RESTART (NEUTRAL, KEY OFF, RESTART, BACK INTO DRIVE) WITHOUT INCIDENT, THE WARNINGS ON THE DASH CLEARED, AND THE POWER STEERING WAS RESTORED. GIVEN ANY WINDING ROAD OR TURNING INTO OR OUT OF TRAFFIC SCENARIO, THIS COULD HAVE BEEN MUCH MORE TREACHEROUS. I FELT I SHOULD BRING THIS TO YOUR ATTENTION, AS IT APPEARS THIS IS A COMMON SITUATION, EVIDENCED BY AN INTERNET SEARCH. *TR

NHTSA ID

10620756

Incident

Aug 6, 2014

Mileage

41,600 mi

FIRST INCIDENT HAPPENED WHILE DRIVING ABOUT 40 MILES AN HOUR. IDIOT LIGHTS CAME ON THE DASH AND THE CARS ENGINE TURNED OFF. THANKFULLY I WAS ABLE TO GET CAR OFF TO THE SIDE OF ROAD. CAR CRANKED RIGHT BACK UP. 5 DAYS LATER WHILE SITTING IN A FAST FOOD LINE, SAME THING HAPPENED AND WAS ABLE TO CRANK CAR. CALLED DEALERSHIP IN TOWN, BROUGHT CAR IN AND THEY SAID, "NOTHING IS WRONG WITH YOUR CAR, COME AND GET IT" PICKED UP CAR. 2 DAYS LATER WHILE DRIVING IT DOWN OUR STREET, I STOPPED TO GET MAIL ABOUT 9PM AND THE CAR TOTALLY DIED. NO POWER AT ALL. WAS STUCK IN PARK HAD TO BE TOWED. THIS IS A VERY DANGEROUS SITUATION. THE CAR SHUTS DOWN WHILE I AM DRIVING!!! THANK GOD THAT IT HAS NOT HAPPENED WHILE GOING 65 MILES AN HOUR WITH MY FAMILY IN THE CAR. CAR IS AT DEALERSHIP. HAVE ONLY HAD THE CAR SEVERAL MONTHS. NOT A GOOD TRACK RECORD SO FAR! *TR

NHTSA ID

10482817

Incident

Oct 29, 2012

Mileage

5,020 mi