2018 Ford Flex Problems

The contact owns a 2018 Ford Flex. The contact received a notification of NHTSA Campaign: 25V732000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front driver-side B-pillar trim with the Security Key pad had detached and almost struck nearby vehicles. The contact stated that she managed to pull over on the shoulder of the road; however, the vehicle independently locked, leaving the occupants on the shoulder of the road temporarily. In addition, the contact stated that while driving at an undisclosed speed on another occasion, the front Passenger-side B-Pillar trims had detached. The vehicle was taken to a local independent mechanic, where it was repaired out of pocket; however, the front Driver-side B-Pillar trim had detached, and upon further inspection, water would intrude through the missing, failed parts. The local dealer was contacted. It was unknown whether the vehicle was diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

The contact owns a 2018 Ford Flex. The contact stated while reversing, the rear view camera displayed a solid green screen. The contact stated that because of the failure, the contact almost crashed into another vehicle. The contact stated that the failure occurred intermittently. In addition, the B- Pillar on the driver's side rear door was detached. The vehicle was taken to the dealer, however the vehicle was not inspected. The contact was informed that the parts were unavailable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received recall notifications: NHTSA Campaign Number: 25V695000 (Back Over Prevention) and NHTSA Campaign Number: 25V732000 (Structurer) however the parts were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

Recall has not been remedied, and it has been over six months.I was told it would be remedied by june or ford would be held accountable for compensating for repairs on the.Recall. #25SA9/25v695 The recall addresses the camera for backing up witch is still not functioning in a safety risk.

The warning shows that the blind spot sensor is not working.

Recall has not been remedied, and it has been over six months.I was told it would be remedied by june or ford would be held accountable for compensating for repairs on the.Recall. #25SA9/25v695 The recall addresses the camera for backing up witch is still not functioning in a safety risk.

Have been waiting for several months for Ford to remedy BOTH recalls. There obviously is no important reason for them to be productive and do the right thing so this issue will likely never be resolved unless I take action and file a complaint. The two issues are not even that critical so I further don't see why action has not been taken. 1. Interior A pillars separating. 2. Back up camera screen on infotainment center.

Wile driving 40 mph, the right rear tire locked up and I had to counter steer aggressively to avoid spinning out and hitting oncoming traffic. The car was flat bed delivered to Ford and they recommended the following repairs. "Control Arm- Rear: rear suspension lateral links. The rear upper and lower control arms not only provide suspension travel but also secure the rear end to the vehicle." "*Tires - 4: passenger rear inner sidewall damaged."

The Left driver side rear suspension toe link broke on expressway, resulting in loss of control had to aggressively steer out of a spin. Car was undrivable and had to have towed and repaired, had passenger side rear suspension toe link go bad in December of 2024. Repair documentation available upon request.

VEHICLE IS NOT GETTING RECOMMENDED MILEAGE AND IS HARD SHIFTING

BRAND NEW CAR 30 DAYS OLD. CAME HOME AND PARKED IN OUR FLAT DRIVEWAY AND PUT SHIFTER IN PARK. TURNED ENGINE OFF AND OPENED CAR DOOR TO GET OUT AND CAR BEGAN TO ROLL BACKWARDS TOWARD THE STREET. HAD TO JUMP IN BEFORE I OR OTHER PEOPLE GOT RUN OVER. PUT FOOT ON BRAKE. SHIFTER CLEARLY IN PARK. CAR ENGINE CLEARLY OFF. TAKE FOOT OFF BRAKE AND CAR CONTINUE TO ROLL BACKWARDS. TRIED TO START CAR BUT CAR WOULD NOT LET ME. PUT EMERGENCY BRAKE ON AND TURNED CAR TO AUXILIARY POWER. DISPLAY SHOWS R (REVERSE) EVEN THOUGH SHIFTER IS IN PARK. SHIFTER CANNOT BE MOVED. HAD TO HAVE TOW TO DEALER. ADVISED CABLE SHIFTER BROKE (INVOICE ATTACHED). JUST ALERTING NHTSA SO THAT YOU ARE AWARE. VERY DANGEROUS WHEN OPERATOR PUTS CAR IN PARK, TURNS ENGINE OFF AND EXITS VEHICLE, AND CAR ROLLS BACKWARDS OUT OF CONTROL. SHOULD NOT HAPPEN ON ANY CAR LET ALONE A BRAND NEW ONE.

The contact owns a 2018 Ford Flex. The contact stated that while her husband was driving at 75 MPH, the vehicle lost power steering functionality. The contact was unsure whether a warning light was illuminated. The driver pulled to the side of the road. The vehicle was towed to an unknown dealer, where it was diagnosed that the steering gear had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 75,186.

WHILE DRIVING THE VEHICLE (IT WAS IN MOTION), ON HWY 290 (NEAR MANOR, TX), THE STEERING ON OUR 2018 FORD FLEX SEIZED UP AND THE CAR WAS IMPOSSIBLE TO TURN. DUE TO COMPLETE LACK OF STEERING, THE CAR WAS AN IMMEDIATE DANGER TO DRIVE AND IT WAS EXTREMELY DIFFICULT TO GET SAFELY OFF THE ROAD, BUT MY HUSBAND WAS ABLE TO DO SO. HE WAS LUCKY TO AVOID A MAJOR COLLISION. THE NEXT DAY WE CALLED FOR THE CAR TO BE TOWED TO THE DEALER. THE TOW TRUCK DRIVER WAS ABLE TO START THE CAR WITHOUT ANY ISSUE. WITH EXTREME MANUAL FORCE APPLIED, THE TOW TRUCK DRIVER WAS BARELY ABLE TO TURN THE CAR ENOUGH IN ORDER TO GET IT ONTO THE TOW TRUCK. ONCE THE CAR WAS RECEIVED BY THE DEALER, THE SERVICE ASSOCIATE CONFIRMED THIS 'STEERING FAILURE' WAS A PROBLEM THEY HAD SEEN COME UP A FEW TIMES IN THE PRIOR WEEKS WITH OTHER FORD MAKES AND MODELS. THEY SAID IT WAS A COSTLY REPAIR AND I SHOULD BE LUCKY BECAUSE WE BOUGHT THE EXTENDED FORD WARRANTY PROGRAM AND THEY WOULD CALL ME LATER TO CONFIRM AFTER A DIAGNOSTIC WAS COMPLETED. LATER THAT DAY THEY CALLED ME AND SAID THEIR DIAGNOSTICS CONFIRMED THE STEERING FAILURE, THAT IT WAS COVERED BY WARRANTY AND MAY TAKE A FEW DAYS AS A MAJOR REPAIR FOR THE STEERING SYSTEM. 3 DAYS LATER, THEY DENIED ANY STEERING FAILURE, AND CLAIMED IT WAS A FAILED BATTERY INSTEAD. DESPITE OUR COMPLAINT, THEY CHARGED US $500 FOR A NEW ONE. AS A RESULT OF THIS SITUATION, WE SOLD THE CAR (AS A DEATH TRAP), CANCELLED OUR FORD EXTENDED WARRANTY AND SOLD ALL OF OUR FORD STOCK. I HOPE SOMETHING IS DONE ABOUT THIS BEFORE THEIR STEERING FAILURES KILL INNOCENT PEOPLE. IF I SEE A FORD ON THE ROAD, I WILL BE GIVING THEM A WIDE BERTH.

I was waiting for my stop light to turn green at 39th street and southwest traffic-way, when my light turned green I started pulling through the intersection. I noticed a car coming towards me on southwest traffic-way at a high rate of speed. I hit the breaks thinking that this person is not going to stop. The vehicle proceeded to run the red light and hit the front passenger side of my vehicle at a high rate of speed and sent my 2018 Ford Flex spinning through the intersection. Not a single airbag went off in my vehicle, that is terrifying to me being a father of 3 young children I am blessed that they were not in the vehicle when the accident happened. The police showed up on the scene within minutes of the accident, the other driver took off running on foot. The police seemed confused as to why my airbags didn’t deploy, as well as the tow truck driver that hauled my vehicle away. The main component that I am reporting is that the airbags did not work or deploy, as a standard safety measure in vehicles I believe that is a big safety problem. The vehicle has been marked as a total loss by insurance.

TL* THE CONTACT OWNS A 2018 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE REAR-ENDED THE VEHICLE IN FRONT. THE AIR BAGS DID NOT DEPLOY. ADDITIONALLY, THE CONTACT HAD A FRONT SEAT PASSENGER AND A REAR PASSENGER. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED ON THE SCENE AND THE SPOUSE DROVE THE CONTACT AND THE FRONT PASSENGER TO THE HOSPITAL AFTERWARDS FOR A CHECK UP. THE VEHICLE WAS DAMAGED BUT WAS NOT TOTALED. THE VEHICLE WAS TOWED TO A COLLISION CENTER. THE CONTACT CALLED THE POWER GM DEALER, (330-303-4094, LOCATED AT 15482 OHIO 170, CALCUTTA, OH 43920) AND WAS REFERRED TO THE DONNELL FORD DEALER LOCATED IN BOARDMAN, OH (330-726-8181). THE DEALER WAS CALLED BUT THERE WAS NO RESPONSE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

Wile driving 40 mph, the right rear tire locked up and I had to counter steer aggressively to avoid spinning out and hitting oncoming traffic. The car was flat bed delivered to Ford and they recommended the following repairs. "Control Arm- Rear: rear suspension lateral links. The rear upper and lower control arms not only provide suspension travel but also secure the rear end to the vehicle." "*Tires - 4: passenger rear inner sidewall damaged."

While driving in a 35mph zone, a complete loss of braking was experienced while coming up to an intersection. The vehicle was unable to stop, not even emergency brake function worked. An independent service center did a postmortem of the brake caliper and confirmed the fastener failure of the caliper bracket. The caliper fasteners sheared off inside the caliper resulting in the caliper piston falling apart while driving. This resulted in complete brake malfunction, and brake fluid leakage. There was no warning or message for this failure. The brakes experienced complete failure without warning.

VEHICLE IS NOT GETTING RECOMMENDED MILEAGE AND IS HARD SHIFTING

ENGINE STOPPED WHILE DRIVING IN WALMART PARKING LOOT. WOULD NOT START. TOWED TO GARAGE WHO TRACED THE CAUSE TO. FUEL PUMP CONTROL MODULE. THERE IS AN EXISTING RECAL FOR THIS PROBLEM FROM 2013 TO 2014 FORD FLEX HOWEVER MY VIN SHOWS AS NOT COVERED. WHATEVER CRITERIA TO LIMIT RECALL APPEARS TO BE INVALID

MY FORD FLEX IS EQUIPPED WITH HANKOOK OPTIMO H426 TIRES. AT APPROXIMATELY 9,500 MILES THE VEHICLE BEGAN TO VIBRATE. I'VE TAKEN IT TO THE SHOP 5 TIMES AND EVERYTHING EXCEPT THE TIRES HAS BEEN RULED OUT. AFTER VISITING A WEB SITE I FOUND LITERALLY HUNDREDS OF COMPLAINTS ABOUT THESE TIRES CAUSING EVERYTHING FROM VIBRATION TO BLOWOUTS. I AM CURRENTLY DRIVING A RENTAL WHILE MY CAR IS IN THE SHOP THAT HAS THE SAME TIRES. IT HAS THE SAME VIBRATION. THE EVENT GENERALLY BEGINS AT ABOUT 60 TO 65 MPH HOWEVER THE VIBRATION HAS BEEN NOTICED AS LOW AS 40 MPH. WHEN IT STARTS AT A LOW SPEED IT TURNS INTO A VIOLENT SHAKING THAT SCARES THE HECK OUT OF ME ENOUGH THAT I PULL OFF THE ROAD AND WAIT UNTILL MY NERVES SETTLE TO CONTINUE DRIVING. TODAY IS FEBRUARY 14 2020. THE VIBRATION HAS BEEN OCCURING SINCE ABOUT OCTOBER 25 2019.

HANKOOK OPTIMO TIRES CHUNKING AT 24100 MILES SEVERE ENOUGH TO BE UNSAFE TO DRIVE.. NOTICED AT AROUND 12000. NORMAL STREET AND HIGHWAY DRIVING.

An antifreeze leak is very hard to locate because Ford’s design placed the water pump INside the engine rather than on the OUTside, which would be more the norm. If antifreeze leaks enough, it gets into the oil and the entire engine stands to be destroyed. Our heater quit blowing warm air recently and after intently searching we discovered that we had an antifreeze leak inside of our engine, and antifreeze was slowly leaking out through a weephole in the engine. The water pump had gone bad and needed replacing. The hours required to replace this water pump are intense and they are long. Almost the entire engine needs to be dismantled in order to perform the work. Not only does the pump need changed, but so does the timing chain, hoses, seals, gaskets, tensioners and other engine parts, all at the same time, making this a VERY costly out-of-pocket expense for us elderly people who have long relied on Ford’s standard of doing what’s right by its people. In our research we found that the water pumps in Flex engines are failing, regularly, once the vehicle is close to having 80,000 miles on it. This repair most DEFINITELY should be covered by recall since it is happening so regularly. We have just been forced to pay for this repair on our own and I would like to please ask for your help in recovering what we’ve had to spend. Will you please provide contact information as to where we can reach out for assistance in this matter? Your help is VERY much appreciated! Thank you!