Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2016 Ford Focus submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 83 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 83, in the owner's own words
Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.
We bought this vehicle from Carvana in February 2023. Since very early on owning this vehicle, the engine hesitated and stuttered when trying to shift from first to second gear, and would lunge forward slightly. In December 2024, I received a letter from Ford Motor Company about a customer satisfaction program, Campaign 24N07. The letter addressed the symptoms my vehicle exhibited, including engine hesitation, engine running rough, and engine stalling at low speeds, though the check engine light was not on. The letter states that Ford Motor Company provides a one-time replacement of the canister purge valve, given these symptoms and the check engine light being on. When I called all the local Ford dealerships, they refused to do it because the check engine light was not on, and that Ford Motor Company issued this as a customer satisfaction program, rather than a safety recall.Everything that was listed in Campaign 24N07 is MOST DEFINITELY a safety issue, and should not be taken lightly. It is highly concerning that Ford Motor Company didn’t think to consider ENGINE ISSUES a safety recall. The class action lawsuit Vargas et al v. Ford Motor Company had a deadline of November 4, 2020, which was 2 years and 3 months prior to us buying the vehicle, so any vehicles of the affected years and models should have been either repaired, or not allowed to be sold unless the repairs were done by an authorized Ford dealership. This information was not told to us when we bought the vehicle.On May 25, 2026, while driving, the engine fault and steering assist fault warnings came on, as well as the check engine light. When we were able to safely park the car, we discovered the entire power train is non operational. The engine no longer turns over, and we are now having to buy a new car.
[XXX] driving her 2016 ford focus hit me [XXX] she claims her btakes did not work hitting multiple times she hit me so hard her car flew many feet back. I believe her car was defective it was alittle snowy but nothing bad. [XXX] said her brakes did not work at all. Me and multiple cars were able to come to complete stop with no skidding i have toyota rav4. I think her car might have been told my car needed repairs. I was severely injured severe permanent concussion brain neck back shoulder arm hand chest back muscle nerve damage. Dunno if [XXX] was also injured INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am writing to file a formal complaint regarding an ongoing mechanical issue with my 2016 Ford Focus. Although my vehicle currently shows zero active recalls, I have experienced a recurring and concerning problem. Each time I turn on the air conditioning and the air begins to blow cold, my engine temperature rises significantly and causes the vehicle to overheat. This issue occurs consistently and makes it unsafe to operate the vehicle while using the air conditioning. Overheating poses a serious safety risk and may lead to engine damage or sudden breakdowns. Given that this problem appears to be directly connected to the operation of the air conditioning system, I am concerned that this may be a known defect or design issue that has not been addressed through a recall. I am requesting that this issue be formally documented, investigated, and addressed. I would appreciate guidance on next steps, including inspection, repair options, or whether this issue has been reported by other 2016 Ford Focus owners. Thank you for your time and attention to this matter. I look forward to your prompt response.
This vehicle been having problems with heater
I was driving the car other all of a sudden died on me and told me to put it in park I put it in park and then turned the key off and tried to restart it. It did not restart and would not turn of kept popping up a warning saying starter system failure. Could not turn my wheel or pit it in neutral to get it out of te middle of the road.
The car failed to start, it did not recognize it was in park. After trying to start my car with the keys it failed. My safety is put at risk, my car failing to recognize which gear shift it is in causes malfunctions while I am on the road, especially since I drive long distances at high speeds. I had a Master Technician review and preform a diagnostic on my vehicle and the codes formed for this test matched hand in hand with TCM issues under the TSB. After this, I went to the dealership to discuss this issue and the only thing that came of it was informing me that I was not eligible for a recall due to my VIN, even if I have all the symptoms under the TSB for my Ford Focus 2016. Since my car failed to start I was not able to bring it to Ford and have it tested, especially after asking if it is eligible and they insisted that it was not. No warning signs from the dashboard appeared on my vehicle to inform me of this issue. I travelled to meet with family and did not end up using my vehicle for a few days and when I tried to start my car, it would not engage. The only warning sounds I would consider a correlation before the problem would be a clicking from the starter pre-firing when I opened the door, and while the car was off.
The contact owns a 2016 Ford Focus. The contact stated while driving at an unknown speed, an alarm sounded, the message " Pull Car Over Safely " was displayed, and the vehicle turned off independently. The contact stated that the vehicle was turned off and was restarted several times; however, the failure persisted. The vehicle was taken to a dealer to be diagnosed; however the dealer was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate mileage was 67,855.
I’m having a very difficult time with ford dealership there is a lot of information about this 2016 ford focus automatic transmission that has problems with either its dry clutch or the tcm transmission control module. It is revving high when you stop it doesn’t shift gears properly it jerks hard it won’t go into higher gears it will start reversing out of no were that’s a very very terrifying situation especially that me and my fiancé have a little boy in this vehicle. We were so happy to buy this vehicle and ended up having huge problems for only having 100k miles on the odometer. This is are only vehicle spent are taxes on this vehicle to get us around for a few years go on vacations all that. To call ford and be told basically if this vehicle wasn’t involved in the lawsuit against ford about this certain situation then it wouldn’t be included in the recall. I think I should file a lawsuit against ford for this why would they have on the web that every 2016 ford focus has a recall for the tcm transmission control module one time free replacement until June 2025 it says. I want something done this is not right and illegal. Organization at its finest.
The contact owns a 2016 Ford Focus. The contact stated that while his daughter was driving at an undisclosed speed, the vehicle inadvertently lost motive power. The driver was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed the dealer, who diagnosed a failure with the Remote Function Actuator (RFA) module. The vehicle was not repaired due to a lack of available parts. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 90,000.
The contact owns a 2016 Ford Focus. The contact stated that the vehicle failed to start. There were no warning lights illuminated. There was an unknown failure with the battery. The vehicle was taken to the local dealer, where it was diagnosed and determined that the TCM needed to be replaced, but the clutch was unrepairable. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 58,500.
While driving my car started skipping from first to second gear and then lowering acceleration. When at a complete stop car would not accelerate and just revs through first and second gear making a pinging clicking sound. Brought to dealership to be told codes p0702 and code p0734 were reading. I've had the car one year and has been maintained. Before I got the diagnosis I drove to the dealership there was no lights on even though there was the issue and then right as I pulled in the transmission light check came on. This problem has been confirmed by Ford dealership from transmission and engine diagnostic. Not being able to accelerate at a green light put my safety at risk.
Faulty dual clutch. I only have 34000 miles on it. I shouldn't have this problem . Started 2 weeks ago .very rough shifting. Sometimes it won't shift at all.
Electrical power steering goes in and out and the dash displays “steering assist fault” warning, and the power steering goes out entirely. You can still turn, but it takes a lot more physical effort to do so. Since it goes in and out, it can happen at any time and is very hard to get diagnosed through a diagnostic if the mechanic or dealer cannot replicate the issue.
on 6/27/2024 when accelerating into traffic my vehicle stalled and almost caused an accident. Dash board display had two messages was code P0106 MAP sensor and hill start assist wasn't going to work. Possible safety recall 14S17 Saying not for my vehicle.
My radio stopped working and is now making horrible loud screeching and popping noises loud enough to startle me and almost cause a crash from the reaction I have to the loud sudden noises
The contact owns a 2016 Ford Focus. The contact stated while driving 50-55 MPH, the steering wheel locked inadvertently. The message "Transmission Failure" was displayed. The contact veered to the side of the road and turned on the hazard lights. The contact stated that the vehicle continuously lost and regained electrical power independently. The vehicle was towed to an independent mechanic, where the contact was informed that the transmission was malfunctioning, and the contact was referred to the dealer. The vehicle was towed to the dealer, where the TCM was replaced. Additionally, the dealer informed the contact that the transmission clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 19N08. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,069.
[XXX] daughter was driving her car on I87 in Albany NY when oil pressure light went on and car speed dropped from 65 to less than 30 while in middle lane of interstate forcing her to cross over lanes onto shoulder roadway and exit ramp where it lost all power. Have learned that the oil belt system failed without any warning or notice causing incident. Have since learned that vehicle motor has been damaged beyond repair and needs replacement. Contact with 4 separate representatives of FORD Customer Service has resulted in FORD denying our requests for assistance to replace the motor. Car is a 2016 Ford Focus SE with the 1.0 liter motor with 81,000 miles. Well maintained with records as needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle hesitates, stutters and stalls when accelerating at any speed. The dealership told us it is either a transmission module or fuel module problem. They don’t have parts to fix it. There’s been a recall and a lawsuit about this same year, make and model, but they tell us our Vin is not included in any of this. it continues to do this to this day. The dealership wants us to drop it off and leave it for 3 to 4 weeks. We can’t be without a car so we are struggling with it. We wrote Ford Motor Company a letter and they told us to contact you. The lawsuit that they lost, gave us an extended warranty, but they refuse to honor it.
Radio will randomly cause a loud popping or screeching sound from the speaker while driving this is a common issue know by ford dealers that requires replacing the ACM witch is $800 for just the part.
The lug nuts are swollen and cannot be unscrewed. Also my electrical system inside my car goes off sometimes for unknown reasons. I'm talking about my stereo.
Car turned off while driving three times. Once when put in park it locked on a busy road. Replaced fuse to battery, still turned off while driving. Lights stay on and its a pretty new battery so thats nit the issue, when turning the key there is no noise, no clicking or grinding. Main issue is the fact it turns off while driving and the fact it locks up when put in park. That's helpful to no one. Windows can't be rolled up either which meant being trapped guarding a vehicle in 92 degree weather. Anti theft is literally so dumb and in annoying. Great thought, terrible in practice. Am currently waiting on tow truck. Open invention on what caused this now.
My car has become hard to start after I fill up with gas. It also randomly loses all power. While driving everything in the car stops. It displays a message that says transmission is not in park, like I turned the key off but I did not. After this it won't start and displays a message on the dash that says "system start up fault". If I wait a few minutes it starts again . This has happened 3 times. I had a mechanic pull any codes. The only code is for a gasket in the evap system. The mechanic told me that Ford had a recall for this problem so I had the car towed to a Ford service center. The Ford dealer told me that my car is not included in the recall. I looked up Ford recalls and my car exhibits all of the problems described in the recall.
2016 FORD FOCUS VIN: 1FADP3F20GL341128 Mileage: 64,750 Hello I am having problems with my 2016 Ford Focus. The vehicle is shuddering, moving forward, problems in shifting, vibrating and Ford cannot do anything about this as they have told me that you have not added this model on the recall. I got the vehicle checked over by Ford and they said it is the same issues as the other Ford Focus and Fiesta have and they said they need to replace the clutch and TCM. However this would be charable to me because you have not added this model in the recall. At the Sound Dealership in Renton WA there was 3 cars with the same issue and one being the same fuel flex model as mine. Is this something you could check as Ford will not help me at all. Thank you
Transmission Fault Service Now warning light keeps coming on and off. I’ve taken it to multiple places to have it checked out and nobody can find and actual issues that would cause the transmission to fail. I got stuck in the middle of an intersection because the transmission randomly stopped. I’ve had to have it towed.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .