Owner-reported complaints naming the airbag system, filed with NHTSA
Data refreshed
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights. Every record below is an owner-reported complaint about the 2005 Ford Freestar submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT COULD HEAR PIECES OF THE FRONT DRIVER SIDE AIR BAG ROLLING AROUND IN THE AIR BAG COVER. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.
THERE ARE SOUNDS OF LOOSE PIECES IN THE STEERING WHEEL AROUND OR INSIDE THE AIRBAG. IT SOUNDS LIKE LOOSE MARBLES INSIDE. *TR
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH, THE REAR PASSENGER SIDE TIRE FAILED, WHICH CAUSED BOTH CURTAIN AND PASSENGER SIDE AIR BAGS TO DEPLOY ERRONEOUSLY. THE DRIVER SUSTAINED MINOR BRUISES TO THE FACE FROM THE AIR BAG DEPLOYMENT. THE TIRE WAS REPLACED AND THE AIRBAGS WERE CUT. THE VEHICLE WAS LATER TAKEN TO A DEALER WHERE IT WAS CONFIRMED THAT THE AIR BAG SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 181,000.
IN DECEMBER 2010 I WAS AT A STOP LIGHT, WHEN I WENT TO ACCELERATE THE CAR WOULDN'T MOVE. HAD IT TOWED TO A TRANSMISSION SHOP AND THEY REBUILT IT. IT HAS GONE BACK 3 TIMES DUE TO CONTINUING OF PROBLEM AND THE CHECK ENGINE LIGHT KEEPS COMING ON AFTER THEY TURN IT OFF. SINCE LAST VISIT, NOW THE AIR BAG LIGHT IS ON, CHECK ENGINE LIGHT IS ON AND THE HORN NO LONGER WORKS WHEN PUSHED BUT IT OCCASIONALLY HAS GONE OFF FOR NO REASON. STILL HAVE PROBLEMS ACCELERATING, IS SLUGGISH, AND MAKES A HORRIBLE NOISE. IT NEEDS TO BE SMOGGED BUT WILL NOT PASS DUE TO THESE ISSUES. *TR
TL*THE CONTACT OWNS A 2005 FORD FREESTAR . THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT HAD BEEN ILLUMINATED ON THE INSTRUMENTAL PANEL SINCE DECEMBER 2010. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HER THAT SHE NEEDED TO REPLACE THE CLOCK SPRING. THE VEHICLE HAD NOT BEEN REPAIRED AS THE PART WAS UNAVAILABLE AND THE DEALER ADVISED HER TO NOT DRIVE THE VEHICLE BECAUSE THE AIR BAGS WOULD NOT DEPLOY IN THE EVENT OF A CRASH. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000. UPDATED 03/24/11*LJ UPDATED 04/22/11
DRIVER SIDE AIR-BAG DID NOT REACT TO CRASH BUT PASSENGER SIDE DID. *TR
TL*THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE AIR BAG INDICATOR LIGHT ILLUMINATED. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT IT WOULD COST $99 FOR A DIAGNOSTIC. THE FAILURE MILEAGE WAS 57,500 AND CURRENT MILEAGE WAS 57,600. UPDATED 06/17/08. *LJ THE CONSUMER STATED HE STRUCK THE PASSENGER SEAT WITH HIS FIST AND WHEN HE STARTED THE VEHICLE, THE AIR BAG LIGHT WENT OUT. UPDATED
AIR BAG LIGHT INDICATING THE AIR BAG WOULD NOT DEPLOY IN CASE OF AN ACCIDENT STAYED ON. DEALERSHIP SUGGESTED THAT THE LIGHT COULD COME ON IF I WERE USING AN AFTERMARKET CELL PHONE CHARGER WHILE DRIVING THE VEHICLE. FORD ISSUED AN ALERT TO DEALERSHIPS THAT STATED SAME. I WAS MADE TO GO OUT AND BUY REPLACEMENT CHARGERS WHILE THE DEALERSHIP INVESTIGATED THE PROBLEM USING MY CAR CHARGERS TO EXPERIMENT. AFTER PICKING UP THE VEHICLE THE LIGHT HAD NOT COME BACK ON. I WAS TOLD THE FORD INSTRUCTED THEM TO REPLACE THE COMPUTER LOCATED NEAR THE RADIO. I AM STILL SHOCKED TO HEAR THAT A CELL PHONE CHARGER COULD CAUSE AN AIRBAG TO NOT DEPLOY. FORD ISSUED AN EXTENDED WARRANTY FOR THIS VEHICLE GIVEN THE SERIOUS NATURE OF THE FAILURE. *NM
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .