2006 Ford Freestyle Body & structure Problems

Took the vehicle in to local Ford for 120000 mile service and was informed the subframe was rusted and starting to separate. The part is no longer available and maybe they could find a used one as they have had to do in other cases. Not sure why just the front subframe is bad and no other part of the frame structure also the car has had rustproofing done on it. Reading on the internet this seems to be a common problem with these subframes.

NHTSA ID

11466341

Incident

May 17, 2022

The contact owns a 2006 Ford Freestyle. The contact stated that she noticed that after it rained, the front passenger’s side floor would fill up with water. The contact was unsure where the leak was located. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 139,372.

NHTSA ID

11432476

Incident

Jul 15, 2021

Mileage

139,372 mi

WENT FOR A STATE INSPECTION IN AUGUST. THE CAR PASSED, HOWEVER, THE MECHANIC SAID THE UNDERCARRIAGE HAD LARGE AMOUNT OF RUST WHICH COULD MAKE PASSING IN FUTURE YEARS DIFFICULT. I FINALLY HAD TIME TO BRING TO BODY SHOP. ON LIFT, MECHANIC SHOWED ME SIGNIFICANT RUST. SAID HE COULDN'T DO ANYTHING AND WOULD BE IN THOUSANDS TO FIX. CAR HAS APPROXIMATELY 59,900 MILES AND HAS BEEN METICULOUSLY MAINTAINED. AFTER SOME RESEARCH, FOUND THIS SEEMS TO BE AN ISSUE AS SEEN HERE: HTTP://WWW.CARPROBLEMZOO.COM/FORD/FREESTYLE/FRAME-RUST-PROBLEMS.PHP AND HERE: HTTPS://FORUMS.EDMUNDS.COM/DISCUSSION/39926/FORD/FREESTYLE/FORD-FREESTYLE-SUBFRAME-RUST COINCIDENTALLY, I JUST RECEIVED 11-27-18 A NHTSA RECALL NOTICE FOR A "FRONT CROSS MEMBER CORROSION SAFETY RECALL 28181 ON MY 2009 MAZDA6.

NHTSA ID

11154481

Incident

Aug 14, 2018

Mileage

59,900 mi

TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE AND WAS INFORMED THAT THE CROSS MEMBER FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT NOTHING COULD BE DONE SINCE THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

NHTSA ID

11130987

Incident

Sep 24, 2018

Mileage

140,000 mi

LAST WINTER THE DOOR LATCHES FROZE AND WOULD NOT STAY SHUT. I HAD TO BUNGEE THE 2 REAR DOORS TOGETHER. SO I DID RESEARCH FOUND THERE WAS A RECALL FOR THAT ISSUES BACK IN 2006. THE NUMBER ON THE OLD LETTER WAS WHO I CONTACTED. THE LADY WENT ON TO SAY THEY WILL NOT COVER THE RECHECK OF ISSUE OR RE-PERFORM THE RECALL. SO I SAID SO WHAT YOUR SAYING IS SINCE YOU ARE SAYING YOU CANNOT FIX THE ISSUE AND DOORS MALFUNCTION I COULD OPEN A LAWSUIT! SHE SAID " YES "! I IMMEDIATELY WENT TO MY LOCAL FORD DEALER AND THE ADVISOR THERE SAID THAT THE RECALL HAS NEVER BEEN PERFORMED IN MY VEHICLE. WINTER IS JUST AROUND THE CORNER AND I WOULD MY CHILDREN TO BE SAFE IN THE BACK SEAT AND NOT HAVE TO WORRY ABOUT THEM. WHILE I WAS AT MY LOCAL FORD DEALER THEY HAD ONE KIT LEFT IN STOCK BUT NOT EXACTLY SURE ON HOW TO PERFORM IT AND WILL ATTEMPT IF NECESSARY BUT WOULD RATHER HAVE IT DONE CORRECTLY AND PROFESSIONALLY.

NHTSA ID

11048695

Incident

Nov 25, 2017

Mileage

131,000 mi

THE PAINT ON THE ALUMINUM STARTED TO BUBBLE THREE YEARS AGO AND BEGAN FLAKING OFF LAST YEAR.

NHTSA ID

10992611

Incident

Mar 1, 2013

THE DRIVER SIDE PASSENGER DOOR SEAL IS FAULTY, LETTING WATER GET INTO THE DOOR CAUSING IT TO FREEZE AND RUST. THE ELECTRICAL FOR THE DRIVER HEATED SEAT KEEPS MALFUNCTIONING CAUSING IT TO KEEP BREAKING. THE LEVERS THAT FLIP THE SECOND AND THIRD ROW SEATING HAVE BECOME FAULTY AND WILL NO LONGER WORK. LASTLY, THE ALL-WHEEL DRIVE COMPONENT ON MY VEHICLE STOPPED WORKING WHILE I WAS DRIVING. IT WAS DURING THE WINTER AND THE ROADS WERE ICY SO IT CAUSED ME TO HAVE LESS TRACTION AND FISH TAIL. *TR

NHTSA ID

10947119

Incident

Dec 14, 2016

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT THE FRONT PASSENGER AND BOTH REAR DOORS FAILED TO LATCH IN COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LATCH MECHANISM HAD FROZEN AND WOULD HAVE TO HAVE A SHIELD PLACED OVER THE FRONT LATCHES AND LUBRICANT APPLIED TO ALL LATCHES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10937950

Incident

Feb 4, 2016

TAKATA RECALL THIRD ROW SEAT IS UNSAFELY UNHINGED BECAUSE THE BODY HAS RUSTED AWAY AND LEAVES THE SEAT UNSECURED AND A HOLE TO THE OUTSIDE OF THE VEHICLE.

NHTSA ID

10929424

Incident

Dec 1, 2016

Mileage

110,000 mi

ANYTIME IT RAINS MY VEHICLE FILLS WITH WATER. I HAVE MOLD STARTING IN MY VEHICLE. I TOOK IT TO FORD DEALERSHIP FOR RECALL WORK BUT IT STILL LEAKS HORRIBLE BAD. THIS CAR IS MOSTLY STATIONARY. WE HAVE HAD RAIN THE LAST TWO DAYS AND IT HAS BEEN SITTING IN THE DRIVE WAY. I CHECKED IT TODAY AND IT IS FULL OF WATER. THIS HAS HAPPENED SINCE I PURCHASED THE VEHICLE IN 2013

NHTSA ID

10898478

Incident

Aug 24, 2016

BOUGHT NEW, PRIOR TO DELIVERY OF VEHICLE DEALER FIRST FIXED A RECALL FOR DOOR LOCK THAT JAMMED DURING COLD WEATHER FREEZING CAUSING REAR DOOR LATCH NOT TO CATCH. PROBLEM OCCURRED THE FOLLOWING WINTER OF 2008 WHEN DROPPING OFF CHILD TO SCHOOL, DOOR WOULD NOT CLOSE AND FLEW OPEN AS I WAS DRIVING AWAY, NEARLY SWINGING INTO PATH OF CHILD. PULLED CAR OFF MAIN ROAD TO TRY AND CLOSE DOOR WITH SEVERAL HARD SLAMS BUT LATCH WOULD NOT CATCH DOOR. CALLED FORD RECALL CORPORATE CENTER WHO CHECKED THEIR RECORDS AND CONFIRMED THE DEALER MARKED THE RECALL AS FIXED ALREADY. I EXPLAINED TO THE FORD RECALL DEPARTMENT THAT REGARDLESS OF WHETHER THE DEALER ACTUALLY FIXED THE PROBLEM, IT IS STILL OCCURRING AND WAS A VERY DANGEROUS HAZARD DURING WINTER MONTHS WHEN DOOR COULD SWING OPEN AND HIT ADJACENT CARS, PEDESTRIANS, LIGHT POLES AND TREES ALONG URBAN LOCAL ROADS WHERE SIDEWALKS AND POLES ARE TYPICALLY NEAR THE CURB. I WAS TOLD THERE WAS NOTHING THEY COULD DO FURTHER SINCE THE VEHICLE WAS ALREADY 'FIXED' UNDER THE RECALL NOTICE. I LOOKED INTO WHAT THE 'FIX' WAS AND IT WAS SIMPLY HAVING THE SERVICE TECHNICIAN DRILL A HOLE IN THE DOOR FRAME TO ALLOW CONDENSATION TO DRAIN INSTEAD OF FREEZING NEAR THE LATCH MECHANISM. I AM AN ENGINEER BY PROFESSION, AND IN MY REVIEW OF THIS REMEDIAL MEASURE, IT BECAME APPARENT THAT THE DRILL BIT SIZE BEING PROVIDED TO THE DEALERSHIPS FOR THIS FIX WAS NOT A LARGE ENOUGH DIAMETER TO ENSURE PROPER DRAINAGE AND AS A RESULT, THE CONDENSATION WOULD SIMPLY FREEZE ACROSS THE FULL DIAMETER OF THE DRILLED HOLE INTENDED FOR DRAINAGE. PROBLEM CONTINUES TO OCCUR DURING COLD WEATHER MONTHS EACH YEAR AND I HEARD THAT FORD IS UNDER INVESTIGATION AGAIN FOR SIMILAR PROBLEM ON SOME NEWER MODELS

NHTSA ID

10821587

Incident

Feb 15, 2008

Mileage

13,430 mi

I WAS BACKING OUT OF ANGLE PARKING SPACE. AS I BACKED I BUMPED CONCRETE POLE. AS I PUT CAR IN DRIVE TO GO FORWARD THE ACCELERATOR STUCK WIDE OPEN. I HAD NO CONTROL OF SPEED. I SPED FORWARD APPROXIMATELY 20 FEET AND CRASHED INTO THE BACK OF A PARKED PICK-UP. POLICE WERE CALLED. I WAS ONLY BRUISED AND SORE. I DID SEE A DR. AND WILL CONTINUE TO DO FOLLOW UP. MY INSURANCE CO. TOTALED THE CAR. IT WAS VERY DAMAGED ON THE DRIVER SIDE. SOMEONE COULD OF BEEN KILLED IN THIS ACCIDENT. MY DESCRIPTION DOES NOT ADEQUATELY DESCRIBE THE SERIOUSNESS OF THIS INCIDENT. POLICE AND OTHERS COULD NOT BELIEVE I WAS NOT SEVERELY HURT. IF THESES CARS ARE NOT RECALLED IT IS ONLY A MATTER OF TIME UNTIL SOMEONE DIES IF THEY HAVE NOT ALREADY .

NHTSA ID

10775882

Incident

Sep 3, 2015

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT WATER LEAKED INTO THE VEHICLE THROUGH THE SEAT BELTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

NHTSA ID

10651505

Incident

Apr 6, 2014

Mileage

89,000 mi

WE WERE AT A STAND STILL IN TRAFFIC LEADING TO THE OFF RAMP, A VEHICLE CAME SPEEDING DOWN THE ON RAMP AND BY HIS OWN ADMISSION WAS NOT PAYING ATTENTION. HE THEN RAMMED INTO THE BACK OF OUR VEHICLE AND HIT US SO HARD THAT IT TRIGGERED A MULTI CAR CRASH, 6 VEHICLES IN ALL. DURING REPAIRS OF THE VEHICLE WE WERE TOLD THAT THE ENGINE WAS EXPERIENCING IDLE SURGE. IT WAS ALSO NOTED THAT THIS WAS NOT DUE TO THE VEHICLE ACCIDENT. WE PAID OUT OF POCKET SOME 1,700.00 AND WE CONTINUE TO HAVE THE SAME ISSUES. THE FORD DEALERSHIP HAS NOT AND WILL NOT CORRECT THE PROBLEM. FORD IS RESPONSIBLE FOR THIS REPAIR AND I WOULD LIKE TO SEE SOME ACTION TAKEN ON THEIR PART. I CALLED FORD CORPORATE OFFICE AND WAS TOLD DESPITE MY VEHICLE BEING INCLUDED IN THE 2005-2007 RECALL MY PARTICULAR VIN NUMBER IS NOT INCLUDED IN THAT LOT. NOT GOOD CUSTOMER SERVICE. *TR

NHTSA ID

10605708

Incident

May 12, 2013

Mileage

128,885 mi

IT WAS BELOW FREEZING OUT AND SOME OF MY PASSENGER DOORS WOULD NOT OPEN AND THE ONE THAT DID OPEN WOULD NOT CLOSE AGAIN. I SEE THAT THERE IS A RECALL ON THIS PART FOR THE 05 FREESTYLES BUT FORD WILL NOT PERFORM THE RECALL FIX ON MY 06 FREESTYLE BECAUSE THE BUILD DATE DOES NOT MATCH THE RECALL SPECIFICATIONS. THE RECALL I AM REFERRING TO IS 06S45. MY CAR WAS BUILT A WEEK OR TWO AFTER THE END OF THAT SPECIFIC RECALL EVENT. I AM EXPERIENCING THE SAME DOOR LOCK ISSUES IN COLD CLIMATE. FORD REFUSES TO FIX THIS SAFETY ISSUE FORCING MY FAMILY INTO UNSAFE SITUATIONS WHEN IT IS COLD. *TR

NHTSA ID

10501187

Incident

Jan 17, 2013

Mileage

86,000 mi

DURING VERY COLD DAYS THE DOORS WON'T LATCH SHUT, AND HAVE EVEN POPPED OPEN DURING TRAVELS... SO FAR HAVE HAD ISSUES WITH BOTH REAR DOORS AND FRONT PASSENGER DOOR.... *TR

NHTSA ID

10498456

Incident

Feb 8, 2013

Mileage

111,010 mi

TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT AN ABNORMAL MILDEW SMELL WAS EMITTED INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN INSPECTED THE VEHICLE AND ADVISED THE CONTACT TO HAVE THE VEHICLE DETAILED. THE CONTACT DECIDED TO TAKE THE VEHICLE TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE DOOR STRIKER WAS LEAKING AND CAUSING WATER TO ENTER THE VEHICLE. AS A RESULT, THE FLOORBOARD WAS DAMP. THE TECHNICIAN REPLACED THE DOOR STRIKER, THE FLOORBOARD CARPET AND THE SPARE TIRE COVER. THE REMEDY FAILED TO CORRECT THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOR A THIRD TIME. THE TECHNICIAN DIAGNOSED THAT THE SUN ROOF DRAINING LINES WERE DEFECTIVE, CAUSING THE REAR OF THE VEHICLE TO FLOOD WHEN ON AN INCLINE. THE TECHNICIAN REPLACED THE SUN ROOF ASSEMBLY AND THE REAR DRAINAGE LINES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10493753

Incident

Mar 6, 2012

Mileage

100,000 mi

MY DAUGHTER HAD A WRECK, SHE REAR-ENDED A TRUCK WHO RAN INTO ANOTHER VEHICLE. THE AIRBAG ON MY VEHICLE DID NOT DEPLOY ALTHOUGH THE SEATBELT DID LOCK UP. THERE HAD BEEN NO WARNING LIGHT STATING THAT THERE WAS ANYTHING WRONG WITH THE AIRBAG. I HAVE WRITTEN TO FORD ABOUT THIS MALFUNCTION BUT THEY JUST SAY THERE IS NO RECALL ON THE AIRBAGS. I TOLD THEM THAT UNFORTUNATELY NO ONE WILL KNOW IF THERE IS A PROBLEM UNTIL THEY HAVE AN ACCIDENT. I FEEL THIS IS A VERY UNSAFE PART AND NEEDS INVESTIGATION. *TR

NHTSA ID

10472098

Incident

Apr 13, 2012

Mileage

104,000 mi

ON MULTIPLE OCCASIONS THE VEHICLE HAS LURCHED FORWARD OR BACKWARD WITHOUT HAVING MY FOOT ON THE ACCELERATOR. APPLYING THE BRAKE HAS STOPPED THE CAR. THE REAR BUMPER WAS DAMAGED WHEN IT HIT A LIGHT POLE. IT SEEMS TO HAPPEN MORE FREQUENTLY WHEN IT'S WARMER OUTSIDE AND WHEN RUNNING THE AIR CONDITIONING. I'M VERY CONCERNE SOMEONE MIGHT GET INJURED. MY WIFE HAS ALSO HAD THIS HAPPEN TO HER ON MULTIPLE OCCASION. I'VE READ A NUMBER OF SIMILAR COMPLAINTS ON THE INTERNET. I BELIEVE THIS VEHICLE SHOULD BE RECALLED. I'M A MECHANICAL ENGINEER BY DEGREE AND CAN STATE WITH CERTAINTY THAT THIS IS A DANGEROUS CONDITION ESPECIALLY IN A PARKING LOT WHERE IT MOST FREQUENTLY HAPPENS. I WON'T EVEN ATTEMPT TO BACKUP THE VEHICLE IF SOMEONE IS NEARBY IN CASE IT HAS ONE OF THESE FITS. PLEASE KEEP ME POSTED ON ANY RECALL UPDATES. DO THE RIGHT THING, FORCE THE MANUFACTURER TO OWN UP TO THE PROBLEM AND TAKE CARE OF IT. I TOOK IT IN TO HAVE IT FIXED, BUT NOBODY SEEMS TO KNOW OR IS WILLING TO SAY WHAT'S WRONG. THEY JUST OFFER TO CHANGE OUT A LOT OF PARTS IN THE HOPES OF HITTING UPON THE PROBLEM. THAT'S TOO EXPENSIVE OF AN APPROACH. DOES FORD KNOW THE SOURCE OF THE PROBLEM? WILL THEY SHARE THAT INFORMATION WITH THEIR DEALERSHIPS OR THE CONSUMERS? *TT

NHTSA ID

10462495

Incident

Jun 12, 2012

Mileage

94,000 mi

NOT SURE ON DATE WHEN INCIDENT OCCURRED, BUT THE VEHICLE WOULD START LUNGING EVEN WHILE BRAKE PEDAL WAS ENGAGED. PROBLEM WORSENED OVER A SHORT PERIOD OF TIME TO WHERE IT WOULD CUT OFF MULTIPLE TIMES. ALSO PROBLEM WOULD GET WORSE WHILE AIR CONDITION WAS ON. ONE DAY PULLING INTO A PARKING SPOT ONE DAY THE VEHICLE LUNGED FORWARD CAUSING ME TO HIT A PARKING BLOCK. DAMAGE WAS DONE TO THE FRONT BUMPER ONLY. EVENTUALLY IT GOT TO WHERE WE WERE UNABLE TO DRIVE THE VEHICLE. HAS BEEN PARKED FOR SEVERAL MONTHS. WILL CRANK UP FOR A COUPLE SECONDS AND WILL CUT OFF. *TR

NHTSA ID

10449769

Incident

May 10, 2011

WATER IN THE SPARE TIRE WELL, RUST ON THE THIRD SEAT SUPPORT, MOLD COVERING TIRE COVER, MOLD ON CARPET AND A TERRIBLE MILDEW SMELL IN THE CAR. PROBLEM IS REPORTED IN FORDS TBS07-03-06 TO DEALERS WATER LEAKING FROM DRAIN TUBES INTO BACK OF CAR. I NOTICED THIS PROBLEM WHEN I SAW WATER RUNNING DOWN MY SEAT BELTS AND A TERRIVEL MILDEW SMELL IN CAR. SEEMS TO ME A MOLD/MILDEW PROBLEM IS A SAFETY ISSUE. DRIVING AROUND IN A CLOSED UP VEHICLE WITH SPORES FLOATING AROUND CAN'T BE HEALTHY ESPECIALLY WITH TWO SMALL CHILREN AGES 1 AND 3. I AM VERY CONCERNED ABOUT MY FAMILY BREATHING IN THIS MOLD IF IT WAS IN A HOME IT WOULD BE CONCIDERED A SAFETY HAZARD. I FOUND THIS FROM A POSTING ONLINE ABOUT MOLD-ASSOCIATED CONDITIONS. HEALTH PROBLEMS ASSOCIATED WITH HIGH LEVELS OF AIRBORNE MOLD SPORES INCLUDE ALLERGIC REACTIONS, ASTHMA EPISODES, IRRITATIONS OF THE EYE, NOSE AND THROAT, SINUS CONGESTION, AND OTHER RESPIRATORY PROBLEMS. FOR EXAMPLE, RESIDENTS OF HOMES WITH MOLD ARE AT AN ELEVATED RISK FOR BOTH RESPIRATORY INFECTIONS AND BRONCHITIS. WHEN MOLD SPORES ARE INHALED BY AN IMMUNOCOMPROMISED INDIVIDUAL, SOME MOLD SPORES MAY BEGIN TO GROW ON LIVING TISSUE, ATTACHING TO CELLS ALONG THE RESPIRATORY TRACT AND CAUSING FURTHER PROBLEMS. GENERALLY, WHEN THIS OCCURS, THE ILLNESS IS AN EPIPHENOMENON AND NOT THE PRIMARY PATHOLOGY. ALSO, MOLD MAY PRODUCE MYCOTOXINS, EITHER BEFORE OR AFTER EXPOSURE TO HUMANS, POTENTIALLY CAUSING TOXICITY. FUNGAL INFECTION A SERIOUS HEALTH THREAT FROM MOLD EXPOSURE FOR IMMUNOCOMPROMISED INDIVIDUALS IS SYSTEMIC FUNGAL INFECTION (SYSTEMIC MYCOSIS). IMMUNOCOMPROMISED INDIVIDUALS EXPOSED TO HIGH LEVELS OF MOLD, OR INDIVIDUALS WITH CHRONIC EXPOSURE MAY BECOME INFECTED. SINUSES AND DIGESTIVE TRACT INFECTIONS ARE MOST COMMON; LUNG AND SKIN INFECTIONS ARE ALSO POSSIBLE. MYCOTOXINS MAY OR MAY NOT BE PRODUCED BY THE INVADING MOLD. *TR

NHTSA ID

10448520

Incident

Dec 15, 2011

Mileage

70,000 mi

I HAVE A 2006 FORD FREESTYLE LIMITED THAT LEAKS THROUGH THE PASSENGER SIDE THIRD ROW SEATBELT. FROM WHAT I HAVE BEEN ABLE TO SEE ON THE INTERNET IT SOUNDS LIKE IT IS BECAUSE OF THE MOONROOF DRAIN CLIPS. I KNOW THIS PART IS NOT A SAFETY ISSUE BUT THE PROBLEM CONTINUED AND SHORTED OUT THE PASSENGER SIDE BRAKE/TURN SIGNAL LIGHT. I KNOW IT IS NOT THE FUSE BECAUSE THE FRONT ONE WORKS AND I KNOW IT'S NOT THE BULB BECAUSE THE BULB ONE THE PASSENGER SIDE WORKED WHEN I TRIED IT ON THE DRIVERS SIDE. I FEEL THAT THIS IS A BIG SAFELY PROBLEM SINCE OTHER DRIVERS DON'T KNOW IF I AM TURNING. FORD NEEDS TO FIX THIS PROBLEM AND ISSUE A RECALL BEFORE ACCIDENTS HAPPEN. *TR

NHTSA ID

10407001

Incident

May 1, 2011

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2006 FORD FREESTYLE. THE CONTACT STATED THAT THE EXTERIOR PAINT WAS BUBBLING AND PEELING OFF ON THE ROOF OF THE VEHICLE. THE DEALER AND MANUFACTURER WERE CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 94,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10403802

Incident

Jan 11, 2011

Mileage

94,000 mi

SUNROOF/MOONROOF LEAK: POSSIBLY ALLOWS WATER INSIDE VEHICLE EVERY TIME IT GETS WET. BROUGHT THE VEHICLE TO THE SELLING DEALER APPROXIMATELY 16 MOS. INTO WARRANTY. I THOUGHT IT WAS A WINDSHIELD LEAK AT FIRST AND THE SERVICE REP TOLD ME I WOULD HAVE TO GO TO A GLASS COMPANY. I EXPLAINED THAT I HAD NOT HAD ANY GLASS REPLACED ON THE VEHICLE AND THAT IT WAS A FORD PROBLEM, TO WHICH THEY RESPONDED THAT THEY WOULD CHECK IT OUT. WHEN I RETURNED TO PICK UP THE VEHICLE THEY TOLD ME THAT THEY COULD NOT FIND THE LEAK. I ASKED IF THEY HAD PUT WATER ON THE CAR ROOF AND THEY SAID THEY HAD NOT TO WHICH I QUESTIONED HOW CAN YOU FIND A WATER LEAK WITHOUT WATER? I REFUSED TO PICK UP THE CAR AND THEY SAID THEY WOULD TRY WATER. THE NEXT DAY THEY CALLED TO SAY THE LEAK WAS REPAIRED,THAT THERE WAS A SERVICE BULLETIN ABOUT THE MOONROOF LEAK, AND THAT THEY HAD REROUTED THE DRAINS TO FIX THE PROBLEM. I BELIEVED THEM. I FORGOT ABOUT THE PROBLEM UNTIL MARCH 09 AT WHICH TIME I WAS OUT OF WARRANTY AND WAS TOLD BY A CUSTOMER SERVICE REP IN DEARBORN THAT I WOULD HAVE TO HAVE IT EVALUATED AT A FORD DEALER AT MY EXPENSE.I DECLINED THIS.NOW ROUGHLY ONE YEAR LATER IT IS BACK AGAIN AND I HAVE CONCERNS THAT IT PROBABLY WILL LEAD TO MOLD, IF IT HASN'T ALREADY, AND THAT BECAUSE THE WATER STAYS ABOVE THE HEADLINER, THE WIRING FOR MY REAR BRAKELIGHTS AS WELL AS THE SIDE CURTAIN AIRBAGS COULD POSSIBLY BE COMPROMISED,IN ADDITION TO LEADING TO PREMATURE RUST THROUGH OR ROT WHERE THE WATER EVENTUALLY COMES OUT.ALSO I FEEL BETRAYED BY FORD BECAUSE I HAVE COPIES OF OTHER TSB'S WHICH PERTAIN TO MY VEHICLE BUT WERE NOT TAKEN CARE OF BECAUSE I DID NOT COMPLAIN OF THOSE SYMPTOMS AT THE TIME OF SERVICE AND NOW THAT I'VE REALISED I HAVE THOSE PROBLEMS IT'S TOO LATE FOR THEM TO BE COVERED. I BELIEVE EVERY NEW VEHICLE OWNER SHOULD RECEIVE NOTICE FROM THE MANUFACTURER ABOUT EVERY PROBLEM CONCERNING THEIR VEHICLE AND THAT EVERY TIME A DEALER SERVICES A PRODUCT UNDER WARRANTY, THAT ALL TSB'S ARE CHECKED AND ACTED UPON. *TR

NHTSA ID

10320645

Incident

Jan 5, 2008

2006 FORD FREESTYLE. WATER LEAKING FROM MOONROOF AREA SATURATING CARPET AND SPARE TIRE GALLEY CAUSING MOLD. *TR

NHTSA ID

10314420

Incident

Feb 20, 2006

Mileage

35,500 mi