Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 2023 Ford Maverick submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Driver side door check hinge, rivets that hold the door hinge will break off. Door rivet panel will prevent the window to go down or up. The check hinge will break off during normal closing and opening of door.
The contact owns a 2023 FORD Maverick. The contact stated he noticed a odd sound from the driver side door when closing and opening, the winch on the driver side door is loose and scraping the inside of the door frame. The vehicle was taken to a dealer where it was diagnosed it to need a new driver side door. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 83,000.
The vehicle was at the dealer for a loud noise on the hinge area of the driver side door. I was contacted by the dealer and told That the door has cracked spot welds and needs to be replaced. The dealer contacted Ford and for opening offered to pay for a portion of the repair leaving me with over $1000 dollars out of pocket.This is a common problem with this vehicle and the Ford escape see Ford TSB 2356B. The vehicle is still under warranty but this is a defective item and should be covered 100% by Ford.
Found Drivers door hard to open and close. Took vehicle to Body shop. Had to replace door.
Drivers door became hard to open and close. Found driver front door stop damaged / welds broken and separated from door interior.
Vehicle drivers front door is very hard to operate, very hard to shut, window wont roll all the way down. Vehicle makes popping noise when operating drivers front door. Door wont close all the way at times due to door check binding inside of door. Ford has had a customer satisfaction service repair for Escape model vehicles with similar problems. Ford reference for this action is 23B56. Due to the door not being able to close properly this vehicle will require repair and the vehicle taken out of service because it is not safe to drive with the door not latching properly. The spot welds are broken away from the door causing the door check and mounting bracket to be pushed into the door when closing, this causes the door to not be properly latched.
The contact owns a 2023 Ford Maverick. The contact stated that the strong odor of mold and mildew was present inside and outside the vehicle. The vehicle was taken to the local dealer who informed the contact that the failure was caused by faulty floor pan body plugs which were improperly sealed causing water to intrude into the floorboard of the vehicle and causing mold and mildew to develop inside the vehicle. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 900.
Windshield will groan and shift when driving , sound is always present and gets louder on uneven roads and bum. Ford stated it was a normal sounds, several maverick owners have had this problem
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .