Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2024 Ford Maverick submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 16 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Upon acceleration, the front end vibrates heavily. light pedal depression it isn't quite as noticeable. But medium pressure to gas peddle & it feels like the whole underneath of the engine/ maybe front axle is about to fall apart. the harder the acceleration, the more intense the shaking/vibrating is.
CV axles failed around 42,000 miles. Purchased new tires due to one being worn. After new tires the front end was shaking on acceleration onto the highway. Vibration stopped once the vehicle got up to speed. The tires were rebalanced but that didn't help. The mechanic found the problem to be the CV axles. Once both were replaced the vibration finally stopped.
I was driving my vehicle that was warmed up,about 5 miles from my house. I set the cruise control on 50 mph- the vehicle climbed an incline at 50, after the decline started the vehicle down shifted trying to keep 50 mph, but was still over by 3-5 mph. The road flattened out and The next thing i noticed was i was doing 42mph and the transmission was in neutral. I shifted back to drive and didnt use cruise control again that day 3/13/26. I have not notice anything else going on with transmission and have reused cruise control again without an issue. I called the dealer and they have not heard of this or have any technical service bulletins regarding this issues. I was quoted a diagnostic charge if i bring it in. I travel on some busier road and use cruise control often
I was driving and the vehicle stopped like it was in neutral. I started rolling backwards into a vehicle. He honked and I slammed on breaks. I put flashers on. Waited a bit. Turned off and on and it started. I drove home and called service dept
Front cv axle failure causing severe vibration with acceleration Ford has not fixed yet 40k miles started
My turbocharger went out 3 times with in a month the dealership is trying there best to fix it but every time they do something with that same system goes wrong. At first it was nothing to bad but lack of power and sounding rough and it was like that the second time the system went out how ever on the 3rd time I was on the highway and when it went out it disabled my crew’s control system and when I bought it back they now say it’s is an electrical concern.
RITICAL BRAKING FAILURE & DEALER NEGLIGENCE: The vehicle exhibits a violent shudder and loss of deceleration during the hand-off between regenerative and friction braking. This defect was first reported to the dealer (Rich Ford) at 35,399 miles (RO #[XXX]) within the Bumper-to-Bumper warranty but was not repaired. THE INCIDENT: On [Insert Date], the braking system failed to decelerate the vehicle during a traffic slowdown. The pedal vibrated violently, and the vehicle did not stop. I was forced to swerve across two lanes of traffic onto the shoulder to avoid a high-speed rear-end collision. DEALER NEGLIGENCE: The vehicle was in dealer possession from Jan 12–28, 2026 (16 days). Odometer records prove they only test-drove it for 7 miles. They failed to apply known TSB 23-2209 (Hybrid Shudder) and released the vehicle to me despite active internal ABS Pump Control Codes (C052E and U0418) recorded in the vehicle logs on Jan 22, 2026. REPORTING IRREGULARITY: The dealer coded this latest safety attempt as "Routine Maintenance/Flush" rather than a safety repair, effectively hiding the defect history from the manufacturer and my warranty provider to avoid Lemon Law liability. The vehicle remains unsafe to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Front CV axles began failing at around 20,000 miles. The truck shakes when accelerating at all speeds but especially at 40-50mph or under load.
Wife was traveling from work to home when vehicle shut down in the middle of the roadway. Vehicle locked transmission into park. Tow truck driver nor Ford representatives via customer care could provide a means to release the parked truck. Fortunately wife suffered no injuries nor was she rear ended when truck decided to stop running and park. Dealership stated they could see error messages not shared with customer. Dealership could not tell us why vehicle shut down on its own in the middle of the roadway
*front cv axle. Both sides, yes inspection available and ford inspection report available. *unsafe to drive. When accelerating above 40 truck shakes badly. *yes problem confirmed by dealership. *has been inspected by dealers mechanic. *no warning lights, noticed at 50k miles, no warnings. I drive a lot of miles but freeway driving mainly, east to west in l.a. I heard from dealer rep that they are seeing this a lot. To the point he diagnosed the issue before the inspection and was correct.
The vehicle began wobbling when accelerating, but no warning lights came on. Self inspection found the CV boot was leaking grease. The dealership confirmed damage to the CV joint and required replacement of the front axle.
While traveling on an interstate highway at night, my gas 2024 Ford Maverick Lariat unexpectedly shifted into neutral. I was not sure what was happening as the truck began to slow even while I was accelerating, I then realized it was in neutral. While still traveling at approximately 40 mph I shifted back into drive and everything was ok.
Vehicle lost power and service engine light came on, transmission speed sensor, powertrain control system, PCM communication error, the second time it said pre-collision assist and powertrain malfunction reduce power. The first time it happened they replaced the transmission, the second time it completely stalled, and they could not duplicate the problem. Returned the vehicle to me without repairing anything. All codes showing on my Ford app were no longer in the computer on vehicle.
CV Axel = vibration under acceleration I will be taking it in. soon for the inspection The vibration is getting worse and has me concerned Not yet ill be taking it in shortly but this is a known problem among the community no warning lamps.
The contact owns a 2024 Ford Maverick. The contact stated while driving 40 MPH, the vehicle briefly hesitated before continuing to accelerate. The contact then heard an abnormal vibrating sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer, who was able to hear the abnormal sound but failed to provide a specific diagnostic result. The contact was informed that the vehicle was functioning as intended. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 3,200.
Unknown, My 2024 Ford Maverick has now twice got stuck in reverse (shifter indicates it is in reverse) though the dash shows park and I was unable to start the truck after removing my key and waiting a few moments it would act normal and let me start my truck. The last time it happened I was in the dealer lot and told my sales representative but we couldn’t replicate the problem he said next time it happens to record it and see if it becomes a trend that it would be covered under warranty but until it is replicable they could not do anything I don’t know when or why it happens. I just wanted to report it because I’m not sure if it’s only happening to me or if it is effecting others as well.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .