1989 Ford Ranger Owner Complaints

VEHICLE BODY AND STRUCTURAL FRAME HAVE ABNORMAL CORROSION AND RUST AND CRITICAL COMPONENTS HAVE FAILED. CAB IS ATTACHED TO FRAME WITH FOUR BOLTS. THE METAL AROUND THE FRONT LEFT BOLT HAD COMPLETELY RUSTED AWAY. CAB IS THEREFORE ONLY HELD DOWN NOW BY THREE BOLTS. RIGHT FRONT COIL SPRING TOWER ROTTED AND WAS SUBJECT TO COMPLETE FAILURE WHICH WOULD CAUSE THE RIGHT FRONT OF THE VEHICLE TO FALL DOWN ONTO THE SHOCK ABSORBER. TIRE WOULD HAVE BEEN THRUST INTO FENDER WELL AND STEERING WOULD BEEN COMPRIMISED. REPAIRED IN 2006. GAS TANK MOUNTING STRAPS RUSTED AWAY SUBJECTING THE TANK TO FALL FROM VEHICLE. REPAIRED IN 2005. LEFT REAR LEAF SPRING ATTACH BRACKET (SHACKLE) RUSTED AND BROKE, CAUSING VEHICLE TO FALL ONTO END OF LEAF SPRING, WHICH IS NO LONGER ATTACHED. ENGINE OIL PICK UP SCREEN BECAME CLOGGED WITH DETERIORATED OIL PAN GASKET MATERIAL. ENGINE BECAME STARVED OF OIL AND SEIZED UP WHILE DRIVING IN HEAVY TRAFFIC, CAUSING A MAJOR HAZARD. ENGINE WAS REPLACED IN 2016.

NHTSA ID

11245886

Incident

Jun 2, 2005

Mileage

140,000 mi

TL* THE CONTACT OWNS A 1989 FORD RANGER. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT, A CERTIFIED INDEPENDENT MECHANIC, DIAGNOSED THE VEHICLE AS HAVING SECONDARY IGNITION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.

NHTSA ID

10986335

Incident

Apr 20, 2016

Mileage

64,000 mi

TL* THE CONTACT OWNS A 1989 FORD RANGER EQUIPPED WITH HERCULES H/P 4000 TIRES, SIZE: 215/70R14 (NA). THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE WAS CRACKING AND EXPERIENCED TREAD SEPARATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS RECOMMENDED TO REPLACE ALL THE TIRES. THE TIRES WERE REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 150 AND THE VEHICLE FAILURE MILEAGE WAS 50,400.

NHTSA ID

10762300

Incident

Jan 15, 2015

Mileage

50,400 mi

TL*THE CONTACT OWNS A 1989 FORD RANGER. THE VEHICLE HAS FIRESTONE FR380 TIRES, SIZE P215/70/R14. THE CONTACT NOTICED THAT THE TIRES WERE ALMOST FLAT. UPON FURTHER INVESTIGATION, HE NOTICED THAT THE TREAD LINES WERE BECOMING LOOSE AND APPEARED TO BE PEELING OFF. THE FAILURE MILEAGE ON THE TIRES WAS 12,781. THE FAILURE MILEAGE ON THE VEHICLE WAS 118,000.

NHTSA ID

10262142

Incident

Mar 17, 2009

Mileage

118,000 mi

1989 FORD RANGER. FAILED SMOG TEST FOR THE FIRST TIME. TOLD NEW TEST FOR SEAL IN GAS FILLER DOWN TUBE RESULTS IN PRETTY MUCH ALL VEHICLES OF THIS TYPE FAILING CALIFORNIA SMOG TEST. SUGGESTED FILE COMPLAINT AS THIS SHOULD BE A RECALL FROM MANUFACTURER (FORD) TO CORRECT THIS DEFECT. *TR

NHTSA ID

10256182

Incident

Jan 22, 2009

Mileage

3,629 mi

ELECTRICAL FAILURE UNDER HOOD RIGHT SIDE RANDOMLY BURST INTO FLAMES IN MY GARAGE.....= = ENGINE COMPARTMENT TOAST...FAN BLADE IN A PUDDLE ON THE FLOOR ALONG WITH MOST OF THE GRILLE AND HEAD LAMP.=.GARAGE----SMOKE DAMAGED,,,,,PUSHED IT OUT WHEN I SMELLED SOMETHING BURNING FIRE DEPT PUT IT OUT. *TR

NHTSA ID

10225977

Incident

Apr 27, 2008

TL*THE CONTACT OWNS A 1989 FORD RANGER. WHILE DRIVING 55 MPH, THE VEHICLE BURST INTO FLAMES. THE CONTACT STATED THAT HE IMMEDIATELY PARKED AND EVACUATED THE VEHICLE. THE FIRE DEPARTMENT AND SHERIFF ARRIVED AT THE SCENE. THE VEHICLE COULD NOT BE TRANSPORTED TO A DEALER. THE VIN AND ENGINE SIZE WERE UNKNOWN. THERE WAS NO CURRENT MILEAGE BECAUSE THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 82,000. UPDATED 09/18/07 *TR

NHTSA ID

10201603

Incident

Mar 1, 2007

Mileage

82,000 mi

ON A RELATIVELY COLD AND RAINY EVENING, I PARKED MY VEHICLE IN A PARKING LOT AND ATTENDED AN EVENT LASTING A COUPLE OF HOURS. AFTER THE EVENT I RETURNED TO MY VEHICLE TO LEAVE. I WAS TRAVELLING ABOUT 15 MPH THROUGH THE PARKING LOT AND CAME TO A CORNER, AND APPROACHING THE CORNER APPLIED THE BRAKES TO SLOW DOWN. WHEN I FIRST TOUCHED THE BRAKES THEY GRABBED HARD, SENDING ME INTO A SLIDE WHICH SENT MY VEHICLE THROUGH A FENCE. IN ADDITION, THE REAR ANTI-LOCK BRAKING SYSTEM DID NOTHING TO HELP. I BELIEVE THIS TO BE RELATED TO NHTSA ITEM NUMBER 601043, FORD TSB #985A36. I TALKED TO THE DEALER SHORTLY AFTER THIS HAPPENED, AND THEY SAID THIS WAS A KNOWN PROBLEM WITH MANY FORD TRUCKS AND THAT THERE WAS NO SOLUTION OTHER THAN TO EXPECT SUCH A BRAKE CONDITION ANY TIME IT IS COLD AND WET AND USE BRAKES/ACCELERATOR SIMULTANEOUSLY TO WARM/DRY BRAKES.

NHTSA ID

10073088

Incident

Nov 18, 2002

Mileage

150,000 mi

CONSUMER STATES THE OUTSIDE MIRRORS BLOW OUT OF POSITION WHILE DRIVING 45MPH AND OVER, CAUSING DANGER WHILE CHANGING LANES, THE RIGHT SIDE MIRROR DOES THIS ONLY ON HOT DAYS. *SLC

NHTSA ID

785739

Incident

Jul 10, 1997

THE MAIN STRAP THE HOLD THE GAS TANK TO THE TRUCK HAD RUSTED COMPLETELY THROUGH. LEAVING ONLY THE FRONT STRAP TO HOLD THE TANK FROM FALLING ONTO THE ROAD (POSSIBLY BEING HIT BY THE AUTOMOBILE BEHIND ME). I HAD BOTH STRAPS REPLACE AT MY EXPENSE BEFORE ANY DAMAGE OR INJURY OCCURRED.*AK

NHTSA ID

748465

Incident

Jun 30, 2001

THE FITTING TO THE PRESSURE REGULATOR BLEW OFF DUE TO THE HEAT AND PRESSURE FROM THE PLASTIC GAS LINE, WHICH CAUSED A FIRE. *SLC

NHTSA ID

557544

WHILE DRIVING AND SLOWING DOWN VEHICLE WILL DIE. WHEN IT DIES IT'S HARD TO STEER. CONSUMER STATES THAT IT COULD BE THE IGNITION MODULE.*AK THE ENGINE STALLS WHEN TURNING SHARP CURVE AND WHEN STOPPING AT LIGHT. *YH

NHTSA ID

874365

Incident

Oct 1, 1990

TRUCK QUITS IN HIQH HEAT,FORD NO HELP.*AK

NHTSA ID

731591

Incident

Sep 1, 2000

TIRE TREAD SEPARATED FROM TIRE AND DAMAGED LEFT FRONT OF VEH 1. THIS LOSS INVOLVES FIRESTONE WILDERNESS HT TIRES AND THEN NI IS INTERESTED IN PURSUING SUBROGATION. (CLAIM# 40-2069-856) *MW

NHTSA ID

6900221

Incident

Jul 8, 1998

THE IGNITION FAILED ON A COUNTRY ROAD GOING UPHILL AND AROUND A BEND IN THE ROAD. SEVERAL VEHICLES STOPPED BEHIND ME, INCLUDING A SCHOOL BUS, WHICH WAS RIGHT BEHIND ME AND WOULD NOT PASS ME BECAUSE OF LIMITED VISABILITY. AFTER SEVERAL UNSUCCESSFUL ATTEMPTS TO SART MY PICKUP THREE MEN CAME BY IN A OFFERRED TO PUSH ME OFF OF THE ROADWAY SO THAT I NO LONGER IMPEDED TRAFFIC. I REPLACE THE INGNITION MODULE MYSELF WITH AN AFTER MARKET UNIT AND HAVE NOT HAD ANY MORE PROBLEMS TO DATE.*AK

NHTSA ID

731178

Incident

Feb 1, 1999

TIRES HAD PROPER INFLATION WHEN TREAD SEPARATION CAUSED LOSS OF CONTROL AND ACCIDENT. *AK( DOT NUMBER: TIRE SIZE: R21570R14 )

NHTSA ID

731067

Incident

Jun 15, 1998

LEFT HOME IN MORNING TO GO TO WORK. IN FIRST 200 YARDS FELT BUMP, BUMP, BUMP IN STEERING. STOPPED AND LOOKED AT LEFT FRONT TIRE. TREAD WAS SEPARATED FROM CARCASS FOR ABOUT SIX INCHES ALONG EDGE OF TIRE AS PART OF A ONE FOOT LONG BULGE ABOUT HALF THE TREAD SURFACE IN WIDTH. STEEL BELT WAS SHOWING IN GAP AND SOME WIRES WERE BROKEN. HAD NOTICED PREVIOUS DAY THAT STEERING PULLED TO THE RIGHT. TIRES ARE NOT WORN OUT - ABOUT 1/8 IN TREAD LEFT. BOUGHT TRUCK USED WITH 30K MILES. DON'T KNOW IF THESE ARE ORIGINAL TIRES OR NOT. HAVE DIGITAL PHOTOS TELL ME WHERE TO SEND THEM.( DOT NUMBER: W2HVM0019H TIRE SIZE: P215/70R14 )

NHTSA ID

730183

Incident

Aug 15, 2000

NO SUMMARY( DOT NUMBER: TIRE SIZE: R21570R14 )

NHTSA ID

729878

Incident

Mar 15, 1997

NO SUMMARY( DOT NUMBER: TIRE SIZE: R21570R14 )

NHTSA ID

729874

Incident

Aug 15, 1998

DESIGN OF THE FUEL TANK CAUSED A CRACK IN THE FUEL TANK, RESULTING IN A FUEL LEAK WHICH COULD CAUSE A FIRE IS THERE WAS A SOURCE OF IGNITION. DEALER SAID THERE WAS A NEWER DESIGN OF THE FUEL TANK WHICH CONTAINED FUEL STRAP AND A HEAT SHIELD. MANUFACTURER WAS NOT WILLING TO HELP. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

864039

Incident

Jun 22, 2000

WHEN BACKING OUT THE DRIVEWAY CONSUMER NOTICED RUST ON THE PAVEMENT. INSPECTED VEHICLE AND NOTICEDT THAT STEEL SPRING WHICH IS ATTACHED TO THE SUSPENSION , RUSTED OUT. CONSUMER HAS CONTACTED THE DEALER. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

NHTSA ID

861192

VEHICLE WAS PLACED IN PARK POSITION, TURNED OFF FOR AROUND OR ABOUT TWO HOURS WHEN IT CAUGHT FIRE DUE TO AN WIRE WHICH SHORTED OUT. CONSUMER ALSO VEHICLE WAS TOTALLED. PLEASE PROVIDE ANY FURTHER DETAILS. 8AK

NHTSA ID

855289

WHILE DRIVING APPROXIMATELY 40 MPH DRIVER SMELLED GAS, PULLED OVER AND WITHIN 1 MINUTE VEHICLE WAS ENGULFED BY FLAMES WHICH STARTED UNDERNEATH HOOD. VEHICLE WAS A TOTAL LOSS.

NHTSA ID

853498

Incident

Oct 22, 1999

WHILE DRIVING AT APPROXIMATELY 40 MPH ,STARTED SMELLING GAS AND PULLED OVER, WITHIN 1 MINUTE VEHICLE WAS ENGULFED IN FLAMES WHICH STARTED UNDERNEATH THE HOOD, RESULTING IN TOTAL LOSS OF VEHICLE. *AK

NHTSA ID

852216

Incident

Oct 22, 1999

WHEN DRIVING AT ANY SPEED AND APPLYING THE BRAKES VEHICLE IS PULLING TO THE LEFT OR THE RIGHT, ALSO, THERE 1S VIBRATION/JERKING AND A GRINDING NOISE. *AK

NHTSA ID

852060

Incident

Jan 1, 1998