Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 132 NHTSA owner-reported complaints for the 1991 Ford Ranger. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 132 · page 1 of 6
TL* THE CONTACT OWNED A 1991 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND NO INJURIES WERE REPORTED AT THE SCENE. THE VEHICLE WAS DESTROYED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 150,000. UPDATED 8/23/12 *CN
TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE OF THE VEHICLE HAD DROPPED APPROXIMATELY FIVE INCHES FROM THE REGULAR POSITION AND THE FRONT FENDER WAS COVERING THE TOP OF THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTICS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE COIL SPRING MOUNT WAS CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT A LOCAL AUTO SHOP WAS CONTACTED AND ADVISED THAT THE PART WAS NO LONGER AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT STATED THAT THE FUEL TANK STRAP BECAME CORRODED AND WAS PARTIALLY FRACTURED FROM THE VEHICLE. THE CONTACT WAS CONCERNED THAT IT WOULD CAUSE THE FUEL TANK TO DETACH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE STRAP WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THERE WERE NO RELATED RECALLS TO THE FAILURE AND PROVIDED NO FURTHER ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 142,800 AND THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
THE FRAME HAS HORRIBLE CORROSION. ALL THE SPRING HANGERS ARE WERE FAILING BAD. I DON'T EVEN THINK IT CAN BE WELDED BECAUSE IT IS RUSTED FROM ONE END TO ANOTHER. FORD REALLY MESSED THIS ONE UP. AND WHY DO ALL THE FUEL GAUGES QUIT WORKING? *TR
PEELING FACTORY PAINT PRIMARILY ON TOP SURFACES..I.E. HOOD, CAB ROOF, COWLING. I HAVE OWNED TRUCK SINCE 12/8/99 AND HAS HAD PROBLEM SINCE,IT HAS LOST NEARLY ALL PAINT ON ROOF , HOOD HAS ABOUT 1/3 LEFT. PRIMARILY LIFTS/PEELS WHEN WASHED OR WHEN LEFT OUT IN RAIN. HAS HAD BITS PEEL BACK AT HIGHWAY SPEEDS. MAINLY OCCURS THOUGH WITH WASHING. HAVE INQUIRED WITH DEALERS TO NO AVAIL. WAS TOLD BY ONE THAT THERE WAS A RECALL BUT THAT THE PERIOD FOR REPAIR OF CONDITION HAD PASSED. I HAVE NOT RECEIVED NOR HEARD ANYTHING FROM MFR REGARDING THIS ISSUE WHATSOEVER. *TR
TL*THE CONTACT OWNS A 1991 FORD RANGER. WHILE DRIVING 5 MPH WITH THE DEFROSTER ACTIVATED, THE VEHICLE BEGAN TO SMOKE. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED FLAMES UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED AND STATED THAT THERE WAS A FAULTY WIRE UNDER THE HOOD THAT CAUSED THE FIRE. PRIOR TO THE FAILURE, THE CLUTCH AND POWER STEERING WERE REPAIRED AND THE GAS LINE WAS CLEANED. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER OR MECHANIC. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 100,000. UPDATED 062909 *BF UPDATED 07/01/09
THE CONSUMER MADE CONTACT WITH THE MANUFACTURE FOR THE FRONT END SUSPENSION PART THAT WAS DISCONTINUED. *JB
BOTH MIRRORS FOLDED UP AGAINST THE VEHICLE WHEN DRIVING. DRIVER'S SIDE WAS REPLACED THREE TIMES, AND THE PASSENGER'S SIDE TWICE. HOWEVER, DRIVER'S SIDE MIRROR MALFUNCTIONED AGAIN. *AK TRUCK IS IN GARAGE FROM 11-1 TOMAY 1. AND I STIKK ONLY GET1 YEAR TO 18 MONTHS PER MIRROR. I REALIZE THE VEHICLE IS 13 YEARS OLD AND REDESIGNING THE MIRROR IS NOT ANOPTION. HOWEVER, FORD MOTOR CORP SURELY COULD DO SOMETHING ABOUT THE PRICE! RETAIL IS CLOSRE TO $7500 PER PIECE. I KNOW REDESIGNING IS OUT OF QUESTION, BUT FOR THOSE OF US THAT INTEND ON KEEPING OUR VEHICLES, THE COMPANY COULD REDUCE THE PRICE. *AK
CONSUMER STATES THAT HIS MOTOR MOUNTS ARE RUSTING RIGHT OUT FROM THE FRAME. HE STATES HE HAS NEVER SEEN ANYTHING LIKE IT. HE STATES HE HAS NOT SEEN A RECALL FOR THIS PROBLEM, BUT HE DOES NOT THINK THIS IS NORMAL. *NM
RIGHT FRONT SPRING BRACKET RUSTED THROUGH ALLOWING BODY TO DROP ONTO FRONT TIRE, AND I NOTICED THERE ARE A LOT OF COMPLAINTS ON THIS ISSUE AND WAS WANTING TO KNOW IS FORD GOING TO FIX THIS PROBLEM OR ARE WE THE PUBLIC GOING TO GET STUCK WITH THIS PROBLEM ? *JB
THE VEHICLE WAS SITTING OUT SIDE WHEN THE BATTERY EXPLODED. THE VEHICLE CAUGHT ON FIRE AS A RESULT. *JG *JB
TRAVELING N ON I-95 ON 12/20/2002 AT APPROX 4 P.M. RIGHT FRONT TIRE TREAD SEPARATED, BEAT AND DAMAGED FENDER; HOWEVER, TIRE MAINTAINED SAME PRESSURE. 1 WAS ASSISTED BY OFFICER K.R. MEARES OF TOBESON COUNTY SHERIFF'S DEPT,TEL 910-671-3100. DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS------770783. *AK *NLM
WHILE PARKED, THE VEHICLE CAUGHT FIRE DUE TO A FAILED IGNITION SWITCH, MANUFACTURER INFORMED CONSUMER THAT THE FAILED PART WAS NOT WORTHY OF ANY TYPE OF ASSISTANCE TO COMPENSATE FOR A VEHICLE DESTROYED BY FIRE. PH. CONSUMER WAS INJURED WHILE TRYING TO PUT THE FIRE OUT. *JB
WHILE DRIVING VEHICLE 70MPH, FELT THE FRONT STARTING TO VIBRATE. HAD PULLED OVER AND CHECKED TIRES. THE RIGHT FRONT TIRE HAD A LARGE BUBBLE. THE TREAD WAS STARTING TO SEPARATE. WENT TO AN INDEPENDENT TIRE DEALER AND THE SPARE TIRE REPLACED THE BLOWN TIRE. NOT ORIGINAL TIRES. FIRESTONE FR 480 P215/70R14 TS
CONSUMER STATED THAT A BATTERY EXPLODED, AND VEHICLE CAUGHT FIRE. CONSUMER STATES THIS WAS VERY DANGEROUS. MANUFACTURE OF BATTERY IS JOHNSON CONTROLS INC. /SEAR DIE HARD. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
BOTH MIRRORS HAVE BEEN REPLACED MORE THAN ONE TIME BECAUSE THEY DO NOT STAY POSITIONED. DEALER HAS BEEN NOTIFIED. NLM CONSUMER STATED THAT WHEN THE MIRRORS DO NOT STAY IN POSITIONED DRIVERS HAVE NO VIEW OF REAR LANES, THE MIRRORS FOLD BACK AT HIGHWAY SPEEDS. *YH
TIRES WERE PURCHASE AT COSTCO WHOLESALE. THESE TIRES SEEM TO HAVE A WEAKER SIDEWALL THAN THE OTHERS TIRES THEY SALE. POSSIBLY A SAFETY HAZARD. THESE TIRES WERE WARRANTED TO 80,000 MILES. S.*AK
CONSUMER STATED THAT THE RIGHT FRONT SHOCK MOUNT COMPLETELY RUSTED. *YH
FIREWALL SEPARATING AND CRACKING AT CLUTCH MASTER CYLINDER. *AK
RIGHT FRONT SHOCK TOWER COLLAPSED ON VEHICLE WHICH CAME APART FROM FRAME. DEALER CONTACTED. *AK. CONSUMER STATES THE RIGHT FRONT SUSPENSION HOUSING CORRODED AND FAILED, CONSUMER STATES PART MAY NOT HAVE BEEN PROPERLY HEAT TREATED PRIOR TO INSTALLATION.*JB
THE COMPONENT HAD CORRODED AND FAILED. REPAIR SHOP SAID THEY HAD NEVER SEEN THIS BEFORE. SUGGESTED THAT THE PART MAY NOT HAVE BEEN PROPERLY TREATED PRIOR TO INSTALATION. LEFT SIDE MATCHING COMPONENT SHOWES NO CORROSION. WAS MAKING A LEFT TURN WHEN THE PART MADE A SNAPPING SOUND AND THE RIGHT FRONT OF THE TRUCK DROPPED RUBBING THE TIRE.*AK
CONSUMER PURCHASED MANUAL LOCKING HUBS FROM DEALERSHIP TO REPLACE AUTOMATIC LOCKING HUBS THAT WERE ORIGINAL EQUIPMENT FOR VEHICLE. AFTER MANUAL LOCKING HUBS WERE INSTALLED ON FRONT WHEELS VEHICLE WAS TAKEN FOR A TEST DRIVE. AFTER DRIVING FOR FIVE MILES AT A SPEED OF 10 TO 15 MPH, HOUSING FOR RIGHT/FRONT HUB CRACKED AND DISCONNECTED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
WE BOUGHT THIS TIRES IN NOVEMBER AT ROBERTSON TIRES IN TULSA, OK. I WAS DRIVING DOWN THE ROAD AND THE TIRE JUST SEPARATED FROM THE RIM. I TOOK PICTURES OF THE TIRE AND WENT TO SEE IF THEY WOULD FIX IT AND THEY SAID THAT THEY WOULD HAVE TO CHARGE ME $40 TO REPLACE THAT TIRE. THEY COULDN'T CHANGE ALL THE TIRES BECAUSE THEY DIDN'T COME WITH THE TRUCK. MY MOM HAD THE SAME PROBLEM WITH WILD COUNTRY TIRES AND FIRESTONE ENDED UP REPLACING ALL 4. THIS IS THE SECOND TIME IN MY LIFE THAT I HAVE SEEN A TIRE SEPARATE LIKE THAT AND WAS WONDERING IF THERE WAS ANYTHING I CAN DO TO GET ALL 4 REPLACED OR DO I HAVE TO GO AHEAD AND PAY TO GET THAT ONE FIXED AND PRAY THAT THE OTHERS DON'T SEPERATE LIKE THAT ONE? THE TIRE IS A FIREHAWK SS20 RWL P215/70R14. I AM SCARED TO DRIVE ON THESE TIRES. I HAVE 2 KIDS THAT RIDE AROUND IN THE VEHICLE WITH ME AND WHAT HAPPENS IF ANYMORE BLOW AND IS FATAL? I HAVE THE RECEIPT FOR THE TIRES AND PICTURES OF IT AND NEED TO KNOW WHAT TO DO. I WILL WAIT TO DO ANYTHING MORE UNTIL I HEAR FROM YOU. I WILL BE CALLING THE CORPORATE OFFICE OF ROBERTSON TIRE AND FIRESTONE. ANY INFORMATION THAT YOU CAN GIVE ME OR HELP ME WITH WOULD BE GREATLY APPRECIATED. SINCERELY, TAMMY. *AK (DOT NUMBER: HYHYF21529 TIRESIZE: P215/70R14)
CONSUMER STATES HE WAS UNABLE TO STOP VEHICLE BECAUSE OF A HIGHLY CORRODED RUPTURED BRAKE LINE, VEHICLE REAR ENDED ANOTHER VEHICLE AND CONSUMERS VEHICLE WAS DEEMED TOTALED, CONSUMER IS SEEKING REIMBURSEMENT FROM MANUFACTURER FOR THE REPAIRS OF THE BRAKES.*YH
SHIFT LEVER WAS PLACED IN PARK POSITION AND THE TRANSMISSION REMAINED IN THE REVERSE GEAR. I BELEIVE THAT THIS IS AN FMVSS VIOLATION OF THE SHIFT /INDICATION SYSTEM.*AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .