Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 243 NHTSA owner-reported complaints for the 2003 Ford Ranger. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 243 · page 1 of 10
Ford knows about the problems with the dual clutch and they are refusing to fix them. I have been giving the run around om trying to get my car fixed. I am a disabled veteran and all I get is they can't help. I just found out about these cars have this problem and ford has know about his problem for years.. they need to fix this. They again to be held according selling bad products to the public.
Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch was already needed on the frame (drivers side rear). As well as a loose bed. The truck is very clean on top but underneath is rotting away like it has 200000 miles on it(truck is at 77,000). I want to remove the rust and coat it but im scared of punching through cause spots are brittle.
The frame of my truck has rotted through. The strap that holds the gas tank has nothing to connect to, i think the tank could fall to the ground under the right circumstances. The frame has a large whole in it and i fear it will break very soon. I had to remove the spare tire because i feared it would fall off the truck. I had to replace both connectors that held the leaf springs to the frame,and was told there wasn't much left to connect them to.
Airbag warning light always on.
The contact owns a 2003 Ford Ranger. The contact stated that while driving at 65 MPH, an abnormal, rattling noise began to emit from the rear of the vehicle without warning. Upon inspection, the contact discovered that the rear cross members had rotted out due to severe corrosion. The contact also stated that the fuel tank was no longer being supported due to the failure. An independent mechanic inspected the vehicle and deemed the vehicle unsafe to drive. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 79,000.
I had been noticing some squeaking form the rear of my 2003 Ford Ranger. I thought it was my breaks. It turned out that the mounts for the rear springs had rusted out. My mechanic also noticed a hole, in the frame, resulting from rust. The hole is located on the inside surface of the frame on the passenger side just forward of the passenger compartment. Since the hole was discovered I stopped using the Ranger due to safety concerns.
THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING AT AN UNDISCLOSED SPEED, THE SPARE TIRE DETACHED FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS DRIVEN BACK TO THE RESIDENCE AND INSPECTED. THE DRIVER NOTICED THAT THE UNDERCARRIAGE AND SUB-FRAME WERE SEVERELY CORRODED. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER TO BE DIAGNOSED. THE MECHANIC STATED THAT THE SUB-FRAME HAD RUSTED OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 131,000
WHEN AT STOP LIGHT ENGINE RPMS GO UP HIGH WHERE IT IS HARD TO HOLD VEHICLE STILL WITH BRAKES.
BODY, FRAME AND SUSPENSION HAVE ALL BEEN RUSTED OUT. BUMPER RECENTLY JUST FELL OFF DUE TO RUST (WHILE PARKED). DOORS WON'T SHUT COMPLETELY DUE TO RUST, WHICH HAS LED TO THE INTERIOR LIGHT REMAINING ON OR PERIODICALLY TURNING ON THROUGHOUT THE DAY/NIGHT AND KILLING THE BATTERY. ENTIRE TRUCK IS ONE BIG PILE OF RUST ON WHEELS.
CHASSIS ROTTING OUT. LOST SPARE TIRE CARRIER AND REAR FRAME SUPPORT. SPRING PERCH ROTTED OFF CHASSIS. OTHER AREAS ARE BEGINNING TO ROT OUT ON FRAME RAILS! THINGS CAME APART IN MOTION BUT WAS ABLE TO SAFELY REMOVE UPON STOPPING
TWO YEARS AGO, A CRUNCHING NOISE WHILE TURNING WAS DETERMINED TO BE THAT BOTH REAR SPRING BRACKETS HAD RUSTED THROUGH AND BROKEN, LEAVING THE REAR OF THE LEAF SPRINGS UNATTACHED TO THE FRAME. BOTH WERE REPLACED WITHOUT INCIDENT. THIS WEEK, WHILE DOING ROUTINE MAINTENANCE, I NOTICED THE FRONT FUEL TANK HANGER WAS OUT OF PLACE. UPON EXAMINATION, ONE SIDE OF THE FUEL TANK HANGER WAS COMPLETELY DISCONNECTED FROM THE FRAME. THE CROSS MEMBER AND THE HANGER FOR THE FUEL TANK BRACKET IS COMPLETELY RUSTED AWAY. THE FRAME HAS NO STRUCTURAL SUPPORT IN THAT AREA AND NOTHING IS SUPPORTING THE FRONT OF THE FUEL TANK. IT IS UNACCEPTABLE THAT FORD IS ALLOWED TO PRODUCE FRAMES THAT RUST AWAY RIGHT UNDER THE VEHICLE SO QUICKLY. THIS TRUCK BODY LOOKS FINE, HOWEVER, THE BED IS RUSTED AWAY IN TWO PLACES AND THIS FRAME CROSS MEMBER IS COMPLETELY GONE.
THE FUEL TANK STRAP BRACKET ON THE FRAME ROTTED OUT AND THE STRAP IS NOW HANGING LOOSE. THE STRAP LOOKS TO BE RUSTY BUT WASN'T THE ISSUE IT IS WHERE THE T-SHAPE END ON THE STRAP HOOKS TO THE FRAME/BRACKET THAT IS THE PROBLEM IF THE OTHER STRAPS ARE TAKING UP ALL THE WEIGHT AND WERE TO BREAK THIS COULD CAUSE THE GAS TANK TO FALL OUT. THIS MAY HAVE HAPPENED WHILE DRIVING ON CITY STREETS. SALT SPREAD THROUGHOUT THE WINTER AND WET CONDITIONS WOULD BE THE BEST CAUSE FOR THIS TO HAPPEN RESULTING IN RUST AND CORROSION. ALSO COMMON FOR THE LEAF SPRING SHACKLES AND MOUNTS TO ROT OUT AND COME APART THIS IS ALSO ANOTHER SAFETY ISSUE IN ITSELF. THIS ALSO APPLIES TO THE MAZDA B2300 THROUGH THE B4000 SERIES PICK UPS SINCE THEY USE THE SAME RANGER FRAMES. *TR
TL* THE CONTACT OWNS A 2003 FORD RANGER. AFTER STARTING THE ENGINE AND TURNING ON THE HEATER, SMOKE AND FLAMES WERE PRESENT INSIDE THE VEHICLE COMING FROM THE DRIVER'S SIDE VENTS. A FIRE EXTINGUISHER WAS USED TO EXTINGUISH THE FLAMES. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AUTONATION FORD MOBILE (901 EAST 1-65, SERVICE RD SOUTH, MOBILE, AL) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. THE VIN WAS INVALID.
A FEW WEEKS AGO MY SPARE TIRE FELL OFF MY TRUCK WHILE DRIVING ON LAKESHORE DRIVE IN HEWITT, NJ 07421. THANKFULLY IT ROLLED OFF ONTO THE SIDE OF THE ROAD SO NO ONE ELSE HIT IT. YESTERDAY I NOTICED THE BACK END OF THE TRUCK LOOKED TWISTED ONLY TO FIND THAT THE REAR PASSENGER SIDE FRAME IS COMPLETELY SNAPPED. ONLY TO FURTHER DISCOVER THE ENTIRE FRAME, SUSPENSION, AND VARIOUS OTHER COMPONENTS ARE ROTTING HORRIBLY. MY VEHICLE HAS UNDER 70,000 MILES. I HAD AN OLDER TOYOTA TACOMA A FEW YEARS AGO THAT WAS RECALLED DUE TO FRAME RUST AND IT WAS FULLY HANDLED. HOWEVER, THE RUST AND ROT ON THIS FORD RANGER MAKE THE 1997 TACOMA FRAME LOOK NEARLY NEW. I CAN NO LONGER DRIVE THIS VEHICLE AS IT IS NOT SAFE. IRONICALLY, IT SEEM THAT THIS IS OR HAS HAPPENED TO NEARLY EVERY FORD RANGER FROM THE EARLY 2000S. PERSONALLY I FEEL WITH THE OVERWHELMING AMOUNT OF WEB EVIDENCE (LITERALLY THOUSANDS) FORD SHOULD BE HELD RESPONSIBLE. PLEASE SEE THE PHOTOS I'VE ATTACHED. THANK YOU.
TL* THE CONTACT OWNED A 2003 FORD RANGER. WHILE DRIVING AT 35 MPH, THE SPINDLE ON THE DRIVER SIDE TIRE ROD BROKE. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE SWERVED FROM LANE TO LANE THE VEHICLE WENT OFF THE ROAD. THE VEHICLE BECAME AIR BORN AND CRASHED IN A TREE. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS WOULDN'T BUCKLE. THE CONTACT SUSTAINED A CUT FROM THEIR EAR TO THEIR THROAT FROM THE SEAT BELT, THE CONTACT ALSO HAD A BURN MARK FROM THE SEAT BELT. THE CONTACT SOUGHT MEDICAL ATTENTION. THE CONTACT'S BROTHER WAS IN THE VEHICLE WAS AS WELL. THEY SUSTAINED AN INJURY BUT DIDN'T RECEIVE MEDICAL ATTENTION. THE CONTACT'S BROTHER SUSTAINED A CRACKED RIB. THE CONTACT'S VEHICLE WAS THE ONLY VEHICLE EVOLVED IN THIS CRASH. NO OTHER MEDICAL ATTENTION WAS NEEDED. A POLICE REPORT WAS MADE. THE VEHICLE WAS TOTALED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 129,000.
I BOUGHT THIS TRUCK USED ,IS THERE A RECALL ON THE AIRBAGS OR ANY OTHER RECALLS OF ANY KIND ?? THANKS *DT *TR
ENGINE QUIT RUNNING,TOOK TO MECHANIC. SPARK PLUG OVERHEATED BLEW WIRE OFF. ENGINE HAD WATER IN OIL. ENGINE IS RUINED. WAS ON HIGHWAY.HAD TO USE WRECKER TO MECHANIC.ONLY 160,000 MILES ON HIGHWAY. THOUGHT RECALL ON FORD TRUCKS TO ENGINES GIVING AWAY PREMATURELY.
SEVERE FRAME ROT (RUST) AT APROX. 85000 MILES, ALREADY REPLACED LEFT REAR LEAF SPRING MOUNT (APROX. 2 YEARS AGO) FRAME CROSS BRACES ARE RUSTING THROUGH INCLUDING THE SPARE TIRE MOUNT.10/10/16. MY BELIEF IS THAT THERE WAS LITTLE OR NO CORROSION RESISTANT APPLIAD TO THESE FRAMES UPON VEHICLE ASSAMBLY. GOOD USABLE PARTS ARE HARD IF NOT IMPOSSIBLE TO FIND AS MOST ARE AS BAD OR WORSE THAN MY EXISTING PARTS. I BELIEVE THIS ISSUE EXISTS WHEN VEHICLE IS STATIONARY OR IN MOTION.
MY 2003 FORD RANGER EDGE FRAME HAS RUSTED AROUND THE FUEL STRAP ON THE DRIVER SIDE. THE FRAME HAS RUSTED CLEAR THROUGH AND BROKE IN HALF. I HAVE SEEN SEVERAL COMPLAINTS ON THE INTERNET AS THIS IS SIMILAR TO WHAT WAS HAPPENING TO THE TOYOTA TRUCK THAT HAD IT'S FRAME RECALLED.
ENGINE STOPS RUNNING WITH NO WARNING. HAPPENED 3 TIMES IN LESS THAN A MILE, UNDER 35 MPH.STARTED BACK UP .GAUGES WERE NORMAL WITH PLENTY OF FUEL. 1ST TIME ENGINE QUIT, I HAD JUST STARTED MOVING , NEXT 2 TIMES I WAS MOVING UNDER 35 MPH AALL TOOK PLACE IN LESS THAN 1/4 MILE IN TRAFFIC
TL* THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT TOOK THE VEHICLE TO FRIENDLY FORD (2800 N TELEGRAPH RD, MONROE, MI 48162) TO BE REPAIRED PER AN UNKNOWN AIR BAG RECALL. UPON ARRIVING AT THE DEALER, THE CONTACT WAS CHARGED A FEE TO REPLACE WIRES THAT WERE CUT DURING THE AIR BAG REPLACEMENT. THE CONTACT RECEIVED ANOTHER RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 17V788000 (AIR BAGS). THE CONTACT HAD NOT TAKEN THE VEHICLE BACK TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 4,000.
EVERY SO OFTEN WHEN I STEP ON THE BRAKE AND ACCELERATE ONE TIME I ALMOST BACKED INTO SOMEBODY THERE'S BEEN A LOT OF COMPLAINTS ON THE INTERNET ABOUT THIS HAPPENING TO THEIR FORD RANGER 2003
FRAME IN REAR OF VEHICLE HAS HOLES ON BOTH THE LEFT SIDE AND RIGHT SIDE. ALSO WHERE THE SPARE TIRE IS HELD IS ALSO ROTTED OUT , CAN NOT HOLD A SPARE TIRE. ALSO THE CROSS MEMBER THAT HOLDES THE THE GAS TANK STRAP IS ALSO ROTTING.DUE TO THE ROTTED FRAME THE TRUCK IS UNABLE TO TOW ANYTHING WITH. OTHER THAN THE FRAME THE TRUCK IS IN GOOD CONDITION
FRAME AND CHASSIS HAS SEVERE ROT FRAME IS ALSO CRACKED. BUMPER FELL OFF WHILE DRIVING REAR BUMPER. THIS IS A 2003 FORD RANGER 5 SPEED 2 WHEEL DRIVE IT HAS LESS THAN 81000 MILES ON IT. THE BUMPER FELL OFF WHILE THE VEHICLE WAS BEING DRIVEN. I DO NOT HAVE PICTURE OF FRAME BUT IF ASKED I COULD GET SOME.
TL* THE CONTACT OWNS A 2003 FORD RANGER. WHILE TAKING THE VEHICLE TO RECEIVE NEW TIRES AT SCHIERL TIRE AND SERVICE CENTER (1002 S 8TH STREET, MEDFORD, WI 54451; 715-748-2963), THE CONTACT WAS INFORMED THAT THE REAR FRAME NEAR THE SHACKLES AND BUMPER WAS SEVERELY RUSTED. THE RUST WAS SO BAD THAT NOTHING COULD BE ATTACHED TO THE FRAME. THE CONTACT CALLED MEDFORD MOTORS (105 WISCONSIN AVENUE, MEDFORD, WI 54451; 715-748-3700) WHO INFORMED THE CONTACT THAT THE FAILURE WAS PREMATURE AND THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .