2005 Ford Ranger Problems

The contact owned a 2005 Ford Ranger. The contact stated while driving at 50 MPH, the vehicle was rear-ended by a driver who ran the stop sign. The impact caused the vehicle to flip over multiple times. The air bags failed to deploy. The contact suffered severe head trauma and PTSD from the accident. It was unknown if the other driver sustained any injuries. The contact was taken to the local hospital where medical attention was received for his injuries. A police report was filed. The vehicle was towed to a local salvage junkyard. The VIN was included in NHTSA Campaign Number 23V306000 (Air Bags). The local dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000. The VIN was not available.

See attached document for complaint

I WOULD BE DRIVING AND ALL OF A SUDDEN THE WHOLE VEHICLE WOULD JUST SHUT DOWN. THIS HAPPENED 3 OR 4 TIMES JUST GOING AT 25 TO 35 MPH. AT FIRST, I THOUGHT IT WAS A CLOGGED FUEL LINE SINCE IT WOULD SOMEHOW RESET ITSELF AFTER HAVING IT TOWED TO MY MECHANIC SO I REPLACED THE FILTER EVEN THOUGH I COULD SEE NOTHING WRONG. WHEN IT HAPPENED AGAIN ON A BACKCOUNTRY ROAD THE MECHANIC SAID IT WAS PROBABLY THE FUEL PUMP SO I HAD THE WHOLE THING REPLACED. IT HAPPENED ONE MORE TIME AFTER THAT, I WAS PULLING ONTO A MAJOR HIGHWAY AND HAD JUST GOTTEN UP TO SPEED 55 MPH AND THERE WAS A TRACTOR-TRAILER BEHIND ME WHEN ALL OF A SUDDEN AGAIN EVERYTHING SHUT DOWN. LUCKILY I HAD ENOUGH MOMENT BUILT UP I WAS ABLE TO COAST TO THE SIDE OF THE ROAD BEFORE GETTING HIT BY THE TRACTOR-TRAILER. I FINALLY LOOKED ONLINE AND FOUND THAT SOMEONE HAD MENTIONED THE SAME PROBLEM IT MAY BE THE INERTIA SWITCH. I CALLED UP A LOCAL DEALERSHIP AND HAD ASKED THE PARTS PERSON IF THE HAD A REPLACEMENT AND IF HE HEARD ANY PROBLEMS ABOUT IT. I WAS TOLD IT WOULD HAVE TO BE ORDERED BECAUSE THEY WERE OUT OF THEM, THEY HAD SOLD A FEW IN THE PAST MONTHS. WHEN I EXPLAINED THE PROBLEM I WAS TOLD OH YES WE HAVE HEARD ABOUT THAT HAPPENING BUT THERE WAS NO RECALL. I EXPLAINED HOW IT COULD BE A SAFETY PROBLEM AND WAS TOLD THAT IT MUST NOT BE HAPPENING ENOUGH FOR IT TO BE A RECALL. I RECENTLY FOUND THIS SITE AND HAVE SEEN THAT I AM NOT THE ONLY ONE WHO HAD THIS HAPPEN SO AT LEAST I KNOW I WASN'T CRAZY. *TR

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING, THE ACCELERATOR PEDAL BECAME STUCK. IN ORDER TO CORRECT THE FAILURE, THE VEHICLE WAS SHIFTED INTO NEUTRAL AS THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 245,000. *TT CONSUMER STATED WHEN GIVING VEHICLE FALL OPEN THROTTLE, THROTTLE PEDDLE STICKS AND THERE IS NO CONTROL OF SPEED. UPDATED 10/17/18*JB

THE REAR PORTION OF THE FRAME IS RUSTING AWAY AND THE LEAF SPRING SHACKLE FELL OFF WHILE DRIVING ON A CITY STREET CAUSING THE BED OF THE TRUCK TO FALL ONTO THE BUSTED SHACKLE. THE SPARE TIRE MOUNT IS RUSTED SO BAD THAT WE REMOVED THE SPARE TIRE TO AVOID LOOSING THE SPARE WHILE DRIVING. THE REAR BUMPER SEEMS UNSTABLE AS THE FRAME IS RUSTED AND FALLING APART FROM THE REAR SHACKLE MOUNT ON BACK. THE FRONT PORTION OF THE FRAME SEEMS TO BE HOLDING UP OK.

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED WHILE DOING A ROUTINE CHECK UNDER THE VEHICLE, THE CONTACT NOTICED THAT THE SUBFRAME UNDER THE VEHICLE WAS SEVERELY RUSTED. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

THE LEAF SPRING BUSHINGS PUSHED THREW THE ROTTED FRAME AND POKED HOLES IN THE BED OF THE TRUCK .THE SPARE TIRE WAS HANGING ON THE GROUND WHEN I GOT HOME ONE DAY. NOW MY INSPECTION STATION WONT PUT A INSPECTION STICKER ON IT BECAUSE THEY SAY ITS TO DANGEROUS.TOYOTA HAD THIS PROBLEM AND ETHER REPAIRED THE VEHICLE OR REPLACED IT. *TR

THE LEAF SPRING SHACKLES ROTTED THREW THE FRAME AND THE SPARE TIRE HOLDER DROPPED THE SPARE TIRE WHILE DRIVING THIS IS DANGEROUS

I HAD THE AIR BAGS REPLACED, AFTER NEW AIRBAGS WERE INSTALLED. AIR BAG WARNING LIGHT WAS FLASHING, CODE 27, WHICH MEANS PASSENGER AIR BAG BYPASS MODULE # F81B-14BZ68-AD. MODULE HAD A BAD INDICATOR LAMP WHICH IN TURNS DISABLES THE ENTIRE AIR BAG SYSTEM. SO IN MY OPINION FORD SHOULD REPAIR THIS SO THAT I CAN HAVE AIR BAGS TO PROTECT ME. WITH THIS LAMP NOT FIXED I HAVE NO AIR BAGS, SO THE RECALL WAS USELESS. I NEED THIS FIXED AND THINK IT SHOULD BE CONSIDERED A SAFETY ISSUE ALONG WITH THE AIR BAG RECALL. I SPOKE TO FORD AND THEY INFORMED ME THAT IT WAS OR MAYBE IS AN ISSUE, NO COMMITMENT THERE. I CANNOT AFFORD THE INSPECTION COSTS BUT YOU TUBE GAVE ME ALL THE INFORMATION I NEED TO KNOW, THE $89 FOR INSPECTION AND $125. FOR PARTS AND INSTALLATION ARE WAY OUT OF MY BUDGET. THIS IS A SAFETY MATTER THAT NEEDS TO BE ADDRESSED. YES THIS IS A CONSTANT CONDITION TO THE FORD RANGER AS IT SITES NOW. THE YOU TUBE SITE I USED IS: WWW,YOUTUBE.COM/WATCH?V=U5MAYZJCTM, SO ANYONE CAN DIAGNOSIS MY TRUCK. DON'T NEED $89.00

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STOPPED IN THE MIDDLE OF TRAFFIC WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE CONTACT'S RESIDENCE AND THE CONTACT REPLACED THE FUEL FILTER. THE FAILURE RECURRED AND THE CONTACT REPLACED THE FUEL PUMP. THE FAILURE RECURRED A THIRD TIME AND THE VEHICLE WAS TAKEN TO AN UNKNOWN INDEPENDENT MECHANIC WHO DIAGNOSED AND REPLACED THE INERTIA SWITCH. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS NOT PROVIDED.

Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill

COUPLE DAYS AFTER BUYING VEHICLE TRUCK BROKE DOWN DEALER REFUSED TO TAKE RESPONSIBILITY ALSO THE BIGGEST COMPLAINT IS DEALER REFUSES TO GIVE US LICENSE PLATES WE PURCHESD THE VEHICLE NOVEMBER 12, 2015 AND DEALER IS HOLDING PLATES HOSTAGE WE DO NOT OWE HIM ANY MONEY

The contact owns a 2005 Ford Ranger. The contact stated that upon arriving to the residence and applying the parking brake and exiting the vehicle, the vehicle started to roll backwards. The contact stated that the vehicle came to a complete stop after rolling across the street and through the neighbor’s fence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 223,000. The VIN was not available.

The contact owns a 2005 Ford Ranger. The contact received notification of NHTSA Campaign Number: 23V306000 (Air Bags) and requested to be removed from the recall distribution list because the vehicle was totaled. The local dealer was contacted. The manufacturer was not contacted.

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING AT AN UNKNOWN SPEED, THE LOW TIRE PRESSURE MONITORING SYSTEM WARNING LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT ALL FOUR TIRES WERE LOSING AIR. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN ADDED AIR TO THE TIRES. THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,500. THE VIN WAS UNAVAILABLE.

UNDER- BED MOUNTED SPARE TIRE MOUNTS RUSTED THROUGH CAUSING TIRE TO BREAK FREE FROM VEHICLE AT HIGHWAY SPEEDS. UPON FURTHER INSPECTION IT WAS NOTED VEHICLE HAS SERIOUS FRAME DAMAGE FROM RUST, PARTICULARLY THE FUEL TANK SUPPORT STRAPS. THE FRAME IS FALLING APART AT AN ALARMING RATE. *TR

At 200k miles I got an air bag light on my guage cluster. The blinking code corresponded to a bad connection at the CLOCKSPRING. I also noticed my cruise control and horn were also inoperable, also an indicator of a bad CLOCKSPRING. Ford part number 1l5z-14a664-ab is the replacement part and is currently unavailable, for the last 6 months. This part covers a few different models and has been exhausted by the dealers when correcting the Airbag recall. The dealer can not give me a date on a replacement part.

Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill

TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING 5 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE DROVE OVER AN ICY PATCH, SLID, AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED A STOMACH INJURY, BUT DID NOT RECEIVE MEDICAL ATTENTION. THE OTHER DRIVER SUSTAINED AN INJURED BACK. THE CONTACT DID NOT KNOW IF THE OTHER DRIVER SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT'S VEHICLE WAS NOT DAMAGED AND WAS DRIVEN TO THE CONTACT'S HOME. THE VEHICLE WAS LATER TAKEN TO COURTESY FORD LINCOLN (313 NE 122ND AVE, PORTLAND, OR 97230), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,043. THE VIN WAS UNKNOWN.

L/FRONT SUSPENSION SNAPT FROM THE FRAME (THE FRAME BROCK).

The contact owns a 2005 Ford Ranger. The contact stated that upon arriving to the residence and applying the parking brake and exiting the vehicle, the vehicle started to roll backwards. The contact stated that the vehicle came to a complete stop after rolling across the street and through the neighbor’s fence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 223,000. The VIN was not available.

I HAVE LEARNED THE HARD WAY THAT THE SHIFTER ON THE 2005 FORD RANGER EXTENDED CAB WILL JUMP OUT OF PARK TO REVERSE. THIS HAPPEN TO ME (JUST RECENTLY) AND CAUSED ME TO TEAR UP MY DOOR AND FENDER ON THE VEHICLE (WHICH WILL BE COSTLY)...

DUE TO EXTENSIVE RUST DAMAGE DESPITE PROPER PREVENTATIVE MAINTENANCE, THE INTEGRITY OF THE FRAME/CHASSIS OF THE VEHICLE WAS COMPROMISED. SUBSEQUENTLY, THE LEFT SIDE OF THE FRAME AT THE MIDWAY POINT OF THE LENGTH OF THE VEHICLE SNAPPED COMPLETELY SEPARATING INTO TWO PIECES. THE RUST DAMAGE ALSO CAUSED THE SPARE TIRE APPARATUS TO BREAK AND ALSO CAUSED THE BUMPER TO FALL OFF.

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING WHEEL WHEN MAKING LEFT OR RIGHT TURNS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

2005 FORD RANGER - LEAKING TRANSMISSION FLUID FROM LINES RUBBING ON THE TRUCK FRAME. START AFTER 45K SERVICE AT DEALER. REPLACE FRONT BRAKE PADS WITH MACHINING LIGHT DUTY($468.43). NOT UNDER 10 YEAR WAR. PARTS AND LABOR $350.00. FOR TRANSMISSION LINES REPLACEMENT OCT. 29, 2008 FORD TOWN ALBANY SHOP. *TR

I AM THE OWNER OF A 2005 FORD RANGER THERE WAS A PROBLEM WITH THE TRANSMISSION. IT WAS TAKEN TO THE DEALER AFTER APPROXIMATELY 5 DAYS WE WERE ABLE TO PICK THE FORD UP AND THE TRANSMISSION WAS REPLACED. SHORTLY AFTER THIS THE VEHICLE STARTED TO SHUT DOWN WHILE DRIVING FOR NO APPARENT REASON .DURING ONE OF THESE TIMES IT SHUT DOWN I WAS REAR ENDED,IT WAS TAKEN BACK TO THE DEALER WAS THERE FOR 3 DAYS, AND THEY SAID THERE WAS NOTHING WRONG WITH THE VEHICLE AS THEY COULD NOT DUPLICATE THE PROBLEM THE DEALER INFORMED ME THE VEHICLE HAD NO PROBLEMS, AND WAS VERY SAFE TO DRIVE. ALSO, I CONTACTED FORD , AND WAS INFORMED THERE HAVE BEEN NO OTHER COMPLAINTS OF THE 2005 FORD RANGER JUST SHUTTING DOWN. THIS VEHICLE WAS FAR FROM SAFE NOT ONLY FOR THE DRIVER AND ANY PASSENGERS BUT ALSO FOR OTHER DRIVERS ON THE ROAD. AS IT JUST SHUT OFF WHEN IT WANTEDF. *AK

TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE PASSENGER SIDE TURN SIGNAL FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE STEERING COLUMN MULTI FUNCTION SWITCH WOULD NEED TO BE REPLACED. THE CONTACT WAS INFORMED OF A RECALL FOR NHTSA CAMPAIGN NUMBER: 11V352000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED BUT STATED THE VIN WAS NOT PART OF THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 70,000.

HEADLAMP SWITCH KNOB BREAKS AND FALLS OFF. 2ND REPLACEMENT IN 2005 FORD RANGER WITH 8000 MILES. WITHOUT KNOB, IMPOSSIBLE TO TURN HEADLAMPS ON AND OFF WITHOUT PLIERS. HAD TO BUY NEW SWITCH KNOBS.

I OWN A 2005 2 DOOR FORD RANGER XLT. WITH APPROXIMATELY 29,000 TOTAL MILES. IT IS SUPPOSED TO BE COVERED UNDER THE NEW CAR WARRANTY UNTIL AUGUST 2008 OR 30,000 TOTAL MILES. PROBLEM: THE PASSENGER SIDE SEAT BACK OCCASIONALLY STICKS IN THE FULL UPRIGHT OR RECLINED POSITION WHEN THE SEAT BACK RELEASE LEVER IS PULLED UP, (ACTIVATED). IT TAKES UP TO SEVERAL MINUTES OF JIGGLING THE BACK AND RELEASE LEVER TO GET THE BACK TO SWING FORWARD. ALSO THE RELEASE LEVER HAS BEEN FOUND TO STICK IN A POSITION THAT WON'T ALLOW THE BACK TO MOVE. OUR GRANDSONS HAVE BEEN RIDING IN BACK AT TIMES, (UNTIL I REALIZED THE POTENTIAL DANGER OF NOT ALLOWING THEM TO EXIT IN A HURRY). I HAVE TAKEN THE TRUCK TO THE LOCAL DEALER, (I WILL GO THERE TOMORROW FOR THE FORTH TIME) TO HAVE THE MECHANISM FIXED OR THE SEAT REPLACED. THE DEALER STATES THAT THEY CANNOT FIX THE PROBLEM UNLESS IT OCCURS WHEN THEY ARE WORKING ON THE TRUCK. THE PROBLEM FIRST APPEARED ABOUT A YEAR AGO, I BELIEVE. I HAVE INFORMED THE DEALER, VERBALLY, OF THE POTENTIAL DANGER, BUT THEY APPEAR TO BE ADVERSE TO MAKING A CORRECTION. I COULD FIND NO RECALL NOTICE OR OTHER INFORMATION OF SIMILAR PROBLEMS WITH TWO OLDER RANGERS I OWNED IN THE PAST. *TR

DT*: THE CONTACT STATED WHILE DRIVING 2 MPH IN REVERSE, THE VEHICLE NEARLY STRUCK A PEDESTRIAN DUE TO THE SEAT BACKS OF BOTH THE DRIVER AND PASSENGER SEATS BLOCKING OUT MOST OF THE VISIBILITY THROUGH THE REAR WINDOW. A SERVICE DEALER WAS CONSULTED, WHO INSTRUCTED THE CONTACT TO CONTACT THE MANUFACTURER.

REAR PASSENGER SAFETY RESTRAINTS ARE NOT ADEQUATE TO PREVENT INJURY OF PASSENGERS. PASSENGERS BUMP THEIR HEADS ON REAR WINDOW IF DRIVER MUST BRAKE QUICKLY OR ACCELERATE RAPIDLY. SO FAR ONLY MILD INJURY, BUT CANNOT USE THE VEHICLE FOR CARRYING THREE OR MORE PASSENGERS AS WAS THE INTENT WHEN TRUCK WAS PURCHASED. *AK

TL*THE CONTACT OWNS A 2005 FORD RANGER. WHEN IT RAINS, WATER ENTERS THE MOTOR AND FREEZES THE WINDSHIELD WIPERS, RENDERING THEM INOPERABLE. THE VEHICLE IS UNDER WARRANTY UNTIL MARCH OF 2008, BUT THE WINDSHIELD WIPER MOTOR IS NOT. THE COST TO REPAIR THE MOTOR IS $105.04. THE CURRENT MILEAGE WAS 19,000 AND FAILURE MILEAGE WAS 18,574. UPDATED 02/15/08. *LJ