2019 Ford Ranger Owner Complaints

Auto transmission is failing to shift when taking off from a stop or hesitating to shift to next year causing traffic behind me to get close to rear bumper.

NHTSA ID

11755076

Incident

Aug 1, 2026

1st I reported to Ford that when my truck was in park and off, it started rolling down a hill. I jumped in and stopped it. Ford said they see nothing and everything looks fine. Since then I use the emergency break every time. 2nd, you feel the transmission shifting hard. Jerks truck. Also, if you drive around 25 mph, the truck starts jerking like it cant make up its mind what gear to be in.

NHTSA ID

11752783

Incident

Jul 23, 2026

Weak steel from connection point of rear leaf springs failed, leaving the springs unconnected at front eye of connection point

NHTSA ID

11752638

Incident

Jul 1, 2026

I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.

NHTSA ID

11747696

Incident

May 23, 2026

The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11747616

Incident

Jan 1, 2022

The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.

NHTSA ID

11746830

Incident

Jun 26, 2026

I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.

NHTSA ID

11745640

Incident

Jun 20, 2026

Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me

NHTSA ID

11743330

Incident

Jun 4, 2026

The contact owns a 2019 Ford Ranger equipped with Dunlop Tires. Tire Line: AT2O, Tire Size : 265/65R17 110HI, DOT number DAAH D31R. The contact stated that while driving 65 MPH, the passenger-side rear tire blew out. The thread separated and was on the roadway. The contact was able to continue to drive. The contact called a tire center, but they failed to respond. The local dealer was not contacted. The manufacturer was not contacted. The tire mileage was unknown. The failure mileage was approximately 97,000.

NHTSA ID

11738570

Incident

Apr 19, 2026

Mileage

97,000 mi

My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.

NHTSA ID

11736221

Incident

Dec 18, 2025

The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.

NHTSA ID

11735236

Incident

Feb 27, 2026

Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.

NHTSA ID

11734116

Incident

Mar 18, 2025

Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.

NHTSA ID

11733822

Incident

Apr 11, 2026

JULY 2024 THE RIGHT SIDE BACK LEAF SPRING WAS BROKEN. WAS REPLACED UNDER WARRANTY. APRIL 2026 THE LEFT SIDE BACK LEAF SPRING IS BROKE. WAITING TO HEAR FROM FORD IF IT WILL BE COVERED OR NOT. LEAF SPRINGS SHOULD NOT BE BREAKING. I DO NOT HAUL THINGS OR EVEN GO OFF ROAD WITH MY 2019 RANGER. IT HAS 74012.10 MILES ON IT NOW.

NHTSA ID

11732372

Incident

Apr 19, 2026

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.

NHTSA ID

11731902

Incident

Feb 27, 2019

Mileage

951 mi

On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.

NHTSA ID

11728932

Incident

Mar 27, 2026

Restraints indicator lamp warning. Air bag warning is on due to a problem with the front passenger side airbag. The front passenger airbag may not function.

NHTSA ID

11726607

Incident

Feb 10, 2023

both rear springs broken at the front eye mounts. the rear leaf springs hold the rear axle in place need I EXPLAIN MORE? I have not had the truck inspected, I have been in the automotive industry for over forty years. I first heard a noise from the springs when entering a parking lot and drove over a curb. No electronics attached to the springs.

NHTSA ID

11726465

Incident

Dec 31, 1969

The transmission failed prematurely (my point-of-view) at around 115,000 miles. A Ford dealer diagnosed and determined the transmission needed replaced. The vehicle was a 2019 Ford Ranger XL with a 10-speed automatic transmission. The transmission would get stuck in 2 gear, sometimes upshifting and sometimes downshifting. Driving highway speeds the speed needle would also drop to zero even though I was moving. They noted that solenoids were bad but replacement was needed. I had the transmission replaced with a new warrantied transmission but it was very expensive at $9,650. It did come with a 2-year warranty. That is half the value of the truck! This is the fourth Ford truck I have owned. I do use it as a truck and haul a few things around as projects dictate but do little towing, drive it reasonably, and do not take it off-roading. I have never had a transmission fail before. The Ford dealer, and three area shops, noted they see "a lot of 10-speeds" come in for transmission rebuild or replacement. As a now review many Ford forums I see many people with issues surrounding the durability of the 10-speed transmission.

NHTSA ID

11724978

Incident

Oct 22, 2025

Since owning the vehicle, I have experienced a range of serious transmission issues. These include harsh or delayed gear shifts, inconsistent downshifts, and transmission slipping. The vehicle also frequently jerks or lurches during gear changes. Of particular concern is the vehicle’s behavior during downshifting. At times, the transmission downshifts abruptly and causes the vehicle to lunge forward unexpectedly. This unpredictable behavior presents a significant safety concern, particularly in traffic situations where smooth and predictable vehicle response is essential. These transmission issues negatively affect the safety, drivability, and reliability of the vehicle and are not consistent with normal operation.

NHTSA ID

11724320

Incident

Mar 8, 2023

My transmission has failed at 131,000 miles on my vehicle. It roughly shifts into reverse and harshly shifts while in drive and the vehicle is in motion. My truck shakes while the transmission searches for gears and shifts slowly requiring extra power to move in normal operating conditions.

NHTSA ID

11724035

Incident

Mar 11, 2026

Airbags: passenger rear and front side airbags did not deploy after being struck on the passenger side by another vehicle. Seatbelts: were ineffective Vehicle was sold due to system failures and equipment issues. Safety: Head and body trauma due to non deployment. Inspection: Unknown No system messages before collision

NHTSA ID

11723752

Incident

Mar 26, 2024

10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.

NHTSA ID

11723225

Incident

Feb 27, 2026

Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.

NHTSA ID

11723121

Incident

Mar 9, 2026

My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.

NHTSA ID

11720076

Incident

Feb 2, 2026