Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 2024 Ford Ranger submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 32 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 32, in the owner's own words
The contact owns a 2024 Ford Ranger. The contact stated that while driving at 55 MPH, the radio display screen started flickering. The failure was a recurring failure. The dealer was contacted, and the radio was replaced; however, the failure persisted.
Truck switched drive mode to slippery on its own. Put truck into 4x4 at 70mph on highway in a turn
While driving a 2024 Ford Ranger Raptor at approximately 40 mph under normal road conditions, the vehicle experienced a sudden and uncommanded drive-mode failure. Without any driver interaction with the center console GOAT mode dial, the truck spontaneously began cycling through drive modes and attempted to engage the 4-wheel drive system. The driver's instrument cluster displayed a warning message stating "Stop to go to 4L," indicating that the vehicle's computer module was actively trying to shift the transfer case into 4-Wheel Drive Low while traveling at highway speeds. While the vehicle's digital electronic guardrails successfully blocked the physical shift into 4-Low due to the vehicle's current velocity, the uncommanded shift command represents a severe safety hazard. If the software safety parameters fail to block an unprompted 4-Low shift at these speeds, it could cause catastrophic mechanical failure, instantaneous drivetrain lockup, or an immediate loss of vehicle control. This is a known issue within the owner community that requires an official investigation to determine if a manufacturing defect exists in the All-Terrain Control Module (ATCM) or the physical mode-selector switch assembly.
The contact owns a 2024 Ford Ranger. The contact stated that while driving at approximately 15 MPH and making a U-turn, the vehicle experienced a total loss of motive power. The Service Emergency Brake and Trailer Brake Assist warning lights illuminated. The vehicle was towed to a local dealer, where it was diagnosed; however, the diagnosis details were unavailable. Additionally, during rainy weather, water intruded into the cabin and accumulated, leaving the seats wet and causing mold growth. The local dealer was contacted on several occasions regarding the water intrusion. Upon further investigation, the contact associated the failure with NHTSA Campaign Number: 26V238000 (Structure, Electrical System) and NHTSA Campaign Number: 25V541000 (Air Bags), suspecting that improper completion of a prior recall repair contributed to the failure. The manufacturer was notified of the failure by telephone and email. The failure mileage was approximately 50,148.
The vehicle intermittently changes its drive mode on its own, with no input from the driver. This has happened approximately 6 to 12 times. It occurs in two situations. While stopped at a traffic light, the vehicle has switched itself into Rock Crawl mode, and on other occasions into Baja mode. During at least one Rock Crawl event I believe the rear differential locker engaged, though I did not photograph the cluster to confirm it. The vehicle has also attempted to change drive modes while driving on the highway at speed. When it happens, the drive mode change animation appears in the instrument cluster. If I notice it immediately I can manually reselect Normal mode before the new mode fully engages. If I do not catch it in time, the mode engages. Safety risk: an unrequested change into Rock Crawl or Baja alters throttle mapping, transmission shift scheduling, traction and stability control calibration, and driveline configuration, and in Rock Crawl potentially the differential lockers. A mode engaging while stopped and then pulling into traffic, or the system attempting a mode change at highway speed, produces a loss of expected vehicle handling and response. The vehicle was taken to a Ford dealer. The dealer was unable to reproduce or confirm the problem. They reflashed all vehicle modules. The failure has recurred multiple times since that reflash, so the reflash did not correct it. No warning lamps or messages appear other than the drive mode animation in the instrument cluster. The vehicle is available for inspection upon request. I believe the cause is a fault in the electronic module or software controlling drive mode selection.
In the 21 months I have owned this 2024 Ford Ranger Lariat, it has changed driving modes 15-20 times ON ITS OWN. It goes from NORMAL OR ECO all the way to SAND, from 2wd to 4wd lo if I am stopped or 4wd high, (while telling it cannot go to 4lo if I don't stop), when I at at highway speeds.It also locks the differential so steering is somewhat compromised. If this thing decides to overrule the speed requirements for shifting to 4lo on the freeway, this would put others at risk. The truck has changed modes while Idling, at a cold start, and at driving speeds. the dealer says they could not replicate the problem, (it is very random), and that they found no trouble codes. I believe that engineers would only assign trouble codes to something they think is possible. This has happened since the first night I took it home, but until last month when it did it while I was alone in the truck, I thought my wife was accidentally hitting the switch on the center console. Searching this on the internet will find many people reporting the same problem, with a very small number reporting that their dealer replaced the selector switch, (ATCM). No warning lamps appear other than the message that it cannot go into 4lo unless I stop.
Filed a complaint that Rangers had a recall on wiring harness and this vehicle was made in the Michigan plant where other Rangers had the recall. This particular Ranger should have been included in the recall. The dealership refused to do their due diligence. I filled a complaint and have a case number. CXH09344864X2D6B2. These issue needs to be resolved in a timely manner as it can cause fires and children are riding in this vehicle.
The drive mode suddenly changes without input from the driver. Sometimes the vehicle will change from 2H to 4H without touching the mode selector knob. this is dangerous for the vehicle to randomly change drive settings without the driver knowing. There is an electrical issue or short in the mode selector dial.
The truck changes drive modes and will shift from 2wd to 4wd randomly, including on the freeway. i have had it change from 2wd to 4wd suddenly on the freewway at 65+ MPH. Attempted to take to Lithia Ford in Fresno awhile back and they could not reproduce the issue
The consumer owns a 2024 Ford Ranger. The consumer received notification of NHTSA Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that the parts were unavailable, even though the recall notification stated that parts were available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle remained with the dealer unrepaired since June 22, 2026. The contact stated that the interior lights, including the dome light and the sun visor lights, were inoperable. The dealer confirmed the failure.
lariat ranger 2024 changes modes without input from driver. This has happened dozen times btu not consistent It has happened at 80mph on interstate ,35 mph on road, leaving parking space, and turning corner after stopping for stop light This time went in to 4wheel drive low on dry pavement very difficult to steer until stopped and put back into 2 wheel drive. Has happened in dry weather and rainy weather. 50 degrees and 100 degrees dealer says ford has no reported problems to dealers. dealer says can not do anything without replicating problem while they test drive I am not leaving my Ranger with them to test drive for weeks. It is an inconsistent problem that can not be replicated by any one action
This 2024 Ford Ranger Pickup is part of recall # 26V238. The vehicle has been at the dealer since 6/20/2026. Today is 8/30/2026. There have been several dates given for the release of the fix for this recall and all have come and gone. Ford does not seem to be acting in a timely manner to correct this issue. Since i purchased the vehicle used, I do not qualify for a buy back nor does it fall under lemon laws. Ford has provided a loaner vehicle but it is a compact SUV not the truck that I need for my daily needs. PLEASE do what you can to get Ford to correct this issue soon. Thank you
On multiple occasions while driving the vehicle will randomly change drive modes by its self. It will try to go into 4x4 low gear (rock crawl mode) at highway speeds. This has happened a dozen times since I purchased the vehicle new.
The contact owns a 2024 Ford Ranger. The contact received notification of NHTSA Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that there was an abnormal burning odor inside the vehicle, and the instrument cluster flickered while driving. The dealer was contacted and confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that a second letter would be sent once the remedy was available, and parts were anticipated by the end of August 2026. The failure mileage was approximately 323.
Hello, I have a 24-ford ranger raptor, this incident happened twice, I was driving approximately 60 MPH and vehicle on its own started changing drive modes. It switched itself to baja mode which is 4-wheel drive and very dangerous at these speeds. I took my truck to local ford dealer in Valencia Ca, Dealer stated no codes or issues found. This is deeply concerning to me; I Have family that also drives this vehicle. I have read online that other same vehicle owners are experiencing same symptoms and heavy concerns. Not sure where to go from here, any help or feedback would greatly appreciated. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
There's no remedy to this recall in a timely manner. Ford has provided a remedy for the 2025 and 2026 model, but not my 2024. They need to do better.
The vehicle went into BAJA Mode 4wd high then 4wd low range out of nowhere while driving. It shot me off the road , and ive been researching it. There is a 6 page thread about new rangers and ranger raptors doing this on 6G ranger forum, tons of people with the same issue. Super scary. Fear injury or fatality will happen from this as it shoots you hard off the road
The truck shifted its drive mode from normal driving into Baja mode by itself, and also shifted the transmission from 2H to 4H, potentially damaging the transmission and causing a safety issue on the highway.
Vehicle experienced unintended transmission gear change without driver input from the gear selector. While driving, the transmission shifted unexpectedly into 4H even though the selector was not touched. This created a safety hazard due to sudden change in vehicle behavior, including: loss of acceleration, lurching and unexpected movement. Issue occurred at approximately 30 mph. Concern is potential electronic transmission control or shift-by-wire malfunction causing unintended gear engagement.
The incomplete recall 26V238 is a concern. They say in the letter from Ford that it could be a fire issue. It seems the harness in the A pillar gets pinched and could short out causing the overhead lighting or mirror lighting to either cause a smoke issue or fire. BUT THE ANSWER IS NOT GOING TO BE AVAILABLE UNTIL LATE JULY MAYBE!! Why send a letter and state you have no answer yet or will have for a couple of months!!! Am I supposed to be happy that I will know why the fire breaks out? Some 1400 potential failures out of 140,000 is the prediction per a conversation with your [XXX] on the chat line. This is to me a lame response to an issue with a potential for a real safety issue and should have more response than "WE ARE WORKING ON THE ANSWER AND MAYBE END OF JULY" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My 2024 Ford Ranger XLT 2W has been suddenly losing power or stumbling upon initial acceleration. This has been occurring intermittently. My truck now has approximately 20,000 miles. The problem has become increasingly frequent. It seems to occur most often when accelerating from a complete stop. The loss of power can last for several seconds, then normal power is regained. Several times, the truck has lost power while making a left turn. It simply will not accelerate, and I find that I am stuck, unable to complete my turn and clear the oncoming traffic. I have taken my truck to a local dealer who attempted to diagnose the problem and they didn’t offer a solution since they were unable to reproduce the problem during their road test. It has happened many times since then and I am scheduled to return the vehicle to the same dealership to attempt to diagnose and fix the problem again soon. The problem seems to occur, regardless of which drive mode the truck is in and also occurs with Electronic Stability Control both enabled and disabled. There are no warning lights or check engine codes shown.
I am the original owner of this vehicle and the engine and controls have not been modified in any way. Yesterday while driving at approximately 30 mph on a surface street with dry road conditions in the “2H” setting on the Drive Modes Selection Dial my truck spontaneously shifted into four-wheel drive high and then attempted to switch into four-wheel-drive low – “Rock Crawl Mode.” The rear differential locked, speed was suddenly reduced, and the steering became more difficult. Luckily, I was able to safely pull over. I captured a video at this time documenting the control settings and display image. It took multiple attempts, even in Park and Neutral, to get out of 4WD and back into the 2H setting. Once back in 2H, the truck drove normally. I have had similar experiences at least twice before in this truck with months between them. In those cases, I wondered if I had accidentally bumped the dial control. I am certain that this was not the case yesterday, so this was a spontaneous event initiated by the truck’s computer and/or mechanical controls. I consider this to be a very serious safety hazard, as it dramatically and unexpectedly affected the speed and handling of my truck. I did some online searching today and found that multiple other Ranger Raptor owners have experienced this issue, suggesting that this may be a serious design flaw affecting multiple vehicles. I plan to schedule a service appointment with Ford and notify them directly of this problem and hazard.
Loss of power/accelleration. Multiple times. Issue has always occurred when turning left quickly then trying to accellerate. to make the immediate uphill. The accellerator goes dead for 3-4 seconds, then works. Engine RPM does not speed up when commanded, but then does after several seconds. By then it has been pushed to the floor attempting to make it over the upcoming hill. This is going to cause an accident, especially when pavement is slick, then truck quickly responds to the pedal position. The truck displays no codes or lights. Dealer says they have no idea what it could be. There are multiple reports on [XXX] . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The battery has been dying since the last update which causes my rear camera to just go black screen when I am reversing my battery shouldn't be dying after a year and my camera should still work
while driving between 5-10 MPH on a dry, smooth paved road, the transmission began cycling through 4WD modes and began shifting from normal mode to 4WD Sand mode, i was able to pull over and park, but the transmission continued shifting and fully transitioned to 4WD mode. This is the second time it has occurred, the first time the transmission fully switched 4WD and i was barely able to pull off the road to reset it. after first issue, dealership noted the following "3131 confirmed concern. pulled codes with FDRS and found P05D3 in ABS module. Referred to workshop manual and run pinpoint test AH for concern. AH1 yes. AH2 had me reconfigure ABS module with As-Built data rerun self test. No codes returned and system operating correctly at this time." There multiple online forums with owners having the same problem. https://www.ranger6g.com/forum/threads/24-rr-shifted-while-driving.18956/ Truck will be going to dealership for assessment again.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .