2013 Ford Redundant C-Max Hybrid Problems

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that on several occasions, while the vehicle was parked, it failed to start. The vehicle was jump-started on several occasions but needed to be towed occasionally. The vehicle was taken to an independent mechanic, where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The battery was replaced; however, the failure reoccurred. The vehicle was then taken to the dealer, but was not diagnosed. The dealer suggested that a waiver be signed for the battery replacement. The vehicle was repaired. The contact stated that the vehicle had experienced electrical failures. The instrument panel intermittently malfunctioned, and the turn signals failed to operate properly. The manufacturer was made aware of the failure. The approximate failure mileage was 36,463.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving approximately 15-20 MPH, the steering wheel was wobbly. The contact exited the highway immediately and was able to pull over to the side of the roadway. The contact then pulled into a parking lot and the vehicle was towed to the dealer, where it was diagnosed that the rear subframe was rusted, causing the control arms to separate. The dealer determined that the rear subframe and connecting parts needed to be replaced. Additionally, the dealer informed the contact that a high voltage wire was chewed on by rodents. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving on three occasions at approximately 30-55 MPH, several unknown warning lights were flashing. The message to shift to park(P) was flashing. The vehicle was shifted to park, and the vehicle stalled and failed to restart. The contact's husband assisted with restarting the vehicle. The contact determined that the battery was working as designed. The vehicle was taken to the local dealer for five weeks, where it was diagnosed that the battery junction box had corrosion and defective fuses. Additionally, there was a failing control unit. The dealer informed the contact a Ford engineer was advising with the repairs. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,000.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while driving at various speeds, the vehicle would shut-off without warning. Due to the failure, the contact had the vehicle towed to the dealer on three separate occasions for service. Each time the vehicle was towed to the dealer, the vehicle would resume normal operation upon arrival and the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 120,000.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. WHILE DRIVING VARIOUS SPEEDS, THE STEERING LOST POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION ASSEMBLY MODULE NEEDED TO BE REPLACED. THE CONTACT CALLED NORTH CENTRAL FORD AT 972-584-1338 (LOCATED AT 1819 N CENTRAL EXPY, RICHARDSON, TX 75080) WHERE IT WAS STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.

LIGHT CAME ON SAYING SERVICE POWER STEERING. ALMOST IMPOSSIBLE TO STEER IT. WAS TOLD BY THE FORD DEALER IT IS A $2,000.00 FIX. RESEARCH SHOWED ME THAT OTHER MODELS HAVE HAD THE SAME PROBLEM AND WERE LISTED AS A RECALL BUT THERE ISN'T ENOUGH DOCUMENTATION YET ON THE C-MAX'S TO WARRANT INCLUDING THEM. AT 55,000 MILES THAT SEEMS VERY EARLY TO HAVE THIS KIND OF PROBLEM. WE LOVE OUR C-MAX BUT THIS IS A DEFINITE CONCERN WHEN YOUR ON SOCIAL SECURITY 2,000 IS A BIG EXPENSE FOR A FOX AT 50 SOMR THOUSAND MILES. RESPECTFULLY SUBMITTED. [ ANY HELP WOULD BE APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

The contact's wife owns a 2013 Ford C-Max Hybrid. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. The contact stated there was an abnormal hissing and crackling sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer where it was diagnosed with a defective transmission. The vehicle was not repaired. The manufacturer was notified of the failure and was informed that there were no recalls or warranties on the vehicle. The vehicle remained in the possession of the dealer. The failure mileage was approximately 180,000.

The contact owns a 2013 Ford C-MAX Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was able to restart after several attempts. Additionally, the vehicle remained on after the contact had pushed the Auto Start/Stop button to turn off the vehicle. The contact was able to turn off the vehicle after pushing the Auto Start/Stop button numerous times. The dealer and Five Star Ford Stone Mountain (3800 US-78, Snellville, GA 30039) were made aware of the failure but confirmed that parts were not yet available. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated while driving approximately 15-20 MPH, the steering wheel was wobbly. The contact exited the highway immediately and was able to pull over to the side of the roadway. The contact then pulled into a parking lot and the vehicle was towed to the dealer, where it was diagnosed that the rear subframe was rusted, causing the control arms to separate. The dealer determined that the rear subframe and connecting parts needed to be replaced. Additionally, the dealer informed the contact that a high voltage wire was chewed on by rodents. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that upon exiting the vehicle, the driver’s side doors failed to latch closed. The contact also stated that while driving at an undisclosed speed and attempting to get another driver’s attention, he became aware that the horn was not functioning as needed. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: RQ19005 (Latches/Locks/Linkages, Structure); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 80,000. The VIN was not available.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that upon exiting the vehicle, the driver’s side doors failed to latch closed. The contact also stated that while driving at an undisclosed speed and attempting to get another driver’s attention, he became aware that the horn was not functioning as needed. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: RQ19005 (Latches/Locks/Linkages, Structure); but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 80,000. The VIN was not available.

The contact owns a 2013 Ford C-Max Hybrid. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) and 20V331000 (Latches, Locks, and Linkages) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had experienced a transmission failure and the vehicle was towed to the dealer. Parts distribution disconnect.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while in reverse, the rearview camera failed to display a rearview image, potentially compromising the back over prevention system. The vehicle returned to normal functionality, but the failure became a regular occurrence. The rearview camera warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V695000 (Back Over Prevention), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 230,000.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. WHILE THE VEHICLE WAS STATIONARY, THE BATTERY SAVER WARNING INDICATOR TURNED OFF AND THE FOLLOWING MESSAGE DISPLAYED ACROSS THE INSTRUMENT PANEL: "911 ASSIST IS DISABLED, CONTACT DEALER". IMMEDIATELY AFTERWARDS, THE SHIFTER INDICATOR DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT TURNED THE KEY IN THE IGNITION, BUT THE MOTOR DID NOT INDICATE THAT IT WAS READY TO DRIVE UNTIL APPROXIMATELY ONE MINUTE LATER. THE CONTACT PLACED THE SHIFTER INTO REVERSE AND ATTEMPTED TO REVERSE, BUT A SUDDEN LOSS OF POWER STEERING OCCURRED. THE CONTACT PLACED THE VEHICLE IN THE DRIVE GEAR AND DEPRESSED THE ACCELERATOR PEDAL IN AN ATTEMPT TO STOP THE VEHICLE; HOWEVER, THE VEHICLE ACCELERATED BEYOND 35 MPH. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BY DEPRESSING THE BRAKE PEDAL, BUT THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO BOB MOORE FORD (8948 S I-35 SERVICE RD, OKLAHOMA CITY, OKLAHOMA 73159) WHERE IT WAS DIAGNOSED THAT THE INNER CELL OF THE BATTERY WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. WHILE THE VEHICLE WAS STATIONARY, THE BATTERY SAVER WARNING INDICATOR TURNED OFF AND THE FOLLOWING MESSAGE DISPLAYED ACROSS THE INSTRUMENT PANEL: "911 ASSIST IS DISABLED, CONTACT DEALER". IMMEDIATELY AFTERWARDS, THE SHIFTER INDICATOR DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT TURNED THE KEY IN THE IGNITION, BUT THE MOTOR DID NOT INDICATE THAT IT WAS READY TO DRIVE UNTIL APPROXIMATELY ONE MINUTE LATER. THE CONTACT PLACED THE SHIFTER INTO REVERSE AND ATTEMPTED TO REVERSE, BUT A SUDDEN LOSS OF POWER STEERING OCCURRED. THE CONTACT PLACED THE VEHICLE IN THE DRIVE GEAR AND DEPRESSED THE ACCELERATOR PEDAL IN AN ATTEMPT TO STOP THE VEHICLE; HOWEVER, THE VEHICLE ACCELERATED BEYOND 35 MPH. THE CONTACT ATTEMPTED TO STOP THE VEHICLE BY DEPRESSING THE BRAKE PEDAL, BUT THE VEHICLE WOULD NOT STOP. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO BOB MOORE FORD (8948 S I-35 SERVICE RD, OKLAHOMA CITY, OKLAHOMA 73159) WHERE IT WAS DIAGNOSED THAT THE INNER CELL OF THE BATTERY WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000.

I WAS IN AN ACCIDENT, DRIVING APPROXIMATELY 25 MPH WHEN I HIT THE BRAKES WITH APPROXIMATELY 20 FEET OF DISTANCE, THE ANTI LOCK BRAKES FAILED TO ENGAGE CAUSING THE CAR TO SLIDE, AND REAR END THE CAR IN FRONT OF ME, UPON IMPACT THE AIRBAGS DID NOT DEPLOY.

THE CONNECTORS LEAKED INTERNALLY THROUGH THE INJECTOR AND ROTTED ALL THE PARTS. ENGINE LIGHT CAME ON AND THE CAR STARTED TO SHAKE VIOLENTLY.

AT FIRST THE CMAC WOULD NOT START FOLLOWED BY ALL THE ELECTRICITY IN THE GOES DEAD (HORNY LIGHTS RADIO NOW HAVE EVERYTHING). I WAS THEN DRIVING AT ABOUT 45 MPH THE CAR SLOWED DOWN BY ITSELF WHILE I WAS PRESSING THE GAS TO ABOUT 5 MPH AND I COULD NOT GO ABOVE THAT. THE SLOWDOWN WAS IMMEDIATE LIKE THE CAR DOWNSHIFTED IN THE LOWER GEAR. THE DEALER SAYS THEY DO NOT KNOW WHAT CAUSED IT BUT THEY SAW THE 12VOLT BATTERY ADD A BAD CELL AND SO THEY BELIEVING THAT THAT'S WHAT COULD'VE CAUSED ALL THE PROBLEMS.I CONTACTED FORD AND THEY SAID TO LET THE DEALER HANDLE IT. MY MAIN CONCERN IS THE CAR COMING TO ALMOST A FULL STOP IN THE MITTS OF HIGH-SPEED ESPECIALLY WITH NO PRIOR WARNING OR INDICATIONS.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. WHILE DRIVING 75 MPH, THE CONTACT CRASHED INTO THE REAR OF A TOYOTA TUNDRA. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A BODY SHOP WHERE IT WAS DEEMED A TOTAL LOSS BY THE INSURANCE COMPANY. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS 146,000.

I WAS IN AN ACCIDENT, DRIVING APPROXIMATELY 25 MPH WHEN I HIT THE BRAKES WITH APPROXIMATELY 20 FEET OF DISTANCE, THE ANTI LOCK BRAKES FAILED TO ENGAGE CAUSING THE CAR TO SLIDE, AND REAR END THE CAR IN FRONT OF ME, UPON IMPACT THE AIRBAGS DID NOT DEPLOY.

CAR ELECTRONICS WILL NOT SHUT OFF. RADIO REMAINS ON CONTINUOUSLY, EVEN WITH KEYS REMOVED AND DOORS LOCKED. NO CHIMES TO INDICATE IF CAR IS ON/OFF. AT OTHER TIMES, CAR NAVIGATION AND ELECTRONIC SYSTEMS WILL FAIL. FAILURES AND NON-RESPONSE CAN HAPPEN WHILE IN MOTION. RADIO NOT TURNING OFF AFTER ENGINE OFF AND PARKED.

AFTER DRIVING FOR ABOUT 30 MILES AT NIGHT, I GET A BURNING SMELL IN THE INTERIOR OF THE CAR. I HAVE HAD PEOPLE STOP ME TO TELL ME THAT MY REAR TAIL LIGHTS ARE OUT. THIS HAS HAPPENED ONLY TWICE BUT I RARELY DRIVE AT NIGHT. I WAS ON THE FREEWAY THE LAST TIME AND SOME PEOPLE FOLLOWED ME TO TELL ME THAT THEY COULD BARELY SEE ME. I HAVE A BLACK CAR AND LICENSE PLATE. THE CAR IS OUR OF WARRANTY AND I DON'T KNOW IF MY EXTENDED WARRANT WILL COVE IT. I AM TERRIFIED TO DRIVE IT AT NIGHT NOW. *TR

THE DRIVER'S SEAT BELT WILL NOT RETRACT PROPERLY. RESULTS IN EXTREME SLACK WHILE OPERATING THE VEHICLE. THE FAILURE MILEAGE WAS 78,600.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO FORD OF MONTEBELLO (2747 VIA CAMPO, MONTEBELLO, CA 9064 (323) 838-6920) TO BE SERVICED PER NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). SEVERAL DAYS LATER, THE CONTACT NOTICED THAT THE SEAT BELT INDICATOR FAILED TO ILLUMINATE WHILE DRIVING VARIOUS SPEEDS. THE FRONT DRIVER SIDE AND/OR FRONT PASSENGER SIDE SEAT BELTS WERE UNLATCHED. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OF THE SEAT BELT WARNING FAILURE. THE MANUFACTURER WAS ALSO NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 56,114.

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The message "Stop Safely Now'" was displayed on the screen. The contact was able to pull to the side of the road. However, no cause for the failure was found. The vehicle was not repaired. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle was taken to the dealer; however, no cause for the failure was found. The failure persisted. The vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The message "Stop Safely Now'" was displayed on the screen. The contact was able to coast to the side of the road. After waiting for several minutes, the contact was able to restart the vehicle. The vehicle functioned as intended. The vehicle was towed to the dealer; however, no cause for the failure was found. The contact stated that the failure first occurred three years ago, and the dealer diagnosed that it as a battery failure. The contact was unsure if the battery was replaced. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 107,000.

TL* THE CONTACT OWNS A 2013 FORD C-MAX HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE REAR PASSENGER'S SIDE TIRE EXPLODED. THE CONTACT NOTICED THAT THE VEHICLE WAS NOT EQUIPPED WITH A SPARE TIRE, WHICH WAS DESIGNED BY THE MANUFACTURER. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 9,000.

THUMPING NOISE COMING FROM FRONT END AT LOW SPEEDS. SOUNDS LIKE FRONT SUSPENSION IS FALLING APART.

WHILE DRIVING ON THE INTERSTATE WE NOTICED A NOISE COMING FROM THE LEFT FRONT TIRE AREA. WHENEVER WE STOPPED, I LOOKED AT THE TIRE AND NOTICED A LARGE BUBBLE ON THE SIDEWALL OF THE TIRE. WE PURCHASED ANOTHER TIRE AND DROVE THE CAR TO A REPAIR SHOP WHERE WE HAD THE TIRE WITH THE SIDEWALL BUBBLE REMOVED AND THE NEW TIRE INSTALLED. WE LOOKED AT THE TIRE TO SEE WHAT HAD CAUSED THE BUBBLE AND NOTICED THAT THERE WAS A LARGE SQUARE TIRE PATCH INSTALLED ON THE INSIDE OF THE TIRE NEAR THE SIDEWALL. THIS VEHICLE WAS PURCHASED AS A NEW VEHICLE AND HAD MICHELIN TIRES ON IT. THIS WAS A PROFESSIONAL PATCH ON THIS TIRE THAT HAD TO HAVE BEEN DONE AT THE TIRE MANUFACTURER OR AT WAYNE ASSEMBLY PLT. WHERE THE VEHICLE WAS BUILT. THIS IS NOT A DEALER OR HOME REPAIR. I AM DISAPPOINTED TO LEARN THAT A TIRE LIKE THIS COULD BE INSTALLED ON A NEW VEHICLE. THIS COULD HAVE CAUSED A BLOW OUT AND SERIOUS INJURY TO SOMEONE. *TR

THE DEALER LOCATED IN MENA REGION JORDAN, NOT WORKING OR COOPERATE AS WELL. MOST RECALLS HE SAID NO NEED TO DO IT AND CLAIM THAT NO PARTS AVAILABLE AND ITS NEED MORE THAN 45 DAYS TO BE AVAILABLE AND AFTER 45 DAYS HE SAID STILL NOTHING COME BACK AFTER A MONTH ETC... AND WE ARE ALL CUSTOMERS FACING PROBLEM IN CONTACTING THEN AND THE WAYS THEY ARE TREAT US IN IT IS NOT PROFESSIONAL. NOT FEEL (NOT ONLY ME) THAT THE HAVE PROFESSIONAL TEAM, I WANT TO DO ALL RECALLS BUT AFFAIR IF THEY DID MOST PROBABLY THEY WILL MAKE NEW ISSUE AND START PAID FOR SOMETHING WRONG THEY MADE :(

2013 FORD C-MAX. CONSUMER WRITES IN REGARDS TO DEFECTIVE REAR WINDOW. CONSUMER REQUESTS REFUND FOR REPAIRS. *SMD THE CONSUMER STATED 15 DAYS AFTER PURCHASING THE VEHICLE, THE REAR WINDOW SHATTERED. THE CONSUMER STATED SHE PURCHASED AN EXTRA WINDOW COVERAGE WARRANTY. HOWEVER, THE DEALER STATED THE COVERAGE WAS ONLY FOR THE FRONT WINDSHIELD.

WHILE DRIVING ON THE INTERSTATE WE NOTICED A NOISE COMING FROM THE LEFT FRONT TIRE AREA. WHENEVER WE STOPPED, I LOOKED AT THE TIRE AND NOTICED A LARGE BUBBLE ON THE SIDEWALL OF THE TIRE. WE PURCHASED ANOTHER TIRE AND DROVE THE CAR TO A REPAIR SHOP WHERE WE HAD THE TIRE WITH THE SIDEWALL BUBBLE REMOVED AND THE NEW TIRE INSTALLED. WE LOOKED AT THE TIRE TO SEE WHAT HAD CAUSED THE BUBBLE AND NOTICED THAT THERE WAS A LARGE SQUARE TIRE PATCH INSTALLED ON THE INSIDE OF THE TIRE NEAR THE SIDEWALL. THIS VEHICLE WAS PURCHASED AS A NEW VEHICLE AND HAD MICHELIN TIRES ON IT. THIS WAS A PROFESSIONAL PATCH ON THIS TIRE THAT HAD TO HAVE BEEN DONE AT THE TIRE MANUFACTURER OR AT WAYNE ASSEMBLY PLT. WHERE THE VEHICLE WAS BUILT. THIS IS NOT A DEALER OR HOME REPAIR. I AM DISAPPOINTED TO LEARN THAT A TIRE LIKE THIS COULD BE INSTALLED ON A NEW VEHICLE. THIS COULD HAVE CAUSED A BLOW OUT AND SERIOUS INJURY TO SOMEONE. *TR

The contact owns a 2013 Ford C-Max Hybrid. The contact stated that while driving at various speeds, the vehicle would shut-off without warning. Due to the failure, the contact had the vehicle towed to the dealer on three separate occasions for service. Each time the vehicle was towed to the dealer, the vehicle would resume normal operation upon arrival and the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 120,000.