1997 Ford Taurus Brakes Problems

WHEN DRIVING THE CAR AT A LOW RATE OF SPEED A FEW MILES FROM MY NEIGHBORHOOD, I NOTICED THAT THE BRAKE LIGHT INDICATOR CAME ON. I SLOWED DOWN TO LOOK AROUND THE CAR BUT COULD NOT FIND ANYTHING. I DROVE THE CAR HOME AND JUST AS I WAS DRIVING INTO MY NEIGHBORHOOD, THE BRAKES STOPPED WORKING. VERY LUCKILY, I DID NOT GET INTO AN ACCIDENT. IT TURNS OUT THAT THE METAL REAR BRAKE LINES RUNNING UNDERNEATH THE DRIVER'S SIDE FRONT DOOR WERE COMPLETELY CORRODED AND ONE OF THE LINES HAD BURST (THE ONE AFFECTING THE DIAGONAL BRAKE CIRCUIT FOR THE FRONT DRIVER SIDE AND REAR PASSENGER SIDE). THIS CAME WITHOUT WARNING, AND I COULD HAVE EASILY BEEN STRANDED (OR KILLED) ON A BUSY HIGHWAY OUT OF CONTROL. THIS IS A SAFETY ISSUE JUSTIFYING A RECALL. AMAZINGLY, THE OTHER UNDERSIDE COMPONENTS OF THE VEHICLE ARE IN MUCH BETTER SHAPE THAN THE BRAKE LINES. WHY FORD WOULD FAIL TO PROPERLY COAT OR PROTECT A CRITICAL COMPONENT LIKE THE REAR BRAKE LINES SO THAT THEY WOULD NOT CORRODE IS AN INEXCUSABLE SAFETY HAZARD. I HAVE READ OF THIS REAR BRAKE LINE ISSUE ELSEWHERE BEING EXTREMELY COMMON FOR THIS VEHICLE, SO THIS IS NOT A "ONE OFF" EVENT. SOONER OR LATER, SOMEONE WILL GET INTO A SERIOUS ACCIDENT OR BE KILLED!

NHTSA ID

10777947

Incident

Sep 27, 2015

Mileage

105,000 mi

I HEARD RATTLING IN THE FRONT OF THE VEHICLE TOWARDS THE WHEELS OF THE CAR. I ASSUMED THAT IT WAS MY BRAKES NEEDING REPLACED. I TOOK IT IN FOR REGULAR MAINTENANCE TO HAVE THE BRAKES REPLACED AT WHICH TIME THEY DID A DIAGNOSTIC ON THE BRAKES, THEY WERE STILL GOOD AND FOUND THAT MY AUTOMATIC BRAKING SYSTEM HAD FAILED (HYDRAULICS THAT ACTUALLY PUSH THE BRAKE PADS DOWN), THANKFULLY I WAS NOT ON THE HIGHWAY GOING 55MPH LIKE I USUALLY DO WHEN THIS HAPPENED. FORD NEEDS TO RECALL THE ENTIRE BRAKING SYSTEM OF THE FORD TAURUS GL STATION WAGON ACCORDING TO ALL THE COMPLAINTS THAT I HAVE SEEN ALSO KEEPING IN MIND MOST OF THE COMPLAINTS WERE OVER 100,000 MILES. SOMEONE WILL BE KILLED DUE TO THIS FAILURE. GOD FORBID THERE MIGHT BE CHILDREN IN THE VEHICLE WHEN IT HAPPENS. FORD STEP UP TO THE PLATE AND FIX THIS PROBLEM NOW!! IT IS GOING TO COST ME $2100.00 TO HAVE THE PUMP AND HYDRAULIC SYSTEM REPLACED AND THIS IS NOT AN EXAGGERATION. I DEPEND ON THIS VEHICLE AND CAN NOT AFFORD TO BE WITH OUT IT. :( AS FAR AS I AM CONCERNED ONE COMPLAINT SHOULD WARRANT A RECALL. LIVES ARE AT STAKE. *KB

NHTSA ID

10419997

Incident

Aug 17, 2011

Mileage

54,500 mi

BRAKE LINE BURST. CONTROL BECAME NONEXISTENT. GOT VERY LUCKY BRINGING IT HOME, ALTHOUGH I DID RUN INTO THE BACK OF MY GARAGE (BECAUSE THE BRAKES DIDN'T WORK). *TR

NHTSA ID

10363415

Incident

Oct 28, 2010

Mileage

77,387 mi

TL* THE CONTACT OWNS A 1997 FORD TAURUS . DURING BRAKE APPLICATION AT 25 MPH THE PEDAL WENT TO THE FLOOR. HE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. A MECHANIC FROM A LOCAL REPAIR FACILITY STATED THAT THE BRAKE LINE WAS LEAKING. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 90000.

NHTSA ID

10296063

Incident

Dec 15, 2009

Mileage

90,000 mi

1997 FORD TAURUS (1996-2005+) BRAKE LINE FAILURE. THE BRAKE LINES TO THE REAR OF THE CAR HAVE A CORROSION PROBLEM UNDER THE DRIVERS SEAT, UNDER THE CAR. THE LINES CORRODE SEVERELY AND THEN BURST UNDER PRESSURE. ALL BRAKING IS LOST AFTER THE FLUID LEAKS OUT. STEEL LINES WERE NOT PROTECTED FROM MOISTURE AND HAVE PLASTIC SHIELD THAT TRAPS WATER. *TR

NHTSA ID

10293958

Incident

Nov 28, 2009

Mileage

112,000 mi

COMPLETE AND SUDDEN BRAKE FAILURE. PLACED FOOT ON BRAKE PEDAL TO REVERSE CAR OUT OF PARKING SPOT. (WOULD HAVE CAUSED SEVERE INJURY/DAMAGE HAD I BEEN AT HIGHWAY SPEED OR CITY MANEUVERING). PEDAL WENT TO FLOOR AND BRAKE FLUID PUDDLED UNDER THE CAR. HAD CAR TOWED TO REPAIR FACILITY AND BRAKE LINES WERE REPAIRED. MECHANIC SAID FORD'S PLASTIC BRACKET ALLOWED WATER/DIRT/SALT TO ACCUMULATE AND RUST THROUGH LINES. *TR

NHTSA ID

10266461

Incident

Apr 7, 2009

Mileage

120,000 mi

WHILE DRIVING FOR A FUEL FILL-UP ON A HEAVILY-TRAVELED ALLEGHENY CO (PA) FOUR-LANE ROAD (SPEED APPROX. 30-35 MPH), TRAFFIC HEAVY, I EXPERIENCED, WITHOUT PRIOR WARNING, A SUDDEN TOTAL LOSS OF ALL BRAKING EFFECTIVENESS. I FOLLOWED A FORD F-250 PICKUP INTO THE GAS STATION LOT AND BROUGHT MY CAR (1997 FORD TAURUS SDN, 90,000 MILES ON ODOMETER) TO A STOP BY SMASHING INTO THE BACK OF THE TRUCK. NO ONE WAS INJURED. THERE WAS EXTENSIVE DAMAGE TO THE FRONT END OF MY CAR; INCONSEQUENTIAL DAMAGE TO THE HEAVY-DUTY STEEL REAR BUMPER OF THE TRUCK. A SIZABLE PUDDLE OF BRAKE FLUID WAS OBSERVED FORMING UNDER DRIVER'S SIDE FR DOOR OF MY CAR, CAUSED BY SUDDEN CATASTROPHIC RUPTURE OF ONE OR MORE HYDRAULIC BRAKE LINES ON MY CAR, RESULTING IN TOTAL LOSS OF ALL BRAKING POWER. MY CAR IS NOW UNDER REPAIR TO REPLACE ALL RUSTED-OUT OR CORROSION-COMPROMISED BRAKE SYSTEM COMPONENTS. WHAT IF, INSTEAD OF 5:15 PM ON A SATURDAY, THIS CATASTROPHIC LOSS OF BRAKES HAD OCCURRED AT 3:15 PM ON A SCHOOL DAY, WITH A SCHOOL BUS IN FRONT OF ME DISGORGING HALF A BUS LOAD OF SCHOOL KIDS CROSSING THE STREET IN FRONT OF ME? BELIEVE ME, THE FLASHING RED LIGHTS OF THE SCHOOL BUS WOULD NOT HAVE CAUSED MY CAR TO STOP. IN OVER 50 YRS OF DRIVING, THIS IS THE FIRST TIME I EVER EXPERIENCED A BRAKE LINE FAILURE, AND I ROUTINELY DRIVE A CAR FOR 10+ YRS. HAVE THE AUTO MFGRS BEEN PERMITTED TO SQUEEZE A FEW MORE PENNIES OF PROFIT BY ADOPTING A CHEAPER, LESS CORROSION-RESISTANT GRADE OF STEEL FOR THE VEHICLE BRAKE LINES? IS NOT THE BRAKING SYSTEM OF MY '97 SUPPOSED TO HAVE A REDUNDANCY FEATURE TO RETAIN SOME BRAKING EFFECTIVENESS IN THE EVENT OF LOSS OF ONE OF THE LINES? THE MANAGER OF THE REPAIR SHOP WHERE I TOOK THE CAR TELLS ME THAT BRAKE LINE REPLACEMENT HAS BECOME AN INCREASINGLY COMMON REPAIR IN THIS PART OF THE SNOW-AND-SALT WINTER DRIVING BELT. *TR

NHTSA ID

10258340

Incident

Feb 7, 2009

Mileage

89,700 mi

TL*THE CONTACT OWNS A 1997 FORD TAURUS. THE CONTACT NOTICED A STRONG GASOLINE SMELL AND NOTICED GASOLINE ON THE GROUND UNDER THE VEHICLE. THE MECHANIC STATED THAT THREE FAILURES WERE PRESENT: THE FUEL TANK, A COOLANT LEAK, AND BRAKE LINE CORROSION. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURES. THE VEHICLE WAS REPAIRED. THE CONTACT WOULD LIKE FORD TO REIMBURSE HIM FOR THE COST OF THE REPAIRS, BUT THEY REFUSED. THE FAILURE MILEAGE WAS 123,100 AND CURRENT MILEAGE WAS 123,900. UPDATED 04/02/08. *LJ

NHTSA ID

10221405

Incident

Mar 7, 2008

Mileage

123,100 mi

BRAKE LINE FAILURE. *TR

NHTSA ID

10221269

Incident

Mar 10, 2008

Mileage

43,900 mi

DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT 65 MPH THE BRAKES WENT TO THE FLOOR. WHEN HITTING A BUMP THE BRAKES BOUNCE AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC REPLACED THE FRONT AND REAR BRAKES AND THE ENGINE LIGHT SENSOR. THE MANUFACTURER WAS ALERTED.

NHTSA ID

10152235

Incident

Feb 24, 2006

Mileage

14,000 mi

I AM THE OWNER OF A 1997 TAURUS. APPROXIMATELY ONE WEEK AGO, THE BRAKES FAILED COMPLETELY WHILE I WAS EXITING OFF A HIGHWAY; THE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR. SINCE I WAS RELATIVELY CLOSE TO HOME, I DROVE CAUTIOUSLY BACK TO MY HOUSE, AFTER WHICH I CALLED A TOW TRUCK THE TAKE THE CAR TO MY MECHANIC. A COUPLE OF HOURS LATER I RECEIVED A CALL FROM THE SHOP INFORMING ME THAT THE ENTIRE BRAKE LINE SYSTEM WAS RUSTED & ROTTED AWAY AND THAT THE FLUID HAD COMPLETELY LEAKED OUT. THE MECHANIC SAID IN HIS 20 YEARS HE HAD NEVER SEEN A BRAKE LINE SYSTEM RUST SO COMPLETELY IN SUCH A YOUNG CAR. IN FACT, HE SAID, IT SHOULD BASICALLY LAST THE LIFE OF THE CAR, NEVER NEEDING TO BE REPLACED. AFTER ALL WAS SAID AND DONE, THE JOB COST ALMOST $800. I ASKED TO SEE THE OLD LINES AND COULDN?T BELIEVE HOW RUSTED AND ROTTED THEY HAD BECOME. THERE WAS NO PROTECTIVE SHEATHING ON THE LINES. I FEEL THAT I SHOULD BE REIMBURSED FOR THESE REPAIRS SINCE IT SHOULD HAVE NEVER HAVE HAPPENED IN THE FIRST PLACE. THE MECHANIC DID MENTION THAT HE HAD RECENTLY BEEN SEEING A LOT OF YOUNG FORD MODELS COMING IN WITH THE SAME PROBLEM OR RUSTING AND FAILING BRAKE LINE SYSTEMS. ALSO, WHILE SEARCHING THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE FOR SIMILAR DEFECTS, I FOUND COMPLAINTS LODGED ABOUT THE ROTTING OF THE HARD TUBING, CAUSING THE BRAKE LINES TO BURST. IN THESE CASES, THE CARS WERE 1997 TAURUS?. MY MECHANIC FIXED THE ENTIRE LINE SYSTEM, COMPLETELY REPLACING ANY OLD PARTS WITH NEW, CUSTOM MADE TUBES. I KEPT THE OLD TUBING JUST SO I CAN SHOW FORD WHAT THEIR CARS ARE RELYING ON FOR STOPPING. THE ENTIRE JOB CAME TO ALMOST $800.*AK

NHTSA ID

10117988

Incident

Mar 29, 2005

I HAVE EXPERIENCE THE SAME LOST OF POWER STEERING AND BRAKES,I HAVE ALSO NOTICE THAT WHEN I TURN MY WHEEL IT MAKES A SQUEAKING SOUND.HAD THE CAR CHECKED WAS TOLD IT NEEDED TO BE LUBED.HAD IT LUBED CAR IS STILL DOING THE SAME THING.A COWORKER HAS A 1997 FORD TAURUS LIKE MY CAR AND THEY ARE EXPERENCING THE SAME NOISES. PLEASE ADVISE IF THIS PROBLEM IS COMMON. *AK

NHTSA ID

10110303

Incident

Feb 10, 2005

VEHICLE MOVING DOWN A HILL. POWER BRAKES AND STEERING LOST POWER,ENGINE STILL RUNNING, BUT NO POWER TO BRAKES OR STEERING. FINALLY STOPPED VEHICLE WITH NO INCIDENT. TURNED OFF VEHICLE AND RESTARTED, POWER TO BRAKES AND STEERING RESTORED.*AK TOOK TO SERVICE.REPLACEMENT WAS MADE TO CAMSHAFT SENSOR. PROBLEM SEEMED TO HAVE BEEN CORRECTED, BUT RETURNED ABOUT 6 MOS. LATER...SAME CIRCUMSTANCES,ONLY IN FIRST INCIDENT, CHECK ENGINE LIGHT HAD BEEN APPEARING INTERMITTENTLY.

NHTSA ID

10102885

Incident

Dec 10, 2004

Mileage

90,000 mi

WHILE DRIVING AND UPON PRESSING THE BRAKES VEHICLE ACCELERATED. THE ONLY WAY CONSUMER COULD STOP THE VEHICLE WAS TO PUT THE VEHICLE IN NEUTRAL. HOWEVER, THE LAST TIME SHE DID THAT THE VEHICLE ACCELERATED AT FULL SPEED. THERE WERE NO ACCIDENTS OR INJURIES. TOOK VEHICLE TO THE MECHANIC. HOWEVER, THE PROBLEM RECURRED. *AK

NHTSA ID

10095187

Incident

Jul 1, 2004

WHILE DRIVING TRAFFIC LIGHT WAS CHANGING, WENT TO PUMP THE BRAKES, THE BRAKES FAILED. THE ONLY WAY TO STOP THE VEHICLE WAS TO PULL THE EMERGENCY BRAKE LEVER. BRAKE LINE COMPLETELY RUSTED FROM THE FRONT TO THE BACK. *AK

NHTSA ID

10095073

Incident

Oct 3, 2004

BRAKE LINE BURST ON 2 DIFFERENT FORD CARS IN SAME WEEK! AND IN BOTH CASES IT WAS ROT, AND IN BOTH CASES IT WAS THE HARD TUBING, NOT THE HOSES. ONE A 1997, SO IT WAS ONLY 7 YEARS OLD. BRAKE LINE ROTTED ENOUGH TO BURST DURING FIRM STOP. THE NEW ABS STYLE BRAKE LINES ARE DANGEROUSLY THINNER THAN THE OLDER STYLE BRAKE LINES. THEY ALSO SEEM TO HAVE ELECTROSTATIC PROPERTIES THAT CAUSE PREMATURE ROTTING IN SOME CASES. THE PIECE THAT BROKE WAS MUCH MORE ROTTED THAN THE OTHER PIECES ATTACHED THE HOLDING CLIPS ACTUALLY CAUSES MORE ROTTING BECAUSE WATER COLLECTS IN THE OPEN SPACE WHERE IT HOLD THE THINNER BRAKE LINE. IT IS EXTREMELY DANGEROUS THAT THESE BRAKE LINES ARE BEING MADE MUCH THINNER. ALSO ON THE 1997 FORD TAURUS THE BRAKE LINES HANG DOWN LOWER THAN OTHER SUSPENSION IN THE MIDDLE AND PRESENT A HAZARD DURING WINTER WHEN CARS MAY BE DRIVEN ACROSS FROZEN SNOW. FORD ENGINEERS NEED TO GO BACK TO SCHOOL. BRAKE LINE TUBING WALLS MUST BE MADE THICKER. I HAVE HAD MANY CARS AND DRIVEN THEM OVER 100K MILES EACH AND NEVER HAD A BRAKE LINE BURST FOR ROT BEFORE. THIS CAR BROKE AT AROUND 80K I THINK. DATE IS APPROXIMATE...I'M NOT GOING TO LOOK UP THE REPAIR BILL RIGHT NOW. FORD COULD EASILY BE NUMBER ONE IF THEY STOP DOING STUPID THINGS LIKE THIS.*AK

NHTSA ID

10093488

Incident

Jul 1, 2004

WHILE DRIVING IT WAS HARD TO SHIFT GEARS/STEER THE VEHICLE. THE BRAKE AND TAIL LIGHTS FAILED TO WORK. *AK THE ELECTRICAL SYSTEM WAS INTERMITTENT, THE RADIO WOULD GO OFF WHEN THE STEERING WHEEL WAS TURNED AND WHEN THE VEHICLE WAS IN DRIVE. THE PROBLEM WOULD START WHEN THE VEHICLE WAS IN PARK, REVERSE, OR NEUTRAL. THE SEAT BELT LIGHT FLICKERED ON AND OFF WITHOUT CAUSE. *SC *JB

NHTSA ID

10087207

Incident

Apr 22, 2004

Mileage

13,000 mi

THE CAR WAS PARKED. I STARTED THE CAR, STEPPED ON THE BRAKES AND IT WENT TO THE FLOOR. I LOOKED UNDER THE CAR AND SAW OIL LEAKING ABOUT A FOOT FORWARD OF THE DRIVERS SIDE REAR TIRE. *LA

NHTSA ID

10081154

Incident

Jul 15, 2004

Mileage

78,000 mi

WHILE DRIVING AT ANY SPEED ABS LIGHT APPEARED ON THE DASHBOARD. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP FOR INSPECTION. *AK THE CHECK ENGINE SOON HAD ALSO COME ON. THE CONSUMER STATED THAT THE LIGHTS WOULD COME ON INTERMITTENTLY, BOTH AT DIFFERENT TIMES. *SC

NHTSA ID

10071708

Incident

Apr 5, 2004

Mileage

27,000 mi

CRACKED FORWARD PISTON IN TRANS. I HAVE A`97,,,WASN`T THAT PROBLEM FIXED?

NHTSA ID

10068794

Incident

Mar 15, 2002

Mileage

7,200 mi

SERVICE ENGINE LIGHT WILL NOT TURN OFF...TRANSMISSION HAS BEEN REPLACED AND REPAIRED AND IS NOW NEEDING REPAIR AGAIN...TIRES FROM NORMAL WEAR...BRAKES FROM NORMAL WEAR...

NHTSA ID

10068718

Incident

Aug 15, 2003

Mileage

63,941 mi

THE DASHBOARD IS SEPARATING IN LAYERS FROM THE FRAME OF THE INSTRUMENT PANEL. THERE IS TSB 00203 CONCERNING THIS PROBLEM. ALSO, THE CONSUMER IS HAVING PROBLEMS WITH THE ABS LIGHT COMING ON AND STAYING ON. *AK

NHTSA ID

10048007

Incident

Mar 22, 2000

Mileage

90 mi

1997 FORD TARUS HAS BRAKE PROBLEMS. BEGAN WITH SHAKING OF STEERING WHEEL WHEN BRAKES APPLIED AT EXITS OFF OF INTERSTATE. AFTER 3 ATTEMPTS FROM JAN 99 THRU OCT 01 TO GET THE LOCAL FORD DEALER TO REPAIR UNDER WARRANTY I HAD THEM SEMI- REPAIRED AT A LOCAL JUST BRAKES REPAIR SHOP WHERE I WAS TOLD THAT CALIPERS WEREN'T RELEASING. STILL HAVE BRAKE NOISE AS IF CALIPERS ARE NOT FULLY RELEASING. *AK

NHTSA ID

10030361

Incident

Jan 18, 1999

Mileage

16,775 mi

THE VEHICLE EXPERIENCED GRINDING NOISE ON THE REAR PASSENGER SIDE. THE BRAKE ROTORS COULD NOT BE RESURFACED BECAUSE THEY WERE TOO THIN. THE CONSUMER FELT THAT THE ELIMINATION OF THE WARNING INDICATOR ON THE REAR BRAKE PADS COULD POSE A HAZARD BECAUSE SUDDEN BRAKE FAILURE COULD OCCUR WITHOUT WARNING. *PH *CB *NLM

NHTSA ID

10027311

Mileage

58,000 mi

WHILE DRIVING 55 MPH BRAKE FAILED TO OPERATE. VEHICLE TOWED TO DEALER. THEY INFORMED CONSUMER MASTER BRAKE CYLINDER WAS THE PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8015368

Incident

Jul 25, 2002