Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 1991 Ford Thunderbird submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 19 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
LOSS OF HYDRAULIC BRAKE ASSIST ON SUPER COUPE. PEDAL BECAME HARD TO PRESS. BOTH BRAKE AND ABS ANNUNCIATORS ILLUMINATING. TROUBLESHOOTING INDICATES BRAKE PRESSURE SWITCH FAILING TO SIGNAL PUMP TO CHARGE SYSTEM OR ACCUMULATOR HAS FAILED. MASTER CYLINDER AND ABS SYSTEM ARE ORIGINAL EQUIPMENT AND THUS 24 YEARS OLD.
ANTI-LOCK BRAKES AND BRAKE SYSTEM WARNING LIGHTS ON DASHBOARD COME ON. WHEN CONSUMER ATTEMPTS TO SLOW/STOP VEHICLE, THERE IS NO RESISTANCE BEHIND THE BRAKE PEDAL, AND IT GOES TO THE FLOOR. THIS HAS OCCURRED THREE TIMES; AT 15-20 MPH RANGE/ 20-30 MPH RANGE, AND AT 40-50 MPH RANGE. A PRIVATE MECHANIC STATED THAT ON A PREVIOUS VEHICLE WITH SAME DEFECT OCCURRED. THEY RAN A DIAGNOSTIC ON BRAKE SYSTEM AND FOUND NO DEFECTS, BUT REPLACED BRAKE SYSTEM WHICH REPAIRED DEFECT. CONSUMER HAS NOT DETERMINED WHETHER OR NOT HE WILL HAVE THIS DONE. *AK *SLC
THROUGH MOUNTAINOUS REGION IN AR, THROTTLE STUCK WIDE OPEN...FOUND A LITTLE $3 PIECE THAT BROKE ON THE PART THAT HOLDS THE LINKAGE TO THE TRANSMISSION TO THE THROTTLE... CAR KEPT GOING FASTER AND FASTER... BRAKE SYSTEM FAILED. HAD TO PUT CAR IN NEUTRAL, AND GO UP STEEP INCLINE... KEY WOULD NOT COME OUT BECAUSE THE IGNITION SWITCH IS NOT FUNCTIONING PROPERLY. HAD TO REPLACE THE PIECE THAT BROKE, THE TRANSMISSION, CAR STILL IDLED HIGH.. AND HAD TO REPLACE ANOTHER PART AS WELL. THE BRAKES ARE VERY SPONGY, THEY HAVE BEEN BLED NUMEROUS TIMES, AND THE MASTER CYLANDER REPLACED AND THEY STILL HAVE TO BE PRESSED DOWN 2-3 INCHES (VERY SOFT) BEFORE YOU FEEL ANY SORT OF BRAKAGE. THE CAR STILL DOES NOT RUN CORRECTLY. HAVE SPENT 650.00 + ON AIR CONDITIONER, AND IT STILL DOES NOT WORK RIGHT. APPEARS TO BE A SHORT IN IT, BECAUSE WHEN CAR IS ACCELLERATED, IT WILL START COOLING AGAIN... ONE PART HAS BEEN REPLACED 3 TIMES, SO SOMETHING IS SHORTING IT OUT.
I WAS ON MY WAY TO WORK WHEN THE TRUCK IN FRONT OF ME STOPPED IN FRONT OF ME TO LET A CAR IN OUR LANE. WE WERE GOING AROUND 15 MPH. WHEN I STEPPED ON THE BRAKE, I JUST KEPT ON GOING AND HIT THE TRUCK IN THE REAR. I PUT THE CAR IN PARK AND GOT OUT AND WENT OVER TO THE DRIVER OF THE TRUCK TO MAKE SURE HE WAS OK. HE TOLD ME HE WAS FINE,AT WHICH POINT I TOLD HIM THE DAMAGE DONE WAS TO MY CAR AND HIS TRUCK WAS FINE. HE SAID FINE AND WENT ON HIS WAY. I GOT BACK IN MY CAR AND FOUND MY BRAKE PEDDLE HAD BROKEN OFF THE ARM AND WAS ON THE FLOOR. THE METAL PART OF PEDDLE SNAPPED RIGHT OFF THE BRAKE ARM.
ON 3 OCCASIONS CONSUMER EXPERIENCED TOTAL BRAKE FAILURE WITHIN 44,000 MILES WHEN MAKING NORMAL OR SUDDEN STOPS. PEDAL WENT TO FLOOR, RESULTING IN A SAFETY HAZARD. *AK
CONSUMER HAS EXPERIENCED PROBLEM WITH INTERMITTENT BRAKE FAILURE. WHEN BRAKES APPLIED VEHICLE WOULD KEEP ON GOING. ALSO, INTERMITTENTLY PARK LIGHTS AND ABS LIGHTS WOULD COME ON, AND ALL BRAKES WOULD FAIL TO STOP VEHICLE. DEALER NOTIFIED. *AK
DISC BRAKE ROTORS WARPED, CAUSING VEHICLE TO SHAKE UPON BRAKING. *AK
PADS AND ROTORS REPLACED 3 TIMES.
DRIVER EXPERIENCES A TOTAL LOSS OF ABS BRAKES WHILE DRIVING. THIS IS AN INTERMITTENT PROBLEM. *AK
REPEATED BRAKE PROBLEMS AFTER SEVERAL REPAIR ATTEMPTS, CAUSING REAR BRAKES TO OVERHEAT/MELT.
BRAKES FAILED, CAUSING ACCIDENT.
WITHIN 20,000 MILES THE FRONT BRAKES ROTORS HAS BEEN REPLACED THREE TIMES. *AK
WHEN BRAKES ARE APPLIED AT 50, 60 MPH THEY STICK. PLEASE DESCRIBE DETAILS. TT
ABS BRAKES SYSTEM FAILURE, SPORADIC FAILURE OF THE BRAKES, PARTIAL LOSS OF BRAKING. TT
REPLACED THE MASTER CYLINDER , THE SPEED ODOMETER WAS REPLACED THE POWER STEERING WENT SOMETIMES DRIVING CAR LOST POWER . TT
THE VEHICLE IS NOT STOPPING DUE TO BAD ROTORS AND THE CALIPERS ARE STUCK IN THE FRONT BRAKES. PLEASE DESCRIBE. *AK
ABS BRAKE SYSTEM HAS FAILED SIX TIMES SINCE VEHICLES PURCHASE. TT
PADS ARE WEARING PREMATURELY, HAD TO HAVE THEM REPLACED FIVE TIMES, ONLY 42,000 MILES. TT
THE ROTOR HAD TO BE REPLACE EVERY THREE MONTH AND THE FUSE KEEP BLOWING OUT . TT
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .