1997 Ford Thunderbird Owner Complaints

1997 FORD THUNDERBIRD. CONSUMER WRITES IN REGARDS TO VEHICLE VIN# NOT LISTED ON DEFECTIVE BRAKE PADS/ROTORS RECALL NOTICE. *SMD

NHTSA ID

10898835

Incident

Sep 1, 2016

I SMELL GAS WHEN DRIVING AT HIGH SPEED OF 60 AND ABOVE ON FREEWAY MOSTLY. ONCE IN A WHILE I CAN SMELL IT WHEN DRIVING AT LOWER SPEEDS OF 25 -30MPH. I USED TO THINK THAT I HAD SPILLED GAS ON THE OUTSIDE OF CAR WHEN IT FIRST STARTED HAPPENING, BUT NOW A YEAR LATER, I STILL SMELL GAS AND I DO SMOKE IN MY CAR, BUT WHEN I SMELL THE GAS, I WILL PUT THE CIGARETTE OUT. IS THERE SOME KIND OF RECALL ON THIS PROBLEM, THAT CAN REPAIR IT. I HAVE PUT $4000.00 INTO RESTORING THE CAR AND I AND PUTTING ANOTHER $800.00 INTO IT NEXT WEEK, NOVEMBER 2013, TO REPLACE ALL OF THE BELTS AROUND THE ENGINE. I HAVE ALREADY REBUILT THE TRANSMISSION FOR $1800.00 AT AAMCO, AND PUT A $2200.00 PAINT JOB ON IT, BEFORE I KNEW OF THE GAS SMELL. I HAVE ALSO REPLACED ALTERNATOR AND BATTERY. AM I FIGHTING A LOSING BATTLE WITH THIS CAR? *TR

NHTSA ID

10550111

Incident

Oct 1, 2012

Mileage

101,000 mi

IN THE MIDDLE OF AUGUST I SMELT GAS WHEN I DROVE. AND THE SMELL HAS BECOME STRONGER AND STRONGER. TODAY (10/10/2011) I WENT TO A VEHICLE REPAIR SHOP AND WAS TOLD THE LEAKING IS ON THE TOP OF FUEL TANK AND COULD NOT BE REPAIRED IN THE SHOP. I CHECKED ONLINE AND FOUND MANY PEOPLE HAVE EXPERIENCED THIS VERY DANGEROUS LEAK. PLEASE CLICK THE LINK: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T872_DS478881. THIS CAR MUST BE RECALLED FOR FUEL LEAKING. *KB

NHTSA ID

10429371

Incident

Aug 10, 2011

Mileage

69,400 mi

TL* THE CONTACT OWNS A 1997 FORD THUNDERBIRD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED HOME AND WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT ALSO STATED THAT PRIOR TO THE FAILURE, THE VEHICLE WOULD DECELERATE WHILE DRIVING AT VARIOUS SPEEDS. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

NHTSA ID

10413447

Incident

Jul 15, 2011

Mileage

86,000 mi

THE PLASTIC INTAKE MANIFOLD ON MY 1997 FORD THUNDERBIRD CRACKED SPILLING OUT ALL MY COOLANT AND CAUSING MY ENGINE TO OVERHEAT, THIS IS A DESIGN FLAW THAT SHOULD BE COVERD BY FORD MOTOR COMPANY, THIS HAPPEND WHILE DRIVING DOWN GRATIOT AVE. IN ROSEVILLE MI AT 40 MILES PER HOUR WITH NO PREVIOUS WARNING, THIS FAILURE HAPPEND 7/3/2011 SATURDAY OVER THE FORTH OF JULY WEEKEND, WHERE I COULDN'T GET IT TO A OPEN FORD DEALERSHIP, NOW I CONNOT USE MY VEHICAL FOR WORK MONDAY 7/4/2011. WILL THIS REPAIR BE COVERD BY FORD MOTOR COMPANY? *TR

NHTSA ID

10410350

Incident

Jul 3, 2011

Mileage

55,770 mi

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

NHTSA ID

10287146

Incident

Oct 5, 2008

Mileage

162,000 mi

I HAVE A 1997 FORD THUNDERBIRD THAT HAS A MANIFOLD PROBLEM. I AM BEING TOLD BY FORD THAT IT DOESN'T FALL UNDER THE RECALL FROM 2005 BECAUSE IT WASN'T BUILT IN THE RIGHT PLANT. I HAVE READ A LOT OF INFORMATION THAT ALL OF THE 1997 T-BIRD HAVE THIS PROBLEM AND NEED TO BE FIXED. NOT ONLY IS DOES MY CAR NOT RUN RIGHT, BUT I ALSO AM NOT FACING REPLACING MY CATALYTIC CONVERTER, AS WELL DUE TO THE LEAKAGE. WE ARE TALKING ABOUT $1700 IN REPAIR. *TR

NHTSA ID

10274375

Incident

May 1, 2009

WHEN I BOUGHT THE CAR, A YEAR AGO, IT RAN GREAT. ONE DAY AS I AS COMING UP A HILL, MY CAR STARTED SHAKING. IT WAS A CRACKED INTAKE MANIFOLD, THAT OF WHICH FORD WAS IN A CLASS ACTION LAWSUIT IN 2005. WHICH COVERED A "SELECT FEW" OF THUNDERBIRDS. HOWEVER NOW THAT MY MANIFOLD CRACKED, THERE "NOT AT FAULT." WE HAD THE CAR FIXED, ONLY TO LEARN AFTERWARDS THAT FORD HAD SEVERAL ISSUES ABOUT THE FAULTY INTAKE. *TR

NHTSA ID

10260469

Incident

Feb 27, 2009

Mileage

159,000 mi

ENGINE IDLE RACING. CAN'T STOP UNLESS PLACED IN NEUTRAL, WHERE CAR WOULD RUN OVER 2000 RPM. DEALER REPLACED IDLE AIR CONTROL AND POWER CONTROL MODULE. DEALER STATED THAT IDLE AIR CONTROL BURNS OUT THE POWER TRAIN CONTROL MODULES ON MANY V-6 FORD ENGINES. CAR HAD ONLY 34,518 MILES CHECKED OTHER SURGES THAT THIS IS A SAFETY ISSUE OF RACING ENGINES IN ACCIDENTS OF V-6 MOTORS AND FORD REFUSING ANY RECALLS FOR POSSIBLE FIRE OF IDLE AIR CONTROL AND THE BURNING OUT OF POWER TRAIN CONTROL MODULE. *TR

NHTSA ID

10232085

Incident

Jun 12, 2008

Mileage

34,518 mi

1997 FORD THUNDERBIRD WITH SHIFTING PROBLEMS. CONSUMER STATES THAT THE SHIFTER LEVER AFTER PRESSURE ON BRAKE PEDAL DOES NOT RELEASE SHIFTER HANDLE. HE HAD THE BRAKE LIGHT/RELEASE SWITCH REPLACED AND PROBLEM STILL EXISTS. *KB THE CONSUMER HAD DIFFICULTY REMOVING THE SHIFTER OUT OF PARK.

NHTSA ID

10225048

Incident

Jan 1, 1901

PLASTIC INTAKE MANIFOLD FAILURE. *JB

NHTSA ID

10205781

Incident

Sep 13, 2007

Mileage

203,500 mi

MY WIFE DROVE HER 1997 FORD THUNDERBIRD TO WORK TODAY. SHE PARKED HER CAR IN THE COMPANY GARAGE AND WALKED INTO WORK. THE CAR THEN BEGAN TO BURN AND TOTALED THE CAR. AFTER HAVING IT TOWED TO A LOCAL GARAGE, BASED UPON THE KNOWLEDGE OF THE MECHANIC, TO WHOM, I HAVE USED TO SERVICE MY VEHICLES FOR OVER 10 YEARS, TOLD ME THAT THE INTENSITY OF THE FIRE WAS NEAR THE STEERING COLUMN, AND AND POWER STEERING SWITCHES. UPON RESEARCHING THE ABOVE FACTS, FOUND THE RECALL ABOUT THE VARIOUS FORD TRUCKS AND THIS SIMILAR PROBLEM. WE HAVE LIABILITY INSURANCE ON THIS CAR, AND NOW WE HAVE LOST THE CAR TO NO FAULT OF OUR OWN. ARE THERE OTHER FORD CARS WITH THE SAME PROBLEM?

NHTSA ID

10202844

Incident

Sep 12, 2007

TL*THE CONTACT OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 40 MPH, IN HEAVY TRAFFIC THE CONTACT NOTICED SMOKE RISING FROM UNDER THE HOOD. THE TEMPERATURE GAUGE NEEDLE SHIFTED TO THE HOT INDICATOR. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE ENGINE WAS LEAKING COOLANT AND THE PLASTIC INTAKE MANIFOLD WAS CRACKED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 73,500. *UPDATED 12/12/07 *BF UPDATED 12/12/07

NHTSA ID

10202164

Incident

Sep 6, 2007

Mileage

73,500 mi

TL*THE CONTACT'S DAUGHTER OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED AND THE CONTACT NOTICED THAT ANTIFREEZE WAS LEAKING. HER DAUGHTER NOTICED A CRACK ON THE INTAKE MANIFOLD, WHICH SHE BELIEVED MAY BE THE CAUSE OF FAILURE. AS OF AUGUST 31, 2007, THE DEALER HAS NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 60,000.

NHTSA ID

10201345

Incident

Jun 1, 2007

Mileage

57,000 mi

MY MECHANIC HAS INFORMED ME OF A DANGEROUS SITUATION WITH MY AUTOMOBILE THAT COULD LEAD TO AN ACCIDENT. ALL THE BALL JOINTS IN THE FRONT END ARE WORN EXCESSIVELY. HE SAYS THE EXCESSIVE WEAR IS A RESULT OF THE DUST SEALS DISINTEGRATING ALLOWING DIRT AND WATER TO ENTER THE BALL JOINTS. HE INDICATED THAT THIS IS PROBABLY A RESULT OF THE USE OF INAPPROPRIATE OR DEFECTIVE MATERIALS FOR THE SEALS. I AM GOING TO HAVE THE BALL JOINTS REPLACED. I WILL ASK THE MECHANIC TO KEEP THE OLD PARTS FOR ME. *NM

NHTSA ID

10172453

Incident

Nov 2, 2006

Mileage

96,000 mi

DT*: THE CONTACT STATED WHILE PERFORMING GENERAL MAINTENANCE ON THE VEHICLE, IT WAS DETERMINED THE PLASTIC SEALS ON ALL FOUR UPPER AND LOWER BALL JOINTS AS WELL AS THE SEALS ON THE STABILIZER BAR WERE FRACTURED AND DETERIORATING. THE MANUFACTURER WAS ALERTED.

NHTSA ID

10170731

Incident

Oct 13, 2006

Mileage

58,000 mi

INTAKE MANIFOLD SPLIT CAUSING COOLANT LEAKAGE. *NM

NHTSA ID

10154892

Incident

Apr 6, 2006

Mileage

72,950 mi

DT: THE CONTACT STATED THE FLOOR SHIFTER WAS STICKING IN PARK WHEN THE WEATHER WAS COLD. IT TOOK FIVE TO TEN MINUTES TO MOVE THE SHIFTER INTO OTHER GEARS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THE DEALER SAID THE PART WAS UNAVAILABLE, AND THEY WOULD HAVE TO GO TO A JUNK YARD TO LOCATE ANOTHER SHIFTER. NO REPAIRS HAVE BEEN MADE. *AK

NHTSA ID

10145991

Incident

Nov 15, 2005

Mileage

68,000 mi

1997 FORD THUNDERBIRD MOTOR DIED WHILE DRIVING.*MR ***NOT IN REPOSITORY. *NM

NHTSA ID

10120421

Incident

Jan 1, 1901

I PURCHASED THIS 1997 FORD THUNDERBIRD LX SPORT AS A USED VEHICLE IN OCT. 2002. I NOTICED THAT DURING THE FIRST FEW WEEKS OF OWNING THIS VEHICLE IT WOULD INTERMITTENTLY LEAK A SUBSTANTIAL AMOUNT OF COOLANT ONTO MY DRIVEWAY BUT I COULD NEVER SEE WHERE IT WAS COMING FROM. SOMETIMES IT WOULD GO FOR DAYS WITHOUT LEAKING AND THEN ONE DAY THERE WOULD BE OVER A QUART OF COOLANT ON THE DRIVEWAY. I BROUGHT THE CAR INTO A SHOP THAT PUT THE CAR ON A LIFT TO LOOK FOR THE LEAK BUT THEY COULD NOT FIND ONE. I CONTINUED TO DRIVE THE CAR AND ADD COOLANT EVERY TIME THE "LOW COOLANT" LIGHT APPEARED ON THE DASH PANEL. IN MAY 2005 I WAS ON THE 91 FREEWAY AND SUDDENLY WITHOUT WARNING THE "LOW COOLANT" LIGHT CAME ON AND THE TEMP CAME UP QUICKLY SO I TRIED TO CHANGE LANES TO THE RIGHT TO EXIT THE FREEWAY AND THE BACK OF THE CAR BROKE LOOSE AND I ALMOST TURNED SIDEWAYS. I FOUND OUT LATER THAT THE REAR TIRES AND WHEEL WELLS WERE SOAKED IN COOLANT. THIS WAS THE FIRST TIME THAT I FOUND OUT THAT MY INTERMITTENT LEAK THAT NO ONE COULD FIND WAS MY INTAKE MANIFOLD AT THE BASE OF THE THERMOSTAT HOUSING. I WENT TO RANCHO SANTA MARGARITA FORD AND ASKED ABOUT RECALLS AND THEY TOLD ME THAT THE RECALL FOR THE INTAKE MANIFOLD HAD EXPIRED A COUPLE OF MONTHS AGO AND THAT THERE WAS NOTHING THAT THEY COULD DO. I CALLED FORD MOTOR CO. CUSTOMER RELATIONS AND WAS TOLD THE SAME THING. THE CAR NOW SITS PARKED UNREPAIRED. I CANNOT AFFORD TO PAY ALMOST TWO THOUSAND DOLLARS TO CORRECT FORDS ENGINEERING BLUNDER. *JB

NHTSA ID

10143721

Incident

Oct 25, 2002

Mileage

115,000 mi

INTAKE MANIFOLD CRACKED CAUSING COOLANT TO LEAK OUT. FORD WILL NOT REPAIR UNLESS I PAY FOR IT. CLASS ACTION LAW SUIT PENDING. FORD AGREED TO REPLACE ON VEHICLES 7 YEARS OLD OR LESS. MY VEH IS 8 YEARS OLD WITH 26000 MILES. BAD DESIGN FOR INTAKE. *NM

NHTSA ID

10139547

Incident

Oct 13, 2005

Mileage

26,000 mi

DT: 1997 FORD THUNDERBIRD LX V8 4.6 LITERS. 1997 FORD THUNDERBIRD LX HAD A COOLANT LEAK. THE PLASTIC INTAKE MANIFOLD OVERHEATED. COULD SMELL ANTIFREEZE WHEN GETTING OUT OF VEHICLE. THE ANTIFREEZE WAS LEAKING IN THREE PLACES. VEHICLE HAD THE ORIGINAL PARTS. THE CONSUMER WAS THE SECOND OWNER OF THE VEHICLE. HAD NOT CONTACTED THE MANUFACTURER. DID HAVE SOMEONE LOOK AT VEHICLE , WHO CONFIRMED THAT THE INTAKE MANIFOLD WAS PLASTIC AND VEHICLE WAS LEAKING ANTIFREEZE, AND THAT THE O RINGS NEEDED TO BE REPLACED. MANUFACTURER WAS AWARE OF THIS PROBLEM. THE CONSUMER FOUND ON THE INTERNET THAT A TECHNICAL SERVICE BULLETINS WAS SENT OUT ON FEBRUARY 2, 2002 DISCUSSING THIS PROBLEM. HOWEVER, THE CONSUMER WAS UNAWARE OF THE TECHNICAL SERVICE BULLETIN. *AK

NHTSA ID

10139300

Incident

Feb 1, 2005

UPPER INTAKE MANIFOLD ON MY 1997 4.6 L THUNDERBIRD CRACKED AND BLEW ALL THE COOLANT INTO THE ENGINE COMPARTMENT. I HAD TO PAY FORD TO REPLACE THE UPPER INTAKE AND THE PLUGS THAT WERE FOULED OUT. THEY REFUSED ANY RESPONSIBILITY EVEN WITH A FORMAL WRITTEN COMPLAINT TO THEIR HOME OFFICE. IT IS MY UNDERSTANDING THIS IS HAPPENING TO A LOT OF THEIR 4.6 L ENGINES IN A VARIETY OF VEHICLES.*JB

NHTSA ID

10135684

Incident

May 1, 2005

Mileage

98,000 mi

HEADLIGHT LENSES ON 1997 THUNDERBIRD CLOUD OVER DUE TO WEATHERING AND LIMIT AMOUNT OF LIGHT EMITTED. NIGHT VISION AND OBJECT ILLUMINATION IS SERIOUSLY COMPROMISED. VIGOROUS POLISHING TEMPORARILY REMOVES HAZE, BUT IT HAS BEEN MY EXPERIENCE THAT THE CONDITION RETURNS MORE QUICKLY. I RECENTLY HAD TO SWERVE INTO A LARGE POT HOLE TO AVOID A CITY RECYCLE CAN THAT HAD OVERTURNED AND, BEING DARK GREEN, IMPOSSIBLE TO SEE AT NIGHT. I DAMAGED MY LEFT FRONT WHEEL. *AK

NHTSA ID

10135141

Incident

Aug 30, 2005

Mileage

52,244 mi

DT: THE CONSUMER STATED A YEAR AGO WA SINVOLVED IN 2 REAR END COLLISIONS WHILE DRIVING 3 MPH. THIS HAPPENED WITH FOOT ON THE BRAKE IN BUMPER TO BUMPER TRAFFIC. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, BUT IT WAS NOT LOOKED AT, THEY INSTEAD TRIED TO SELL CONSUMER ANOTHER VEHICLE. PLANNED TO HAVE THE VEHICLE INSPECTED AT CONSUMER'S OWN EXPENSE AT ANOTHER MECHANIC. DEALERSHIP STATED THEY KNEW THAT THE PROBLEM EXISTED. . THE MANUFACTURER TOLD HE WOULD HAVE TO HAVE THE PROBLEM DIAGNOSED, BUT THE DEALERSHIP WOULD NOT LOOK AT THE VEHICLE. WHEN THE VEHICLE WAS FIRST PURCHASED,IT WOULD DRAG BETWEEN GEARS. IN THE LAST YEAR, NOTICED SURGING. HAD TO PUT THE VEHICLE IN NEUTRAL TO STOP, AND ANOTHER TIMEHAD TO PUT ON THE EMERGENCY BRAKEON. THERE WERE NO POLICE REPORTS TAKEN, THERE WASNO DAMAGE OR INJURIES.*AK

NHTSA ID

10131043

Incident

Oct 31, 1997