1997 Ford Thunderbird Engine Problems

I SMELL GAS WHEN DRIVING AT HIGH SPEED OF 60 AND ABOVE ON FREEWAY MOSTLY. ONCE IN A WHILE I CAN SMELL IT WHEN DRIVING AT LOWER SPEEDS OF 25 -30MPH. I USED TO THINK THAT I HAD SPILLED GAS ON THE OUTSIDE OF CAR WHEN IT FIRST STARTED HAPPENING, BUT NOW A YEAR LATER, I STILL SMELL GAS AND I DO SMOKE IN MY CAR, BUT WHEN I SMELL THE GAS, I WILL PUT THE CIGARETTE OUT. IS THERE SOME KIND OF RECALL ON THIS PROBLEM, THAT CAN REPAIR IT. I HAVE PUT $4000.00 INTO RESTORING THE CAR AND I AND PUTTING ANOTHER $800.00 INTO IT NEXT WEEK, NOVEMBER 2013, TO REPLACE ALL OF THE BELTS AROUND THE ENGINE. I HAVE ALREADY REBUILT THE TRANSMISSION FOR $1800.00 AT AAMCO, AND PUT A $2200.00 PAINT JOB ON IT, BEFORE I KNEW OF THE GAS SMELL. I HAVE ALSO REPLACED ALTERNATOR AND BATTERY. AM I FIGHTING A LOSING BATTLE WITH THIS CAR? *TR

NHTSA ID

10550111

Incident

Oct 1, 2012

Mileage

101,000 mi

THE PLASTIC INTAKE MANIFOLD ON MY 1997 FORD THUNDERBIRD CRACKED SPILLING OUT ALL MY COOLANT AND CAUSING MY ENGINE TO OVERHEAT, THIS IS A DESIGN FLAW THAT SHOULD BE COVERD BY FORD MOTOR COMPANY, THIS HAPPEND WHILE DRIVING DOWN GRATIOT AVE. IN ROSEVILLE MI AT 40 MILES PER HOUR WITH NO PREVIOUS WARNING, THIS FAILURE HAPPEND 7/3/2011 SATURDAY OVER THE FORTH OF JULY WEEKEND, WHERE I COULDN'T GET IT TO A OPEN FORD DEALERSHIP, NOW I CONNOT USE MY VEHICAL FOR WORK MONDAY 7/4/2011. WILL THIS REPAIR BE COVERD BY FORD MOTOR COMPANY? *TR

NHTSA ID

10410350

Incident

Jul 3, 2011

Mileage

55,770 mi

I HAVE A 1997 FORD THUNDERBIRD THAT HAS A MANIFOLD PROBLEM. I AM BEING TOLD BY FORD THAT IT DOESN'T FALL UNDER THE RECALL FROM 2005 BECAUSE IT WASN'T BUILT IN THE RIGHT PLANT. I HAVE READ A LOT OF INFORMATION THAT ALL OF THE 1997 T-BIRD HAVE THIS PROBLEM AND NEED TO BE FIXED. NOT ONLY IS DOES MY CAR NOT RUN RIGHT, BUT I ALSO AM NOT FACING REPLACING MY CATALYTIC CONVERTER, AS WELL DUE TO THE LEAKAGE. WE ARE TALKING ABOUT $1700 IN REPAIR. *TR

NHTSA ID

10274375

Incident

May 1, 2009

WHEN I BOUGHT THE CAR, A YEAR AGO, IT RAN GREAT. ONE DAY AS I AS COMING UP A HILL, MY CAR STARTED SHAKING. IT WAS A CRACKED INTAKE MANIFOLD, THAT OF WHICH FORD WAS IN A CLASS ACTION LAWSUIT IN 2005. WHICH COVERED A "SELECT FEW" OF THUNDERBIRDS. HOWEVER NOW THAT MY MANIFOLD CRACKED, THERE "NOT AT FAULT." WE HAD THE CAR FIXED, ONLY TO LEARN AFTERWARDS THAT FORD HAD SEVERAL ISSUES ABOUT THE FAULTY INTAKE. *TR

NHTSA ID

10260469

Incident

Feb 27, 2009

Mileage

159,000 mi

ENGINE IDLE RACING. CAN'T STOP UNLESS PLACED IN NEUTRAL, WHERE CAR WOULD RUN OVER 2000 RPM. DEALER REPLACED IDLE AIR CONTROL AND POWER CONTROL MODULE. DEALER STATED THAT IDLE AIR CONTROL BURNS OUT THE POWER TRAIN CONTROL MODULES ON MANY V-6 FORD ENGINES. CAR HAD ONLY 34,518 MILES CHECKED OTHER SURGES THAT THIS IS A SAFETY ISSUE OF RACING ENGINES IN ACCIDENTS OF V-6 MOTORS AND FORD REFUSING ANY RECALLS FOR POSSIBLE FIRE OF IDLE AIR CONTROL AND THE BURNING OUT OF POWER TRAIN CONTROL MODULE. *TR

NHTSA ID

10232085

Incident

Jun 12, 2008

Mileage

34,518 mi

PLASTIC INTAKE MANIFOLD FAILURE. *JB

NHTSA ID

10205781

Incident

Sep 13, 2007

Mileage

203,500 mi

TL*THE CONTACT OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 40 MPH, IN HEAVY TRAFFIC THE CONTACT NOTICED SMOKE RISING FROM UNDER THE HOOD. THE TEMPERATURE GAUGE NEEDLE SHIFTED TO THE HOT INDICATOR. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE ENGINE WAS LEAKING COOLANT AND THE PLASTIC INTAKE MANIFOLD WAS CRACKED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 73,500. *UPDATED 12/12/07 *BF UPDATED 12/12/07

NHTSA ID

10202164

Incident

Sep 6, 2007

Mileage

73,500 mi

TL*THE CONTACT'S DAUGHTER OWNS A 1997 FORD THUNDERBIRD. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED AND THE CONTACT NOTICED THAT ANTIFREEZE WAS LEAKING. HER DAUGHTER NOTICED A CRACK ON THE INTAKE MANIFOLD, WHICH SHE BELIEVED MAY BE THE CAUSE OF FAILURE. AS OF AUGUST 31, 2007, THE DEALER HAS NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 60,000.

NHTSA ID

10201345

Incident

Jun 1, 2007

Mileage

57,000 mi

INTAKE MANIFOLD SPLIT CAUSING COOLANT LEAKAGE. *NM

NHTSA ID

10154892

Incident

Apr 6, 2006

Mileage

72,950 mi

1997 FORD THUNDERBIRD MOTOR DIED WHILE DRIVING.*MR ***NOT IN REPOSITORY. *NM

NHTSA ID

10120421

Incident

Jan 1, 1901

I PURCHASED THIS 1997 FORD THUNDERBIRD LX SPORT AS A USED VEHICLE IN OCT. 2002. I NOTICED THAT DURING THE FIRST FEW WEEKS OF OWNING THIS VEHICLE IT WOULD INTERMITTENTLY LEAK A SUBSTANTIAL AMOUNT OF COOLANT ONTO MY DRIVEWAY BUT I COULD NEVER SEE WHERE IT WAS COMING FROM. SOMETIMES IT WOULD GO FOR DAYS WITHOUT LEAKING AND THEN ONE DAY THERE WOULD BE OVER A QUART OF COOLANT ON THE DRIVEWAY. I BROUGHT THE CAR INTO A SHOP THAT PUT THE CAR ON A LIFT TO LOOK FOR THE LEAK BUT THEY COULD NOT FIND ONE. I CONTINUED TO DRIVE THE CAR AND ADD COOLANT EVERY TIME THE "LOW COOLANT" LIGHT APPEARED ON THE DASH PANEL. IN MAY 2005 I WAS ON THE 91 FREEWAY AND SUDDENLY WITHOUT WARNING THE "LOW COOLANT" LIGHT CAME ON AND THE TEMP CAME UP QUICKLY SO I TRIED TO CHANGE LANES TO THE RIGHT TO EXIT THE FREEWAY AND THE BACK OF THE CAR BROKE LOOSE AND I ALMOST TURNED SIDEWAYS. I FOUND OUT LATER THAT THE REAR TIRES AND WHEEL WELLS WERE SOAKED IN COOLANT. THIS WAS THE FIRST TIME THAT I FOUND OUT THAT MY INTERMITTENT LEAK THAT NO ONE COULD FIND WAS MY INTAKE MANIFOLD AT THE BASE OF THE THERMOSTAT HOUSING. I WENT TO RANCHO SANTA MARGARITA FORD AND ASKED ABOUT RECALLS AND THEY TOLD ME THAT THE RECALL FOR THE INTAKE MANIFOLD HAD EXPIRED A COUPLE OF MONTHS AGO AND THAT THERE WAS NOTHING THAT THEY COULD DO. I CALLED FORD MOTOR CO. CUSTOMER RELATIONS AND WAS TOLD THE SAME THING. THE CAR NOW SITS PARKED UNREPAIRED. I CANNOT AFFORD TO PAY ALMOST TWO THOUSAND DOLLARS TO CORRECT FORDS ENGINEERING BLUNDER. *JB

NHTSA ID

10143721

Incident

Oct 25, 2002

Mileage

115,000 mi

INTAKE MANIFOLD CRACKED CAUSING COOLANT TO LEAK OUT. FORD WILL NOT REPAIR UNLESS I PAY FOR IT. CLASS ACTION LAW SUIT PENDING. FORD AGREED TO REPLACE ON VEHICLES 7 YEARS OLD OR LESS. MY VEH IS 8 YEARS OLD WITH 26000 MILES. BAD DESIGN FOR INTAKE. *NM

NHTSA ID

10139547

Incident

Oct 13, 2005

Mileage

26,000 mi

DT: 1997 FORD THUNDERBIRD LX V8 4.6 LITERS. 1997 FORD THUNDERBIRD LX HAD A COOLANT LEAK. THE PLASTIC INTAKE MANIFOLD OVERHEATED. COULD SMELL ANTIFREEZE WHEN GETTING OUT OF VEHICLE. THE ANTIFREEZE WAS LEAKING IN THREE PLACES. VEHICLE HAD THE ORIGINAL PARTS. THE CONSUMER WAS THE SECOND OWNER OF THE VEHICLE. HAD NOT CONTACTED THE MANUFACTURER. DID HAVE SOMEONE LOOK AT VEHICLE , WHO CONFIRMED THAT THE INTAKE MANIFOLD WAS PLASTIC AND VEHICLE WAS LEAKING ANTIFREEZE, AND THAT THE O RINGS NEEDED TO BE REPLACED. MANUFACTURER WAS AWARE OF THIS PROBLEM. THE CONSUMER FOUND ON THE INTERNET THAT A TECHNICAL SERVICE BULLETINS WAS SENT OUT ON FEBRUARY 2, 2002 DISCUSSING THIS PROBLEM. HOWEVER, THE CONSUMER WAS UNAWARE OF THE TECHNICAL SERVICE BULLETIN. *AK

NHTSA ID

10139300

Incident

Feb 1, 2005

UPPER INTAKE MANIFOLD ON MY 1997 4.6 L THUNDERBIRD CRACKED AND BLEW ALL THE COOLANT INTO THE ENGINE COMPARTMENT. I HAD TO PAY FORD TO REPLACE THE UPPER INTAKE AND THE PLUGS THAT WERE FOULED OUT. THEY REFUSED ANY RESPONSIBILITY EVEN WITH A FORMAL WRITTEN COMPLAINT TO THEIR HOME OFFICE. IT IS MY UNDERSTANDING THIS IS HAPPENING TO A LOT OF THEIR 4.6 L ENGINES IN A VARIETY OF VEHICLES.*JB

NHTSA ID

10135684

Incident

May 1, 2005

Mileage

98,000 mi

TO WHOM IT MAY CONCERN! MY 1997 FORD THUNDERBIRD IS NOT LISTED WHY? I HAVE A LOT OF PROBLEMS WITH THE SMOG STUFF EVERY YEAR I PAY A LOT OF MONEY. WHEN TEMPERATURES ARE HOT OUTSIDE OVER 90 THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE, OR WHEN I GO UP A LONG HILL AND MY CAR OVERHEATS THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE AND IT IS ALWAYS ABOUT AN OXYGEN SENSOR OR OTHER SMOG RELATED ITEMS THAT ALWAYS COST $300 TO $650 I AM GOING B BROKE BEING ON A FIXED INCOME. FORD CAN'T FIX MY FRONT END VIBRATION I HAD ALL ALIGNMENTS DONE WHEEL BALANCING 4 TIMES NOTHING HELPS. MY STEERING WHEEL VIBRATES ALSO. PLEASE HELP! MANFRED GAUER . *JB

NHTSA ID

10130641

Incident

Jul 22, 2005

Mileage

33,573 mi

WHILE DRIVING APPROXIMATELY 40 MPH CONSUMER HEARD A NOISE, THEN WATER SPILLED FROM THE ENGINE. VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE, AND IT WAS DETERMINED THAT INTAKE MANIFOLD CRACKED. *AK

NHTSA ID

10115359

Incident

Mar 3, 2005

VEHICLE WOULD NOT HOLD ANY RADIATOR FLUID,CAUSING THE TEMPERATURE GAUGE TO RISE. TRIED TO REFILL THE RADIATOR FLUID, BUT 5 MINUTES LATER IT RAN OUT. COULD NOT DRIVE VEHICLE. TOOK THE VEHICLE TO MY MECHANIC,WHO TOLD ME THAT THE INTAKE MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. HE REPLACED THE INTAKE MANIFOLD,SO THE I WOULD BE ABLE TO DRIVE THE VEHICLE.

NHTSA ID

10110043

Incident

May 26, 2004

Mileage

120,811 mi

ENGINE FRONT COVER GASKET FAILED IN LINE WITH RECALL 99B29. FORD DOES NOT INCLUDE MY CAR BUILT 04/97 IN RECALL CAMPAIGN 99B29 INDICATING THE ORIGINAL RECALL HAS BEEN INADEQUATE. *AK

NHTSA ID

10108212

Incident

Dec 12, 2004

Mileage

50,090 mi

THE INTAKE MANIFOLD CRACKED, LOSS OF ALL ANTIFREEZE AND VEHICLE BEING TOWED TO DEALERSHIP. VEHICLE ONLY HAS 60,000 MILES ON. THE LETTER FROM FORD TO REPLACE THIS EXPIRED IN MAY 2004! I HAD COMPLAINED TO MY DEALERSHIP ABOUT LOSS OF ANTIFREEZE, GAS, THEY FOUND NO PROBLEMS. OF COURSE, NOW I HAVE TO PAY FOR THE ENTIRE REPAIR. EVEN THOUGH I SEE THAT MANY T-BIRD OWNERS ARE HAVING THE EXACT PROBLEM. THIS SHOULD HAVE BEEN A MANDATORY RECALL FROM FORD. BECAUSE EXISTING PROBLEMS ARE BEING REPORTED!*AK

NHTSA ID

10093009

Incident

Sep 19, 2004

Mileage

60,000 mi

THE INTAKE MANIFOLD WAS DEFECTIVE. ALL OF THE COOLANT LEAKED AND SUBSEQUENTLY THE VEHICLE WAS TOWED. THE DEALER STATED THE DEFECT WAS OUTSIDE OF THE SEVEN YEARS OF THE ORIGINAL RECALL. *JB

NHTSA ID

10091450

Incident

Aug 30, 2004

Mileage

65,490 mi

CRACKED INTAKE ON MY 97 T BIRD. *JB

NHTSA ID

10088358

Incident

Aug 19, 2004

Mileage

67,452 mi

ENGINE MANIFOLD CRACKED ALLOWING ANTIFREEZE TO ESCAPE. TOOK CAR FOR REPAIR. LEARNED LATER THAT REPAIR WAS A RECALL. ASKED FORD FOR REIMBURSEMENT. REIMBURSMENT DENIED.*AK

NHTSA ID

10086956

Incident

Jul 31, 2001

Mileage

62,365 mi

I AM THE ORIGINAL OWNER OF A 1997 FORD THUNDER BIRD WITH THE 4.6 ENGINE. THE INTAKE MANIFOLD IS CRACKED . I HAVE BEEN INFORMED THIS IS A RECALLED PART ON SOME CARS BUT IT SEEMS MY CAR IS NOT INCLUDED IN THE RECALL. THE ORIGINAL REPAIR PART IS NOT AVAILABLE ANY LONG DO TO THE FLAW. SINCE THIS IS THE CASE IT WOUD SEEM TO ME ALL VEHICLES WITH THIS INTAKE MANIFOLD WOULD BE INCLUDED IN THE RECALL. *AK

NHTSA ID

10080637

Incident

Jul 1, 2004

Mileage

80,000 mi

I WAS DRIVING MY CAR TO PAY THE POWER BILL. I HAD MADE A COMPLETE STOP AND THEN TURNED LEFT UP THE ROAD ABOUT 4/10'S OF A MILE WHEN I PULLED INTO THE PARKING SPACE I NOTICED WHITE STEAM COMING FROM THE ENGINE COMPARTMENT. I OPENED THE HOOD A THE ENGINE WAS COVERED IN ANTIFREEZE. I CALLED FOR A TOW HOPING IT WAS A BLOWN HOSE OR AT WORST A HEAD GASKET. SO I DIDN'T DRIVE IT FURTHER TO PREVENT FURTHER DAMAGE. THE DEALERSHIP LOOKS AT IT AND SAYS IT IS A CRACKED INTAKE MANIFOLD. WHICH LEADS TO A $1135 BILL FOR PARTS AND LABOR. SOME ONLINE RESEARCH BROUGHT A CONCERN...IS THE INTAKE MANIFOLD PLASTIC? IF SO, WHY!? *NM

NHTSA ID

10080486

Incident

Jul 6, 2004

Mileage

70,600 mi

REQUEST FOR REIMBURSEMENT FOR REPLACEMENT OF THE INTAKE MANIFOLD. *MR THE CONSUMER WAS TOLD THAT THE MANIFOLD WOULD ONLY BE REPLACED UPON FAILURE. THE VEHICLE HAD BEEN LOSING ANTIFREEZE. EACH TIME THE VEHICLE WAS TAKEN TO THE DEALER, HE WAS TOLD THAT EVERYTHING WAS FINE. THE MANIFOLD FINALLY FAILED AND WAS OUT OF WARRANTY. THE DEALER WOULD NOT HONOR THE OPEN RECALL. THE CHECK ENGINE LIGHT WAS INTERMITTENT DUE TO A BAD SENSOR. *SC *JB

NHTSA ID

10079862

Incident

Apr 22, 2004