2020 Ford Transit Connect Powertrain (other) Problems

Transmission failure in my 2.0L Ford Transit Connect at approximately 94,000 miles. When I shift into reverse, the van sometimes drives forward instead of backing up — as if the transmission is confused or stuck in the wrong gear. Over time, reverse completely stopped working altogether. Additionally, after coming to a full stop (such as at a red light), the van occasionally stalls or becomes unresponsive when pressing the gas pedal. This creates dangerous situations in traffic. All recommended maintenance has been done on time, including a full transmission flush performed by a Ford dealer at around 80,000 miles. There were no warning lights or error messages before the issue began. After researching, I found many other Transit Connect owners with the same problem, especially in models with the 2.0L engine. This points to a potential defect in the transmission system. A full transmission replacement may be necessary, and I believe Ford should issue a recall to address this recurring failure.

NHTSA ID

11674837

Incident

Jul 16, 2025

My 8F35 transmission failed at 95,000 miles, a new unit was put in and that transmission failed at about 175,000 miles, a new transmission was not put in for replacement, but was rebuilt by Ford and currently I have 185,000 miles and as I slow down the transmission starts to jerk and I am slammed forward in my seat. This transmission does this everyday, without fail. Just a matter of time before this transmission fails.This transmission is acting like the last 2 transmissions that failed.

NHTSA ID

11668747

Incident

Jun 23, 2025

2020 Ford Transit Connect with 80,000 miles. Wrench light came on dashboard and car experiences some shuddering and hesitation when going uphill.Warranty expired at 60K miles Dealer says that it is a power train issue and the transmission needs to be fully replaced. There was never any type of warning that the transmission. I did have a code for a EGR valve, which was replaced. Requested Ford Goodwill assistance to pay for this expensive repair but was denied and need to replace at full cost. Vehicle has been serviced every 5,000 miles at dealership. Supposedly transmission doesn't ever need servicing. There is no dipstick to check and when I asked when it needed fluid changed, I was told it didn't. Obviously that isn't true.

NHTSA ID

11585826

Incident

Apr 20, 2024

Powertrain fault Transmission torque converter clutch is not operating as expected. Transmission not shifting properly. Fixed many times and still same issue, now it needs new transmission.

NHTSA ID

11574808

Incident

Feb 2, 2023

Bad Torque Converter - There seems to be a systemic problem with this part on Ford Transits. Ford is not standing behind their parts so we need your help please.

NHTSA ID

11523180

Incident

May 9, 2023

The contact owns a 2019 Ford Transit Connect. The contact stated while driving 20 MPH, the transmission was shifting very rough. There was no warning light illuminated. The contact pulled over on the side of the road and had the vehicle towed to the dealer. The dealer stated that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer stated that the vehicle was not included in a recall regarding the failure. The contact was advised to contact the NHTSA Hotline for assistance. The failure mileage was 102,000.

NHTSA ID

11509576

Incident

Feb 20, 2023

Mileage

102,000 mi

The contact owns a 2020 Ford Transit Connect. The contact stated while driving 20-30 MPH, the message "Pro-Collision Assistant is Unable" was displayed. The accelerator pedal was depressed but the vehicle jerked and hesitated to respond. The contact veered to the side of the road and turned off the vehicle. Upon restarting the vehicle, the vehicle operated as needed and the contact continued driving. However, the failure reoccurred on four different occasions. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.

NHTSA ID

11483077

Incident

Apr 6, 2022

Mileage

15,000 mi

The contact owns a 2020 Ford Transit Connect. The contact received a notification for NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue and an appointment was scheduled for the recall repair. The contact arrived for the appointment but was informed that the appointment was canceled. The contact was informed to bring the vehicle back once he experienced the failure stated in the recall. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11481024

Incident

Jun 1, 2022

Three summers in a row now the transmission "overheats" causing warning lights and errors to pop up while driving, then going away. Sometimes disabling vehicle power altogether. When control does come back, transmission gear changes happen at the wrong rpm , stuttering the vehicle and making erratic driving behavior. Ford ignored my requests to investigate for two years, and now that it's out of warranty, tell me I need to pay them to install a brand new transmission

NHTSA ID

11478261

Incident

Jul 31, 2022

Transmission failed with only 17,000 miles (mostly highway) on the car. The car did not move forward from a parked location. It only moved in reverse. It had to be towed to the nearest dealership and when they examined it, it did not move in reverse either. Even though it is under warranty, the dealers are taking a long time to repair the car.

NHTSA ID

11451925

Incident

Feb 10, 2022