2020 Ford Transit Connect Problems

Transmission failure in my 2.0L Ford Transit Connect at approximately 94,000 miles. When I shift into reverse, the van sometimes drives forward instead of backing up — as if the transmission is confused or stuck in the wrong gear. Over time, reverse completely stopped working altogether. Additionally, after coming to a full stop (such as at a red light), the van occasionally stalls or becomes unresponsive when pressing the gas pedal. This creates dangerous situations in traffic. All recommended maintenance has been done on time, including a full transmission flush performed by a Ford dealer at around 80,000 miles. There were no warning lights or error messages before the issue began. After researching, I found many other Transit Connect owners with the same problem, especially in models with the 2.0L engine. This points to a potential defect in the transmission system. A full transmission replacement may be necessary, and I believe Ford should issue a recall to address this recurring failure.

My 8F35 transmission failed at 95,000 miles, a new unit was put in and that transmission failed at about 175,000 miles, a new transmission was not put in for replacement, but was rebuilt by Ford and currently I have 185,000 miles and as I slow down the transmission starts to jerk and I am slammed forward in my seat. This transmission does this everyday, without fail. Just a matter of time before this transmission fails.This transmission is acting like the last 2 transmissions that failed.

ABS Hydraulic control unit pump malfunction. vehicles brakes locked up on the highway and could of caused an accident. this is a known and common issue with these vans. this type of thing shouldnt happen my vehicle has only has 67,000 miles on it. I have seen other report this issue with less miles than that. vehicle is now having the unit replaced.

The brake pedal went down far and there was poor braking. The brake fluid was found to be leaking from the left front brake jounce hose. This was unsafe due to extended braking stop time and less braking ability. I am an ASE certified master technician and I work in a private vehicle fleet repair facility. I did not interview the driver if the BRAKE warning light came on but most likely it did due to brake fluid leaking fast from this line. We also had a failure of this type on a 2019 Ford Transit Connect which is also in our fleet. So it appears Ford has another problem with front brake jounce hose failures.

Intermittent Electronic issues are: 1) Rear view backup camera malfunction. Works sporadically. Camera some times clear as bell, and stays on when in drive moving forward. Other days camera fails to blue screen, then turns gray with message that camera is unavailable, contact dealership. Defect is not currently not listed for this vehicle as a recall. Definite safety hazard with camera staying on when vehicle is in drive and moving forward. 2) Auto start, stop feature was functioning when vehicle was purchased November of 2025, but as of April 2026, system began to turn itself on and off, no longer can be activated or deactivated via command button on console.

The contact owns a 2020 Ford Transit Connect. The contact stated that while his wife was driving at an undisclosed speed, the braking system erroneously activated causing the front driver side and the rear passenger side brakes to overheat and the vehicle to decelerate. The contact stated that after his wife exited the vehicle, she discovered smoke coming from the front driver’s side wheel well. Additionally, during the failure the Forward Collision Avoidance system warning light activated. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 28,000.

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving in a rainstorm, rainwater poured into the vehicle from the front passenger’s side windshield. The vehicle was taken to the local Satellite Auto Glass repair shop, and it was discovered that the front windshield adhesive had failed, causing the passenger’s side front windshield to become unsecured. The contact was advised that the windshield needed to be replaced. The vehicle was not yet repaired. The contact stated that several electrical features were damaged due to the water, including the audible warnings and 911 assist from the inoperable Bluetooth. The local dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 22V192000 (VISIBILITY). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 189,000.

Water leaking through front windshield. Internet shows there is a recall for improper adhesive of windshield on 2020 Transit Connect but when my 2020 Transit Connect VIN Nm0ls6e25l1446922. Was taken to Ford dealership they are advising there is no recall on my vehicle.

Powertrain fault Transmission torque converter clutch is not operating as expected. Transmission not shifting properly. Fixed many times and still same issue, now it needs new transmission.

While traveling at highway speed the vehicle suddenly and without any warning lost propulsion and died forcing the driver to pull over. As a result of how sudden the failure was the driver was just barely able to find a safe place to pull off the road. The vehicle would not start or run leaving the driver and his passengers stranded in the hot weather. This very easily could have resulted in an accident as the vehicle was going up hill on a mountain road with many curves. After taking the vehicle to the Ford dealership it was determined that the throttle body had failed suddenly and without warning. There were never any service lights that illuminated when the problem occurred. We are reporting so that there is a record in case this becomes a common issue with other vehicles of this type.

While traveling at highway speed the vehicle suddenly and without any warning lost propulsion and died forcing the driver to pull over. As a result of how sudden the failure was the driver was just barely able to find a safe place to pull off the road. The vehicle would not start or run leaving the driver and his passengers stranded in the hot weather. This very easily could have resulted in an accident as the vehicle was going up hill on a mountain road with many curves. After taking the vehicle to the Ford dealership it was determined that the throttle body had failed suddenly and without warning. There were never any service lights that illuminated when the problem occurred. We are reporting so that there is a record in case this becomes a common issue with other vehicles of this type.

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 12,000.

The contact owns a 2020 Ford Transit Connect. The contact stated that while driving at 65 MPH, the brakes locked up. After releasing the brake pedal, the vehicle began to shake abnormally. While driving, the power steering became inoperable. The Hill Assist, traction control, and steering assist became inoperable. The traction control warning light was illuminated. The contact is a former mechanic and determined that the ABS module hydraulic pump needed to be replaced. The vehicle was repaired, but the failure recurred. When the vehicle was taken to the independent mechanic, there were no codes displayed. The contact called the local dealer and was referred to the manufacturer and the NHTSA Hotline. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 68,000.

Intermittent Electronic issues are: 1) Rear view backup camera malfunction. Works sporadically. Camera some times clear as bell, and stays on when in drive moving forward. Other days camera fails to blue screen, then turns gray with message that camera is unavailable, contact dealership. Defect is not currently not listed for this vehicle as a recall. Definite safety hazard with camera staying on when vehicle is in drive and moving forward. 2) Auto start, stop feature was functioning when vehicle was purchased November of 2025, but as of April 2026, system began to turn itself on and off, no longer can be activated or deactivated via command button on console.