2024 Ford Transit Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Ford Transit, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure618.2%
- Other / unspecified412.1%
- Electrical39.1%
- Engine39.1%
- Tires & wheels39.1%
- Driver assistance39.1%
- Powertrain (other)39.1%
- Seat belts26.1%
- Exterior lighting13.0%
- Brakes13.0%
- Fuel system13.0%
- Airbags13.0%
- Steering13.0%
- Suspension13.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Fuel filler door hinges continues to break and the consumer has to pay for a new housing unit. The hinges can break at anytime and the fuel door can become a potential issue while driving. It can break all the way off and hit another vehicle while traveling on the road/ Highway. The problem has been confirmed by the dealerships as they always have back-stock of new units to replace. There is no warning as to when it breaks at all.
A car dealership sold me a brand new vehicle that had an open recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The rear axle snapped and rear tire separated and rolled behind vehicle on the expressway causing the potential for injury/fatalities to our driver and surrounding passenger vehicles by recall 24S05. At no point did we receive communication from Ford that the vehicle should not be operated. We scheduled the recall repairs for next week, 5/4/26 however this morning, 5/1/26 the rear axle snapped and the tire fell off of the vehicle. The vehicle has been towed to Roche Ford in Bensenville for repairs. The recall has been well documented and has thus far caused 285 incidents and 1 accident prior to our issue this morning. There were no indicator lights or messages to indicate an issue.
See the attached video..the car was not serviced before..this the assembly factory negligence..they didn't secure the nodes properly
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
On March 11, 2026, a 2024 Ford Transit (VIN: [XXX] ) was being operated under normal driving conditions when the check engine light began intermittently activating. Shortly thereafter, the vehicle experienced a sudden loss of dashboard functionality. While attempting to safely maneuver to the shoulder, the operator experienced loss of power steering and reduced braking capability. During this time, flames were observed originating from the engine compartment. The operator was able to safely pull the vehicle over, exit, and contact emergency services. The vehicle subsequently became fully engulfed in flames and was completely destroyed. No injuries were reported. A preliminary fire investigation determined the area of origin to be the passenger side of the engine compartment, with evidence of possible electrical involvement. The specific failed component has not yet been identified. This incident created a significant safety hazard due to the sudden loss of vehicle control systems combined with an active vehicle fire during operation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Purchased this new vehicle from the dealer and while driving from the dealership to my business, I heard a loud bang and the vehicle caught fire.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
On March 11, 2026, a 2024 Ford Transit (VIN: [XXX] ) was being operated under normal driving conditions when the check engine light began intermittently activating. Shortly thereafter, the vehicle experienced a sudden loss of dashboard functionality. While attempting to safely maneuver to the shoulder, the operator experienced loss of power steering and reduced braking capability. During this time, flames were observed originating from the engine compartment. The operator was able to safely pull the vehicle over, exit, and contact emergency services. The vehicle subsequently became fully engulfed in flames and was completely destroyed. No injuries were reported. A preliminary fire investigation determined the area of origin to be the passenger side of the engine compartment, with evidence of possible electrical involvement. The specific failed component has not yet been identified. This incident created a significant safety hazard due to the sudden loss of vehicle control systems combined with an active vehicle fire during operation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Recall Action Soon Issue Since 07-18-2025 Rear camera screen software update For More Information
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2024 Ford Transit. The contact received notification of NHTSA Campaign Number: 24V226000 (Tires); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2024 Ford Transit The contact received notification of NHTSA Campaign Numbers: 24V226000 (Tires) and 24V591000 (Steering) however, the part to repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the remedy parts were not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
The contact owns a 2024 Ford Transit. The contact received notification of NHTSA Campaign Number: 25V315000 ( BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2024 Ford Transit. The contact stated that he was unable to rent the vehicle on Turo. The contact received information on NHTSA Campaign Number: 25V315000 (Back Over Prevention). The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was contacted; however, only a recorded message was available. The contact had not experienced a failure.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
On March 11, 2026, a 2024 Ford Transit (VIN: [XXX] ) was being operated under normal driving conditions when the check engine light began intermittently activating. Shortly thereafter, the vehicle experienced a sudden loss of dashboard functionality. While attempting to safely maneuver to the shoulder, the operator experienced loss of power steering and reduced braking capability. During this time, flames were observed originating from the engine compartment. The operator was able to safely pull the vehicle over, exit, and contact emergency services. The vehicle subsequently became fully engulfed in flames and was completely destroyed. No injuries were reported. A preliminary fire investigation determined the area of origin to be the passenger side of the engine compartment, with evidence of possible electrical involvement. The specific failed component has not yet been identified. This incident created a significant safety hazard due to the sudden loss of vehicle control systems combined with an active vehicle fire during operation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While traveling straight at approximately 30 miles per hour, the front differential locked, causing the front wheels to lock and abruptly stopped the vehicle. Vehicle was towed to a Ford dealership, which verified the differential failed, and not due to lack of lubricant. There were no symptoms prior to failure. The abruptness of the stop caused the operator to suffer whiplash like symptoms.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
Attempting to purchase a Midwest Automotive Designs, Patriot RV on Ford Transit chassis. The rear seat belts installed by the RV manufacturer for rear passenger seating have been removed but dealership refuses to replace them. The dealer is offering this vehicle for sale without required safety equipment. I believe this is a violation of DOT law ?
Recall Action Soon Issue Since 07-18-2025 Rear camera screen software update For More Information
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
We rented the Vehicle from ACE Rent A Car JFK location. The turn signals were not working. Hazards worked as normal. When inspected it is suspected an electrical issue with the cable connections caused them not to work. Google searches revealed similar issues on other car models.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
A car dealership sold me a brand new vehicle that had an open recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
The contact owns a 2024 Ford Transit. The contact stated that while driving at various speeds; an abnormal fuel odor would leak into the interior cabin, which caused health issues. In addition, the contact stated that while stopped around other vehicles in daily traffic, the exterior exhaust fumes would leak into the interior cabin of the vehicle. No warning lights illuminated. The contact sought medical attention for vomiting and severe dehydration due to a high carbon monoxide poisoning level of 2.6 as a non-smoker. Upon further inspection, the contact noticed a leak on the passenger side manifold and under the flexing coupling. The vehicle was taken to 3 separate dealers, where the vehicle was declined to be diagnosed. The vehicle was then towed to a local dealer, where it was diagnosed; however, no failures were identified. The manufacturer was made aware of the failure. The failure mileage was approximately 12,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
A car dealership sold me a brand new vehicle that had an open recall.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The contact owns a 2024 Ford Transit The contact received notification of NHTSA Campaign Numbers: 24V226000 (Tires) and 24V591000 (Steering) however, the part to repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the remedy parts were not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The rear axle snapped and rear tire separated and rolled behind vehicle on the expressway causing the potential for injury/fatalities to our driver and surrounding passenger vehicles by recall 24S05. At no point did we receive communication from Ford that the vehicle should not be operated. We scheduled the recall repairs for next week, 5/4/26 however this morning, 5/1/26 the rear axle snapped and the tire fell off of the vehicle. The vehicle has been towed to Roche Ford in Bensenville for repairs. The recall has been well documented and has thus far caused 285 incidents and 1 accident prior to our issue this morning. There were no indicator lights or messages to indicate an issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .