2026 Ford Transit Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2026 Ford Transit, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified342.9%
- Body & structure114.3%
- Brakes114.3%
- Electrical114.3%
- Suspension114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
On 04/14/2026, the second day after purchase.There was extreme vibration from the back of my vehicle at 40 -to- 45MPH and highway speeds 70-to-80MPH. after several service visits the vehicle still has vibration at 70 -to- 80MPH. At highway speeds there is so much vibration that window visors and seat arm rests are shaking. The Car Dealer ( ACE FORD of Woodbury ) did verify vibration during a "ride along" in person with a computer connected to the vehicle . After several attempts to balance tires. On 05/15 2026 we test drove other same "FORD Transit Vans 250" and found that all Vans were exhibiting same vibration . FORD determined that because all vehicles preform the same way that this was "deemed Characteristic"and no further action would be taken. At This point I brought the FORD TRANSIT to another Dealer ( WINNER FORD of Cherry Hill ) They preformed the same or similar diagnostics and found that ALL FOUR (4) tire rims were bent and indicated a replacement of the rims was required. I Then brought the TRANSIT back to ACE FORD where they did more testing and found that there was one (1) rim bent and replace tire and rim. After turning the vehicle back over to me I went on a test drive and found the same vibration problem at highway speeds form 72 - 80MPH . to date, I still have a VAN that I fell unsafe in at highway speeds.
!!!PLEASE MAKE A NATIONAL BROADCAST!!!: "Do not drive - brake booster pushrod cotter pin inspection" Recall incomplete Do not drive your vehicle until your recall service is complete. The dealer might be able to complete the free service at your location or you can get your vehicle towed to a dealer.Description On your vehicle, it may be possible for the brake booster pushrod to separate from the brake pedal due to a missing cotter pin. Safety Risk This may result in a loss of braking function while driving, increasing the risk of a crash. Remedy Do not drive your vehicle until the vehicle passes the inspection or the repair has been performed. Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to inspect for the presence of the cotter pin and a redundant clip, replacing either, or both if necessary. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
On 04/14/2026, the second day after purchase.There was extreme vibration from the back of my vehicle at 40 -to- 45MPH and highway speeds 70-to-80MPH. after several service visits the vehicle still has vibration at 70 -to- 80MPH. At highway speeds there is so much vibration that window visors and seat arm rests are shaking. The Car Dealer ( ACE FORD of Woodbury ) did verify vibration during a "ride along" in person with a computer connected to the vehicle . After several attempts to balance tires. On 05/15 2026 we test drove other same "FORD Transit Vans 250" and found that all Vans were exhibiting same vibration . FORD determined that because all vehicles preform the same way that this was "deemed Characteristic"and no further action would be taken. At This point I brought the FORD TRANSIT to another Dealer ( WINNER FORD of Cherry Hill ) They preformed the same or similar diagnostics and found that ALL FOUR (4) tire rims were bent and indicated a replacement of the rims was required. I Then brought the TRANSIT back to ACE FORD where they did more testing and found that there was one (1) rim bent and replace tire and rim. After turning the vehicle back over to me I went on a test drive and found the same vibration problem at highway speeds form 72 - 80MPH . to date, I still have a VAN that I fell unsafe in at highway speeds.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
!!!PLEASE MAKE A NATIONAL BROADCAST!!!: "Do not drive - brake booster pushrod cotter pin inspection" Recall incomplete Do not drive your vehicle until your recall service is complete. The dealer might be able to complete the free service at your location or you can get your vehicle towed to a dealer.Description On your vehicle, it may be possible for the brake booster pushrod to separate from the brake pedal due to a missing cotter pin. Safety Risk This may result in a loss of braking function while driving, increasing the risk of a crash. Remedy Do not drive your vehicle until the vehicle passes the inspection or the repair has been performed. Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to inspect for the presence of the cotter pin and a redundant clip, replacing either, or both if necessary. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
!!!PLEASE MAKE A NATIONAL BROADCAST!!!: "Do not drive - brake booster pushrod cotter pin inspection" Recall incomplete Do not drive your vehicle until your recall service is complete. The dealer might be able to complete the free service at your location or you can get your vehicle towed to a dealer.Description On your vehicle, it may be possible for the brake booster pushrod to separate from the brake pedal due to a missing cotter pin. Safety Risk This may result in a loss of braking function while driving, increasing the risk of a crash. Remedy Do not drive your vehicle until the vehicle passes the inspection or the repair has been performed. Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to inspect for the presence of the cotter pin and a redundant clip, replacing either, or both if necessary. Next Steps Contact your dealer for more information to schedule the free service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
On 04/14/2026, the second day after purchase.There was extreme vibration from the back of my vehicle at 40 -to- 45MPH and highway speeds 70-to-80MPH. after several service visits the vehicle still has vibration at 70 -to- 80MPH. At highway speeds there is so much vibration that window visors and seat arm rests are shaking. The Car Dealer ( ACE FORD of Woodbury ) did verify vibration during a "ride along" in person with a computer connected to the vehicle . After several attempts to balance tires. On 05/15 2026 we test drove other same "FORD Transit Vans 250" and found that all Vans were exhibiting same vibration . FORD determined that because all vehicles preform the same way that this was "deemed Characteristic"and no further action would be taken. At This point I brought the FORD TRANSIT to another Dealer ( WINNER FORD of Cherry Hill ) They preformed the same or similar diagnostics and found that ALL FOUR (4) tire rims were bent and indicated a replacement of the rims was required. I Then brought the TRANSIT back to ACE FORD where they did more testing and found that there was one (1) rim bent and replace tire and rim. After turning the vehicle back over to me I went on a test drive and found the same vibration problem at highway speeds form 72 - 80MPH . to date, I still have a VAN that I fell unsafe in at highway speeds.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .