2022 Forest River Rockwood Problems

Spare tire attached by cable underneath camper came loose and was bouncing around on road while still attached to spare tire cable. I had tightened up the spare tire cable prior to our 95 mile trip home, but the cable unwound while traveling until the spare tire started bouncing on road. Fortunately we heard the noise before too much damage was done and we were fortunate the tire didn't come off and become a road hazard to anyone following us. I see on multiple social media postings where this is a known problem with other Geo Pro campers and should be fixed by Forest River through a recall due to the risk of the issue.

There was a fire that was created with the factory installed wiring that initiated at the shore power connection where one of the 50 amp wires was loose, heated up, melted the surrounding area and started a fire.

I am reporting a safety defect on a 2022 Forest River Rockwood Mini Lite travel trailer, model 2516S, This RV is equipped with Dexter axle #1 and #9 from a total batch of #288 axles that Forest River recalled on July 27, 2022 under NHTSA recall 22V-558. The RV was purchased on July 15, 2022, twelve days before the recall. Of the 244 recalled RVs with those axles, only the single-axle tent campers were recalled because the defect was visually obvious on those units. On tandem-axle RVs such as this one, the incorrect installation was not visually apparent. This travel trailer was manufactured with brake axle defects and buyers of these units were never contacted. It does not take an engineering analysis to conclude that if axle #1 and #9 from this batch are defective and 244 RVs were recalled, then all 288 axles should have been inspected and included in the recall. The brakes are significantly ineffective in forward motion, causing complete brake failure under normal braking. This is an active safety hazard. There is serious concern that the remaining 44 axles from this batch were placed on tandem-axle RVs and released into commerce without notification, despite the fact that I have not changed my phone number, address, or email since purchasing this trailer. This is a one-owner, low-mileage unit that has never been serviced or altered. Attempts to resolve this issue through Forest River representative dealerships, Dexter Axles, and Forest River have been ongoing for three months with no resolution. No repairs have been made. The trailer is currently being towed over 1,300 miles to Montana for work with defective brakes. Multiple photos have been attached clearly showing the incorrect brake installation. Please investigate this latent manufacturing defect and consider expanding the recall to include these excluded axles.

The transmission failed on our 2019 Subaru Touring Ascent. Also, the Bluetooth brake system for pulling our trailer was losing electrical contact as it wobbled on and off. We tried to remedy this blue tooth situation before our last journey with the Camping World dealership who sold us the trailer, but it still was not connecting properly . We were put at risk and others were put at risk because the blue tooth wireless brakes were not functioning correctly. The trailer swaying into a traffic lane also put us and others at risk. The Subaru Ascent can not tow this 2022 GeoPro trailer safely. We were told by various salesmen that it could. The service manager at the Subaru dealer confirmed that this trailer is indeed too heavy for the 2019 Ascent touring model. There is excess forward weight on the drivers side causing the trailer to pull to the left due to the extra weight of the side out and the 60 gallon water tank even when using a:sway bar. We had no warning lights prior to the failure.

Spare tire attached by cable underneath camper came loose and was bouncing around on road while still attached to spare tire cable. I had tightened up the spare tire cable prior to our 95 mile trip home, but the cable unwound while traveling until the spare tire started bouncing on road. Fortunately we heard the noise before too much damage was done and we were fortunate the tire didn't come off and become a road hazard to anyone following us. I see on multiple social media postings where this is a known problem with other Geo Pro campers and should be fixed by Forest River through a recall due to the risk of the issue.

Spare tire. ST205/75R14. Performing a walk around inspection of my camper and noticed a large Bulge under the tire cover on my spare tire. Removed tire cover and photographed the strange occurrence. This tire has been covered and unused since purchased with new camper.

There was a fire that was created with the factory installed wiring that initiated at the shore power connection where one of the 50 amp wires was loose, heated up, melted the surrounding area and started a fire.

The contact owns a 2022 Forest River Rockwood Trailer. The contact stated that upon purchase of the trailer; several, exposed electrical wires were left hanging from underneath the trailer. The contact also stated that the electrical winch that raised the canopy would remain active. The contact expressed concern that if the winch were to be hit from the outside the trailer, severe damage could be caused to the trailer. The manufacturer had been notified about the failure but had offered no assistance. The vehicle had yet to be repaired. The failure mileage was 0.

The contact owns a 2022 Forest River Rockwood Trailer. The contact stated that while attempting to extend the slide-out, the slide-out became stuck and became inoperable. The RV was taken to an independent mechanic where it was diagnosed with a missing Z-bracket. The contact stated that the column became bent due to the missing Z-bracket. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2022 Forest River Rockwood. The contact stated that while the RV was parked, there was a short circuit causing the RV to catch fire from the inside. The fire marshals extinguished the fire. There was a police report filed. There were no injuries. The RV was taken to a dealer, where it was diagnosed with electrical system failure. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was unknown.

The transmission failed on our 2019 Subaru Touring Ascent. Also, the Bluetooth brake system for pulling our trailer was losing electrical contact as it wobbled on and off. We tried to remedy this blue tooth situation before our last journey with the Camping World dealership who sold us the trailer, but it still was not connecting properly . We were put at risk and others were put at risk because the blue tooth wireless brakes were not functioning correctly. The trailer swaying into a traffic lane also put us and others at risk. The Subaru Ascent can not tow this 2022 GeoPro trailer safely. We were told by various salesmen that it could. The service manager at the Subaru dealer confirmed that this trailer is indeed too heavy for the 2019 Ascent touring model. There is excess forward weight on the drivers side causing the trailer to pull to the left due to the extra weight of the side out and the 60 gallon water tank even when using a:sway bar. We had no warning lights prior to the failure.

I am reporting a safety defect on a 2022 Forest River Rockwood Mini Lite travel trailer, model 2516S, This RV is equipped with Dexter axle #1 and #9 from a total batch of #288 axles that Forest River recalled on July 27, 2022 under NHTSA recall 22V-558. The RV was purchased on July 15, 2022, twelve days before the recall. Of the 244 recalled RVs with those axles, only the single-axle tent campers were recalled because the defect was visually obvious on those units. On tandem-axle RVs such as this one, the incorrect installation was not visually apparent. This travel trailer was manufactured with brake axle defects and buyers of these units were never contacted. It does not take an engineering analysis to conclude that if axle #1 and #9 from this batch are defective and 244 RVs were recalled, then all 288 axles should have been inspected and included in the recall. The brakes are significantly ineffective in forward motion, causing complete brake failure under normal braking. This is an active safety hazard. There is serious concern that the remaining 44 axles from this batch were placed on tandem-axle RVs and released into commerce without notification, despite the fact that I have not changed my phone number, address, or email since purchasing this trailer. This is a one-owner, low-mileage unit that has never been serviced or altered. Attempts to resolve this issue through Forest River representative dealerships, Dexter Axles, and Forest River have been ongoing for three months with no resolution. No repairs have been made. The trailer is currently being towed over 1,300 miles to Montana for work with defective brakes. Multiple photos have been attached clearly showing the incorrect brake installation. Please investigate this latent manufacturing defect and consider expanding the recall to include these excluded axles.

Nothing happened. My complaint is the inactivity and not resolving recall #22V243 on a propane connector on my RV that can leak and cause an explosion. I received the notice 4 months ago and I'm told there are no parts available when Forest river is pumping out new trailers every hour. This is ridiculous!