RoadVitals

2011 Freightliner Argosy

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Feb 23, 2011
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2011 Freightliner Argosy. 1 safety recall has been issued covering this model year; and 164 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
11V109000

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

Feb 23, 2011
4,977 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 ARGOSY, CASCADIA, AND CORNOADO HEAVY TRUCKS MANUFACTURED FROM JANUARY 4, 2010, THROUGH NOVEMBER 30, 2010, EQUIPPED WITH 40K AIRLINER SUSPENSIONS. THE REAR SUSPENSION MAY FRACTURE THROUGH THE CENTER BOLT HOLE AFTER VEHICLE ASSEMBLY.
The risk: IF UNDETECTED, OVER TIME THE REAR END OF THE SPRING MAY SEPARATE FROM THE VEHICLE CAUSING A HAZARDOUS ROAD DEBRIS SITUATION, INCREASING THE RISK OF A CRASH.
The remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE MONO LEAF SPRINGS FREE OF CHARGE. DAIMLER TRUCKS WILL SEND AN INTERIM LETTER TO OWNERS INFORMING THEM OF THE RECALL. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 5, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-589View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

WI21-009

ENGINE AND ENGINE COOLING

Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.

WI21-008

EQUIPMENT

Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.

SB35-036

POWER TRAIN

Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.

SB54-278

ELECTRICAL SYSTEM; EQUIPMENT

Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter® is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.

SB35-036

EQUIPMENT; POWER TRAIN

Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.

SB54-327

BACK OVER PREVENTION; ELECTRICAL SYSTEM

Service Bulletin for Lengthening the Backup Light Harness. Though the backup light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Freightliner Argosy by model year
YearComplaintsRecallsInvestigationsIssue Index
2020000—
2019000—
2018000—
2017000—
2016000—
2015010—
2014030—
2013000—
2012000—
2011Viewing010—
2010020—
2009010—
2008061—
2007051—
2006051—
2005140—
2004020—
2003020—
2002000—
2001020—
2000070—
1999090—
1998060—
1997010—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.