RoadVitals

2011 Freightliner Business Class M2 106V

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest May 18, 2011
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2011 Freightliner Business Class M2 106V. 2 safety recalls have been issued covering this model year; and 117 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
11V289000

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

May 18, 2011
2,342 units potentially affected
The defect: DTNA IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2, AND CORONADO, MODEL YEAR 2011-2012 CASCADIA VEHICLES EQUIPPED WITH FONTAINE ULTRA LT FIFTH WHEELS AND MANUFACTURED FROM APRIL 7, 2010, THROUGH MARCH 7, 2011. DURING THE COUPLING PROCESS ON VEHICLES EQUIPPED WITH PRE-MODIFICATION FONTAINE ULTRA LT FIFTH WHEELS, IT IS POSSIBLE FOR THE DRIVER TO PARTIALLY CLOSE THE FIFTH WHEEL LOCK, AND IF RELYING ON A TUG TEST (PULL TEST), AND NOT PERFORMING THE REQUIRED VISUAL INSPECTION, THINK THAT THE FIFTH WHEEL LOCK IS PROPERLY COUPLED TO THE TRAILER KING PIN, WHEN IN FACT, IT IS NOT.
The risk: IF THE TRACTOR IS NOT FULLY CONNECTED TO THE TRAILER, THE TRAILER MAY DISENGAGE WHILE IN USE, INCREASING THE RISK OF A CRASH.
The remedy: FONTAINE NOTIFIED OWNERS IN FEBRUARY 2011, AND IS HANDLING THE REMEDY FOR THIS CAMPAIGN. FONTAINE IS IN THE PROCESS OF RETROFITTING ALL AFFECTED VEHICLES, FREE OF CHARGE. OWNERS MAY CONTACT FONTAINE AT 1-800-874-9780 OR DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-608View on NHTSA.gov
11V160000

EXTERIOR LIGHTING:HEADLIGHTS

Mar 10, 2011
301 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2 106V INCOMPLETE CHASSIS CAB VEHICLES, MANUFACTURED FROM JULY 19, 2010, THROUGH JANUARY 14, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE HEADLIGHTS ON SOME VEHICLES MAY HAVE BEEN INSTALLED MORE THAN 54" FROM THE ROAD SURFACE.
The risk: HEADLIGHTS INSTALLED AT HEIGHTS OUTSIDE OF THE PARAMETERS SET BY THE SAFETY STANDARD MAY NOT FULLY ILLUMINATE ROAD SURFACES OR MAY INHIBIT THE ABILITY OF MOTORISTS TO SEE VEHICLES INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT THE HEADLAMP HEIGHT AND REPLACE ANY NONCONFORMING HEADLIGHTS WITH NEW HEADLIGHTS THAT LOWER THE BULB CENTER SUCH THAT THE HEADLIGHTS MEET THE SAFETY STANDARD FREE OF CHARGE. AN INTERIM LETTER WAS SENT TO OWNERS ON JUNE 1, 2011. THE NOTIFICATION LETTER TO NOTIFY OWNERS THAT THE REMEDY IS NOW AVAILABLE WAS MAILED ON OCTOBER 10, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-592View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

18SP725Rev

ENGINE; EQUIPMENT; FUEL SYSTEM, DIESEL

This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.

19TS-6

ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; FUEL SYSTEM, DIESEL

The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.

19-008WI

EQUIPMENT

Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.

19-009WI

STRUCTURE

Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers

17-029

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Computer Hook-Up Standard Diagnostic Time Update

17CSA25

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

17CSA25 New Method for Uploading Diagnostic Log Files to the CSC

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Freightliner Business Class M2 106V by model year
YearComplaintsRecallsInvestigationsIssue Index
2011Viewing020—
2009000—
2008110—
2007011—
2006210—
2005020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.