1997 Freightliner Business Class Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Freightliner Business Class, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Brakes150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
REAR PASSENGER DOORS OF FREIGHTLINER "BUSINESS CLASS" TRUCK COME UNLATCHED AND OPEN UP DURING OPERATION DOWN THE ROAD. THERE ARE ALSO INCIDENTS OF THE TRUCKS PARKING AT CERTAIN ANGLES WHERE THE DOORS WILL NOT OPEN UP AT ALKL. THIS HAPPENS ON BOTH FL80 CHASSIED FIRE TRUCKS. CRACKS IN THE ROOF STRUCTURE HAVE BEEN IDENTIFIED BY FREIGHTLINER AS A POSSIBLE ISSUE. WE ARE TRYING TO FIGURE OUT IF THIS IS A FREIGHTLINER OR E1 PROBLEM. THE ISSUES HAVE BEEN GOING ON SINCE BOTH TRUCKS WAS 5 YEARS OLD. SEVERAL DOOR LATCH ASSEMBLIES HAVE BEEN PURCHASED OVER THE YEARS IN AN ATTEMPT TO RESOLVE THE PROBLEM, WITH NO SUCCESS. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
LOSS OF HYDRAULIC BRAKE PADS, LOCKED UP CALIPERS, ACTUAL LOSS OF WHEEL CALIPERS WHEN BACKING UP, INCONSISTANT BRAKE WEAR, EQUALIZER WARNING SWITCH N/A FOR MASTER CYLINDER, DATE LISTED IS FIRST OCCURANCE, ALMOST WENT OVER STEEP 40 FOOT DROPOFF DUE TO SWITCH N/A IN MOUNTAINS ON SLICK ROAD. *NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .