2013 Freightliner Cascadia Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2013 Freightliner Cascadia, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes228.6%
- Electrical228.6%
- Driver assistance114.3%
- Engine114.3%
- Fuel system114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
FRONT AIR BRAKE CHAMBERS - CRACKS DEVELOPING AND EXPANDING NEAR MOUNTING BRACKET REQUIRING REPLACEMENT BEFORE BREAKING FREE RESULTING IN LOSS OF BRAKES. CRACKS FORMED TOP AND BOTTOM OF CAN WHERE ATTACHED TO MOUNTING BRACKET. NO AIR LEAKS DETECTED. HALDEX HDX127240011
TL* THE CONTACT OWNS A 2013 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT THE J-BRAKE AND TRAILER BRAKE ERRONEOUSLY ENGAGED. THE CONTACT ALSO MENTIONED THAT THE BRAKES INTERMITTENTLY FAILED TO RESPOND TO DECELERATION ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE ON GUARD SYSTEM HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 265,000. UPDATED 7/31/14*CN *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
OCCURRING BOTH STATIONARY AND WHILE IN MOTION WHENEVER KEY IS TURNED ON. LEFT AND RIGHT UPPER VISOR LIGHTS WHILE THE OTHER 3 REMAIN OFF, DASH LIGHTS TURN ON AND OFF. SOME GAUGES NOT FUNCTIONING. HEADLIGHTS REMAIN ON WHILE KEY IN IGNITION REGARDLESS OF IF LIGHT SWITCH IS ON. EMERGENCY POWER SYSTEM FLUCTUATES ON AND OFF.
THE CAB READING LIGHTS NOT FUNCTIONING, DASHBOARD LIGHTS MALFUNCTION OR NOT WORKING. THEY STOP FUNCTIONING WHILE VEHICLE WAS STATIONARY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2013 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS WITH THE CRUISE CONTROL ON, THE ON GUARD COLLISION SAFETY SYSTEM ENGAGED AND CAUSED THE VEHICLE TO SUDDENLY STOP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 1,800 AND THE CURRENT MILEAGE WAS 225,546.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2013 FREIGHTLINER CASCADIA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND THE VEHICLE'S COMPUTER WAS ACTIVATED BY ROADSIDE ASSISTANCE. THE VEHICLE WAS DRIVEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REGENERATION SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 414,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2013 Freightliner diesel fuel cause fire, destroy the unit completely to the ground... Very first load with this truck...Truck was inspected by dealer (Penski) truck and release by truck dealer Fontana CA. Driver was fortunate to jump out of cab to safety .......He indicated truck was running normal no sign of warning lights...
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .