2022 Freightliner Cascadia Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Freightliner Cascadia, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance642.9%
- Brakes535.7%
- Electrical17.1%
- Engine17.1%
- Other / unspecified17.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
ABS system is shutting causing all safety systems to shut down including cruise control. Freightliner is overlaying the harness for abs sensors at the owners expense. There should be a recall for them to fix this issue. They are very aware of what's going on and are doing nothing to fix the issue.
The contact owns a 2022 Freightliner Cascadia. The contact received notification of NHTSA Campaign Number: 22V817000 (Service Brakes, Air, Forward Collision Avoidance) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, the Axiomatic Braking System independently activated. The failure had occurred approximately 15 times and occurred intermittently. The contact took the vehicle to the dealer who confirmed that it was a known issue. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the issue. The approximate failure mileage was 115,629. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The contact owns a 2022 Freightliner Cascadia. The contact received notification of NHTSA Campaign Number: 22V817000 (Service Brakes, Air, Forward Collision Avoidance) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, the Axiomatic Braking System independently activated. The failure had occurred approximately 15 times and occurred intermittently. The contact took the vehicle to the dealer who confirmed that it was a known issue. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the issue. The approximate failure mileage was 115,629. Parts distribution disconnect.
The contact owns a 2022 Freightliner Cascadia. The contact stated while reversing at 10 MPH, the brake caliper seized and the two front driver’s side inside tires exploded. The vehicle was taken to the dealer and diagnosed with front brake modulator failure. The contact was informed that the front brake modulator valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that she had contacted the dealer and the manufacturer about the failure and was informed by the manufacturer that the VIN was included in NHTSA Campaign Number: 22V817000 (Service Brakes, Air, Forward Collision Avoidance) however, the dealer would not honor the recall repair. The failure mileage was approximately 201,285.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
ABS system is shutting causing all safety systems to shut down including cruise control. Freightliner is overlaying the harness for abs sensors at the owners expense. There should be a recall for them to fix this issue. They are very aware of what's going on and are doing nothing to fix the issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The flex flang behind the turbocharger has broken off. This lets the hot exhaust gases blow directly onto the underside of the cab and onto electrical wires. And other parts of the truck
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
Premature failure of TPMS sensors in 3 tires. Battery alert on them. Only 23,000 miles on vehicle
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .