RoadVitals

2004 Freightliner Century ST Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jul 16, 2007
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

07V302000

SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

Jul 16, 2007
75,000 units potentially affected
The defect: CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
The risk: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
The remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-504View on NHTSA.gov
05V285000

WHEELS:HUB

Jun 14, 2005
1,786 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.
The risk: THIS TAPER MAY CAUSE CRACKING OR FRACTURES OF THE FRONT HUB. THIS COULD CAUSE A CRASH WITHOUT PRIOR WARNING.
The remedy: AFTER FURTHER INVESTIGATION AND TESTING, FREIGHTLINER HAS REVISED THE POPULATION AND THE REMEDY (DECEMBER 22, 2005). THEREFORE, THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-451View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE08009ClosedPreliminary Evaluation

POWER STEERING PUMP FAILURES

Opened Feb 1, 2008
Closed Jul 3, 2008

ODI'S INVESTIGATION OF THE SUBJECT POWER STEERING PUMP HAS FOUND THAT, WITH OVER FIVE YEARS OF OPERATIONAL EXPOSURE, THERE HAVE BEEN NO PUMP FAILURES THAT RESULTED IN LOSS OF POWER STEERING ASSIST WHILE THE VEHICLE WAS BEING DRIVEN ON THE ROAD OR ANY SUDDEN DROP OFF IN THE POWER STEERING ASSIST AT ANY TIME.THERE ARE NO CRASHES OR INJURIES.THESE REDUCTION IN ASSIST EVENTS HAVE ONLY OCCURRED DURING BACKING OR PARKING MANEUVERS.FREIGHTLINER AND TRW APPEAR TO HAVE ACTED RESPONSIBLY IN PROVIDING INFORMATION TO CUSTOMERS AND DEALERS REGARDING SAFE MAINTENANCE AND REPAIR PROCEDURES FOR POWER STEERING PUMPS THAT HAVE EXPERIENCED A REDUCTION IN SPEED OF STEER.FREIGHTLINER'S FIELD SERVICE BULLETIN, FSB 46-38, IS A DIAGNOSTIC PROCEDURE FOR DETERMINING IF THE TRW POWER STEERING PUMP IS RESPONSIBLE FOR REDUCED POWER ASSIST AND DESCRIBES CORRECTIVE ACTIONS THAT SHOULD BE TAKEN ONCE THE DETERMINATION IS MADE.THE CORRECTIVE ACTIONS ARE:REPLACE THE SPOOL VALVE ASSEMBLY (VEHICLES BUILT PRIOR TO 1/1/05) OR, REPLACE THE POWER STEERING PUMP (VEHICLES BUILT AFTER 1/1/05).A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR MORE DETAILED INFORMATION SEE DOCUMENT FILE.

STEERING:HYDRAULIC POWER ASSIST:PUMP
PE06033ClosedPreliminary Evaluation

STEERING COLUMN WELD CRACKS

Opened Aug 30, 2006
Closed Jan 30, 2007

EARLY WARNING AGGREGATE DATA SUBMITTED TO NHTSA BY FREIGHTLINER SUGGESTS THAT A STEERING (EWR CODE 01) PROBLEM EXISTS FOR THE 2004 AND 2005 CENTURY AND COLUMBIA CLASS VEHICLES.THE COUNT OF FIELD REPORTS SUBMITTED FOR THE FIRST QUARTER OF 2006 WAS SIGNIFICANTLY HIGHER THAN THE AVERAGE OF THE PREVIOUS 6 QUARTERS FOR THE AGGREGATE STEERING DATA.FURTHER REVIEW OF THE EWR DATA FOUNDFIELD REPORTS THAT DESCRIBED STEERING COLUMN FAILURES AS A RESULT OF WELDS CRACKING OR BREAKING.INFORMATION RECEIVED FROM FREIGHTLINER DETAILS A NUMBER OF STEERING COLUMNFAILURES ON THE SUBJECT VEHICLES.THESE FAILURES WERE THE RESULT OF MISSING AND CRACKED WELDS ON THE STEERING COLUMN ASSEMBLY.AN ENGINEERING ANALYSIS (EA) IS WARRANTED TO DETERMINE IF THE WELD FAILURES IN THE STEERING COLUMN CREATE A SITUATION WHERE THE VEHICLE BECOMES DIFFICULT TO STEER OR STARTLES THE DRIVER PRESENTING A SAFETY RISK.

STEERING:COLUMN

Elsewhere on this vehicle

Data sources