RoadVitals

1998 Freightliner Century Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Mar 21, 2003
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

03V112000

SUSPENSION:FRONT:HUB

Mar 21, 2003
5,716 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
The risk: SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
The remedy: DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER CORPORATIONManufacturer number FL-407View on NHTSA.gov
00V232002

SERVICE BRAKES, AIR:ANTILOCK

Aug 7, 2000
35,405 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
The risk: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
The remedy: DEALERS WILL REPLACE THE ABS ECU.
FREIGHTLINER CORPORATIONManufacturer number FL-266View on NHTSA.gov
99V359000

STEERING:LINKAGES:TIE ROD ASSEMBLY

Dec 29, 1999
2,588 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE TIE ROD ENDS CAN FRACTURE DUE TO LOW STRESS, HIGH CYCLE, REVERSED BENDING FATIGUE RESULTING FROM A SYSTEM RESONANCE.
The risk: LOSS OF STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE TIE ROD ENDS AND TUBE ASSEMBLY.
FREIGHTLINER CORPORATIONManufacturer number FL-251View on NHTSA.gov
99V295000

SUSPENSION:FRONT:HUB

Oct 26, 1999
2,976 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE OUTBOARD BEARING ON THE STEERING AXLE HUBS CAN FAIL DUE TO WATER INTRUSION THROUGH A HUBCAP VENT.
The risk: THIS CONDITION CAN RESULT IN A SEPARATION OF THE WHEEL.
The remedy: DEALERS WILL REMOVE THE HUBCAP AND INSPECT FOR WATER INTRUSION AND CORROSION. THE HUB AND BEARING ASSEMBLY WILL BE REPLACED IF THERE IS EVIDENCE OF CORROSION. A NON-VENTED HUBCAP WILL BE INSTALLED.
FREIGHTLINER CORPORATIONManufacturer number FL-246View on NHTSA.gov
98V085000

SUSPENSION:FRONT

Apr 21, 1998
22,186 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR INTERAXLE DRIVELINE U-JOINTS. DEFLECTOR RINGS, A PART OF THE SYSTEM TO SEAL THE U-JOINTS FROM CONTAMINATES, ARE LOOSE. THIS ALLOWS WATER TO ENTER THE U-JOINT BEARING AREA RESULT IN DILUTION OF THE LUBRICANT, OXIDATION OF THE BEARING AND SEAL SURFACES, AND LOSS OF LUBRICANT.
The risk: IF THIS PROBLEM GOES UNDETECTED, THE INTERAXLE DRIVELINE CAN SEPARATE FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE U-JOINTS WITH THE CURRENT DESIGN U-JOINTS.
FREIGHTLINER CORPORATIONView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE03005ClosedPreliminary Evaluation

FRONT BRAKE AIR HOSE LEAKS

Opened Feb 7, 2003
Closed Aug 22, 2003

CERTAIN 1998-2001 FREIGHTLINER CENTURY AND COLUMBIA VEHICLES EXHIBIT A HIGHER RATE OF FRONT BRAKE AIR HOSE LEAKS THAN EARLIER VINTAGE FREIGHTLINER VEHICLES.THE LEAKS HAVE BEEN FREQUENTLY DISCOVERED AT FMCSA ROADSIDE INSPECTIONS SINCE THESE INSPECTIONS ARE CONDUCTED WITH THE BRAKES APPLIED (PRESSURIZING THE AIR HOSE) WHEREAS DRIVER PRE-TRIP INSPECTIONS MAY NOT ALWAYS BE PERFORMED WITH THE BRAKES APPLIED. AFTER A THOROUGH TECHNICAL REVIEW OF THIS MATTER,ODI HAS CONCUDED THAT WHILE THE SUBJECT VEHICLES EXHIBIT A HIGHER RATE OF FRONT BRAKE AIR HOSE LEAKS THAN EARLIER VINTAGE AND PEER VEHICLES, THESE LEAKS APPEAR TO BE MINOR. FREIGHTLINER HAS EXTENDED THE WARRANTY FOR THIS COMPONENT TO 5 YEARS, 500,000 MILES AND WILL ASSIST IN ALERTING THOSE VEHICLE OWNERS WHOSE VEHICLES ARE MOST SUSCEPTIBLE TO FRONT BRAKE AIR HOSE LEAKAGE BY ISSUING A SERVICE BULLETIN ALERTING THOSE OWNERS TO THE POTENTIAL FOR FRONT BRAKE AIR HOSE LEAKAGE TO OCCUR. SEE ATTACHED REPORT FOR FULL TECHNICAL DETAILS.

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
PE02088ClosedPreliminary Evaluation

INTEGRAL HUB AND BEARING ASSEMBLY

Opened Nov 22, 2002
Closed May 1, 2003

FREIGHTLINER SUBMITTED A DEFECT REPORT ON MARCH 21, 2003 IN WHICH THEY IDENTIFIED APPROXIMATELY 5000 TRUCKS AS POSSIBLY BEINGAFFECTED BY THIS PROBLEM.ARVINMERITOR (FRONT AXLE MFR) SUBMITTED A DEFECT REPORT ONAPRIL 16, 2003, WHICH IDENTIFIES 6098 FREIGHTLINER TRUCKS ASBEING AFFECTED BY THIS RECALL AND 1191 AXLES SOLD TO FREIGHTLINER IN THE AFTERMARKET. ODI NOTES THAT THERE ARE TWOINTEGRAL HUB AND BEARING ASSEMBLIES PER FRONT AXLE.FREIGHTLINER IDENTIFIED VEHICLES INCLUDINGFREIGHTLINER,STERLING, AND WESTERN STAR BRAND NAME AS BEINGAFFECTED BY THIS RECALL.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.

WHEELSLed to recall 03E019000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .