RoadVitals

1997 Freightliner FL80 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Feb 18, 2003
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Freightliner FL80, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Steering1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

PROBLEM: BALL STUD & SOCKET ASSEMBLY SEPARATED. REVIEW NHTSA #OOV-246.001 TRUCK: 1997 FREIGHTLINER, FL-80 - SERIAL # [XXX] IN-SERVICE DATE: MAY 9, 1997 - MILEAGE 76,389 THE STATE OF CONNECTICUT, DEPT. OF TRANS., HAS A LARGE NUMBER OF 1997 THRU 1999 FREIGHTLINER, FL-80 DUMP TRUCKS, USED FOR SNOW AND ICE REMOVAL. CANNOT RECEIVED THE NHTSA BULLETIN #00V-246-001 PERTAINING TO BALL STUD AND SOCKET ASSEMBLIES COMING APART. FREIGHTLINER SENT ONLY A FEW NOTICES PERTAINING VEHICLES IN OUR FLEET. NONE OF THEM INCLUDED THE LARGE NUMBER OF 1997 FREIGHTLINER DUMP TRUCKS. WE WERE FORTUNATE THAT THE VEHICLE WAS AT A LOW RATE OF SPEED, TURNING INTO A PARKING LOT TO STOP. NO DAMAGE OR INJURIES REPORTED. THE FAILED BALL AND SOCKET SEPARATED IN THE EXACT SAME WAY AS NOTED IN THE FREIGHTLINER BULLETIN #FL396AB OR NHTSA #00V-246-001. ACTION REQUEST: EXTEND OR EXPAND THE RECALL OF THE TRW BALL & STUD AND SOCKET ASSEMBLIES TO INCLUDE OTHER VEHICLES BUILT USING THIS BALL & STUD ASSEMBLY. TIME FRAME SHOULD BE AS SOON AS POSSIBLE TO MAKE SURE ANOTHER BALL STUD & SOCKET ASSEMBLY DOES NOT FAIL AND CAUSES AN INJURY OR DEATH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID 10007730 · filed Feb 18, 2003

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .