RoadVitals

1993 Freightliner Flb Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Newest Aug 4, 1997
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

6 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

97V114001

EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

Aug 4, 1997
77,000 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCK. THE SHOULDER BOLT WHICH HOLDS THE GROTE TURN SIGNAL SWITCH CASE AND COMPONENTS TOGETHER CAN LOOSEN RESULTING IN THE TURN SIGNAL MALFUNCTIONING.
The risk: IF THE TURN SIGNAL FUNCTION IS LOST, FOLLOWING MOTORISTS WOULD NOT BE AWARE OF THE TURNING VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL INSPECT THESE VEHICLES AND TIGHTEN ANY LOOSE BOLTS AND IN THE TURN SIGNAL SWITCH WITHIN 2 YEARS FROM THE DATE OF THE RECALL NOTIFICATION LETTER. THE SHOULDER BOLT WILL BE REMOVED, CLEANED, AND REINSTALLED WITH LOCTITE. OWNERS CAN ALSO REQUEST LOCTITE AND REPAIR INSTRUCTIONS SO THEY CAN FIX THE VEHICLES THEMSELVES.
FREIGHTLINER CORPORATIONView on NHTSA.gov
96V232000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

Nov 13, 1996
27,500 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HORTON FAN DRIVES. THE FAN DRIVE CONTROL SYSTEM WAS RECONFIGURED WHICH RESULTED IN A SIGNIFICANT INCREASE IN THE DEMAND FOR FAN ACTIVATION AND ASSOCIATED STRESS TO ELECTRICAL AND MECHANICAL COMPONENTS. VARIOUS COMPONENT FAILURE MODELS, COMBINED WITH CHARACTERISTICS OF THE FAN CLUTCH AND ITS BEARINGS, CAN CAUSE FAN CLUTCH BEARINGS TO FAIL PREMATURELY AND RESULT IN A LOCKED FAN.
The risk: IF THE FAN IS LOCKED, THE THE SYSTEM CALLS FOR THE FAN TO BE ON, THE FAN CLUTCH WILL SLIP, GENERATE HEAT, AND UNLESS RELEASED, WILL RESULT IN A FIRE.
The remedy: DEALERS WILL REPLACE THE FAN CLUTCH DRIVE DISC WITH ONE THAT INCORPORATES A THERMALLY ACTIVATED PRESSURE RELIEF.
FREIGHTLINER CORPORATIONView on NHTSA.gov
95E003005

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Apr 3, 1995
18,500 units potentially affected
The defect: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVER PRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.
The risk: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGECAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
The remedy: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
FREIGHTLINER CORPORATIONView on NHTSA.gov
94V068000

ELECTRICAL SYSTEM:WIRING

Apr 11, 1994
1,400 units potentially affected
The defect: A LARGER THAN SPECIFIED SCREW WAS USED TO MOUNT A POWER JUNCTION STUD BLOCK TO THE PASSENGER SIDE OF THE ENGINE TUNNEL. THE LARGER SCREW DID NOT ALLOW ADEQUATE CLEARANCE BETWEEN THE SCREW HEAD AND THE RING TERMINALS WHICH ATTACH TO THE STUD. CONTACT BETWEEN THE RING TERMINALS AND THE SCREW HEAD CAN CAUSE AN ELECTRICAL SHORT CIRCUIT.
The risk: ELECTRICAL SHORT CIRCUITS IN THE ENGINE COMPARTMENT CAN LEAD TO POSSIBLE FIRES WITHOUT PRIOR WARNING.
The remedy: CORRECT SIZE MOUNTING FASTENERS WILL BE INSTALLED TO REPLACE THE OVERSIZE SCREWS. THESE WILL BE RECESSED INTO THE MOUNTING BLOCK AND CANNOT COME INTO CONTACT WITH THE RING TERMINALS.
FREIGHTLINER CORPORATIONView on NHTSA.gov
93V202000

POWER TRAIN:DRIVELINE:UNIVERSAL JOINT

Dec 6, 1993
11,000 units potentially affected
The defect: THE DRIVELINE U-JOINTS EXHIBIT EXCESSIVE RATES OF FAILURE AT LOW MILEAGES AND MAY CAUSE SEPARATION OF THE INTERAXLE DRIVELINE.
The risk: SEPARATION OF THE INTERAXLE DRIVELINE MAY RESULT IN THEDRIVELINE FALLING TO THE ROAD WHERE IT CAN INTERFERE WITH TRAFFIC AND RESULTIN AN ACCIDENT.
The remedy: FREIGHTLINER DEALERS WILL REMOVE AND REPLACE THE ROCKWELL INTERAXLE U-JOINTS WITH U-JOINTS OF A DIFFERENT DESIGN.
FREIGHTLINER CORPORATIONView on NHTSA.gov
93V191000

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

Nov 19, 1993
1,800 units potentially affected
The defect: THE HEATER/DEFROSTER DOOR CAN BECOME STUCK IN THE HEATER MODE DUE TO THE DOOR OVER-TRAVELING THE DOOR STOP, IMPEDING THE DEFROSTER PORTION OF THE SYSTEM FROM WORKING.
The risk: IF THIS OCCURS, AND THE WINDSHIELD BECOMES FOGGED, ITWILL IMPAIR THE DRIVER'S VISION OF THE ROAD AND TRAFFIC, WHICH MAY CAUSE ANACCIDENT.
The remedy: DEALERS WILL INSTALL A POSITIVE DOOR STOP.
FREIGHTLINER CORPORATIONView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources