RoadVitals

2004 Freightliner Fld Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Newest Sep 16, 2011
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

6 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

11V478000

FUEL SYSTEM, DIESEL

Sep 16, 2011
73,500 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
The risk: THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number 11C-2View on NHTSA.gov
09V366000

ENGINE AND ENGINE COOLING

Sep 23, 2009
25,362 units potentially affected
The defect: DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.
The risk: AN OIL LEAK MAY RESULT IN A FIRE.
The remedy: DAIMLER TRUCKS IS WORKING WITH CATERPILLAR TO REMEDY THESE VEHICLES. PLEASE SEE CATERPILLAR'S DEFECT REPORT 09E-020. CATERPILLAR WILL INSPECT AND REPAIR THE NECESSARY COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 5, 2009. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR DAIMLER TRUCKS AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICAManufacturer number FL-558View on NHTSA.gov
05V408000

STEERING:LINKAGES

Sep 13, 2005
37,029 units potentially affected
The defect: ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.
The risk: IF THIS OCCURS, THE VEHICLE COULD SUFFER A LOSS OF STEERING ABILITY, WHICH COULD RESULT IN A CRASH.
The remedy: DEALERS WILL INSPECT AND ATTACH A TENSION COLLAR TO THE STEERING SHAFT TO SECURE THE CONNECTION TO THE YOKE. THE RECALL BEGAN ON NOVEMBER 16, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-452View on NHTSA.gov
05V285000

WHEELS:HUB

Jun 14, 2005
1,786 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.
The risk: THIS TAPER MAY CAUSE CRACKING OR FRACTURES OF THE FRONT HUB. THIS COULD CAUSE A CRASH WITHOUT PRIOR WARNING.
The remedy: AFTER FURTHER INVESTIGATION AND TESTING, FREIGHTLINER HAS REVISED THE POPULATION AND THE REMEDY (DECEMBER 22, 2005). THEREFORE, THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-451View on NHTSA.gov
04V591000

SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

Dec 15, 2004
250 units potentially affected
The defect: ON CERTAIN TRUCKS, THE BRAKE PEDAL PUSHROD WAS NOT TIGHTENED PROPERLY DURING ASSEMBLY.
The risk: LOOSE BRAKE PEDAL PUSHROD JAM NUTS COULD CAUSE LOSS OF CONTROL OF THE VEHICLE AND A CRASH MAY OCCUR.
The remedy: DEALERS WILL ADJUST THE PEDAL PUSHROD. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-437View on NHTSA.gov
04V590000

POWER TRAIN:DRIVELINE

Dec 15, 2004
1,095 units potentially affected
The defect: ON CERTAIN VEHICLES, THERE IS A DEFECT IN THE INTERAXLE DRIVELINE YOKES. THE BOLT HOLES LOCATED ON THE EARWORK OF THE MALE SHAFT YOKES WERE MANUFACTURED WITH AN OVERSIZED MINOR THREAD DIAMETER.
The risk: THIS CONDITION ALLOWS THE BOLTS USED IN THE HOLES TO BECOME DETACHED WHICH COULD RESULT IN A DRIVELINE SEPARATION. DRIVELINE SEPARATION COULD RESULT IN A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE SUSPECT MALE SHAFT YOKES. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-436View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .