RoadVitals

1996 Freightliner FLD120 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jun 11, 2000
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Freightliner FLD120, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes150.0%
  • Interior & seats150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

BRAKES FAILED RESULTING IN REAR END COLLISION.

NHTSA ID 535706 · filed May 19, 1998

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

THIS IS A 1996 FREIGHTLINER IM AM BUYING OFF OF BUSKE LINES INC. I WAS IN A RESTURANT EATING IN A RESTURANT IN INDIANA. I WAS NOTIFIED THAT UNIT WAS ON FIRE. I RAN TO TRUCK AND FIRE HAD GUTTED INSIDE OF CAB MY DOG WAS TRAPPED IN THE SLEEPER AND WAS KILLED I NOTICED NO SMOKE WHEN I LEFT TRUCK BUT SMELLED SOMETHING LIKE HOT PLASTIC I CHECKED BUT DID NOT FIND ANYTHING BURNING. TRUCK WAS THEN TOWED TO ST LOUIS MO I WAS INFORMED BY FIRE DEPT AND SHERRIF THAT IF I WOULD OF LAID DOWN I WOULD HAVE PROBELY BEEN KILLED DUE TO TOXIC FUMES PRODUCED BY SMOKE. IN RECENT MONTHS I HAVE SEEN IN PERSON A MINIMUM OF 10 OTHER TRUCKS SAME YEAR AND MODEL WITH SAME FIRE DAMAGE STARTING IN THE SAME AREA. I ALSO HAVE A WIREING JUNCTION BLOCK THAT WAS TAKEN FROM ANOTHER TRUCK SAME YEAR THAT HAS MELTED AND STARTED TO BURN BUT WAS REPLACED BEFORE IT CAUGHT ANOTHER TRUCK ON FIRE. THIS TRUCK HAS BEEN REBUILT BUT AM STILL AFRAID OF FIRE IN WIRING I HAVE TRIED TO CONTACT FREIGHTLINER WITH NO RESPOSE . ALSO NOT ONLY IN MY UNIT BUT OTHERS AT NIGHT WHEN YOUR DASH LIGHT ARE ON ALL GUAGES [ESPECIALLY WHEN HEATER IS ON] YOU CAN NOT PLACE YOUR HAND ON ANY GUAGE AND LEAVE IT THERE BECAUSE IT IS EXTREMELY HOT IN MY OPINION THIS WOULD ALSO BE A MEANS OF A FIRE STARTING SOMETHING IS WRONG WITH THIS . I AM DOING MORE INVESTIGATION ON MY OWN FOR MORE FIRES OF THIS NATURE PLEASE NEED YOUR HELP I HAVE OVER 28 YEARS OF DRIVING AND HAVE NEVER HAD ONE CATCH FIRE IS IT GOING TO TAKE A HUMAN LIFE TO CORRECT THIS ..THANK YOU. *AK

NHTSA ID 723892 · filed Jun 11, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .