RoadVitals

2000 Freightliner MT45 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Oct 6, 2005
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Freightliner MT45, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Fuel system2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

2
reports

From owner reports, verbatim

DT: 2000 FREIGHTLINER MT45. THE CONTACT STATED THE FUEL PUMP FAILED ON FEBRUARY 25, 2003. THE VEHICLE LOST POWER FROM 75-35 MPH. ON A SEVEN MILE DRIVE THE VEHICLE VARIED WITH FREQUENT SPEED VARIATIONS, EVERY 10- 15 SECONDS, THE ENTIRE SEVEN MILES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP; THEY CHECKED THE ENGINE FOR STALLING INTERMITTENTLY. THE DEALERSHIP FOUND 299 COUNTS OF FAULT CODE 364. THEY REPLACED THE FUEL PUMP. THIS CORRECTED THE PROBLEM, BUT THE DEALERSHIP DID NOT WARRANTY THE PROBLEM *AK

NHTSA ID 10138924 · filed Oct 6, 2005

DT: 2000 FREIGHTLINER MT45. THE CONTACT STATED THE FUEL INJECTION PUMP FAILED. THIS HAPPENED ON AUGUST 31, 2005. THE VEHICLE HAS NOT BEEN TO TAKEN TO THE DEALERSHIP. THE CONTACT INSTALLED A LIFT PUMP AND A LIFT PUMP INDICATOR FAILURE LIGHT. HE NOTICED SUDDEN AND UNANNOUNCED ENGINE FAILURE WHILE DRIVING ON MAIN STREET TRAFFIC. THE CONTACT IMMEDIATELY PULLED OVER WITH A DEAD ENGINE. THE VEHICLE WAS THEN TOWED TO THE CONSUMER'S RESIDENCE. THE CONTACT CONTACTED FREIGHTLINER, AND THEY TOLD HIM THERE WAS NO WARRANTY COVERAGE. ALSO CONTACTED CUMMINS, AND THEY STATED THERE WAS NO WARRANTY COVERAGE . *AK

NHTSA ID 10138921 · filed Oct 6, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .