RoadVitals

2001 Freightliner MT45 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Apr 5, 2005
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

05V138000

EQUIPMENT:OTHER:LABELS

Apr 5, 2005
500 units potentially affected
The defect: CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
The risk: THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING WHICH COULD CAUSE A CRASH.
The remedy: DEALERS WILL MAIL NEW CHASSIS IDENTIFICATION LABELS WITH THE CORRECT GAWR, GVWR, AND TIRE INFORMATION. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER LLCManufacturer number FL-444View on NHTSA.gov
01V117000

ELECTRICAL SYSTEM:WIRING

Apr 13, 2001
1,354 units potentially affected
The defect: VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE APPLIED WITHOUT THE ENGINE RUNNING, THE FUSE COULD BLOW.
The risk: THIS RESULTS IN A LOSS OF POWER ASSIST TO THE BRAKE SYSTEM, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REWIRE THE BACK-UP BRAKE PUMP CIRCUIT. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER CORPORATIONManufacturer number FL-283View on NHTSA.gov
01V116000

ELECTRICAL SYSTEM:WIRING

Apr 13, 2001
1,400 units potentially affected
The defect: VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
The risk: THIS COULD POTENTIALLY CAUSE AN ELECTRICAL FIRE.
The remedy: DEALERS WILL INSTALL A NEW SEALED RELAY AND FUSE BOX WITH SEALED RELAYS. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
FREIGHTLINER CORPORATIONManufacturer number FL-278View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .