2005 Freightliner Sprinter 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Freightliner Sprinter 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure120.0%
- Electrical120.0%
- Exterior lighting120.0%
- Powertrain (other)120.0%
- Visibility120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
2005 FREIGHTLINER SPRINTER VAN 2500 WITH NO SIDE DOOR OR REAR DOOR GLASS. THE DRIVER MUST USE THE OUTSIDE MIRRORS TO MERGE IN TRAFFIC. THE OUTSIDE MIRRORS THAT ARE NOT HEATED WILL FOG UP WHEN DRIVING IN DIFFERENT ELEVATIONS CAUSING THE DRIVER TO BE BLIND. I BELIEVE THIS IS A SAFETY ISSUE WHERE ALL FULL SIZE COFFIN VANS WITH NO SIDE OR REAR GLASS SHOULD HAVE HEATED OUTSIDE MIRRORS FROM THE FACTORY, THIS APPLIES TO ANY MAKE FULL SIDE COFFIN VANS, CARGO VANS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TURN SIGNAL FAILURE AT CONTROL ARM ON STEERING COLUMN. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
TURN SIGNAL FAILURE AT CONTROL ARM ON STEERING COLUMN. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WHILE CLIMBING A MOUNTAIN INCLINE (6%) IN N.C.,WE HAD SUDDEN LOSE OF POWER IN OUR 2005 FREIGHTLINER (DODGE) SPRINTER. THIS WAS OUR FIRST FAILURE. THE TURBO RESONATOR SEPARATED CAUSING ALMOST COMPLETE LOSE OF POWER. THIS COULD BE VERY DANGEROUS HAD THERE BEEN TRAFFIC. THERE SHOULD BE A RECALL TO REPLACE THIS ITEM WITH A MORE RELIABLE ONE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
2005 FREIGHTLINER SPRINTER VAN 2500 WITH NO SIDE DOOR OR REAR DOOR GLASS. THE DRIVER MUST USE THE OUTSIDE MIRRORS TO MERGE IN TRAFFIC. THE OUTSIDE MIRRORS THAT ARE NOT HEATED WILL FOG UP WHEN DRIVING IN DIFFERENT ELEVATIONS CAUSING THE DRIVER TO BE BLIND. I BELIEVE THIS IS A SAFETY ISSUE WHERE ALL FULL SIZE COFFIN VANS WITH NO SIDE OR REAR GLASS SHOULD HAVE HEATED OUTSIDE MIRRORS FROM THE FACTORY, THIS APPLIES TO ANY MAKE FULL SIDE COFFIN VANS, CARGO VANS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .