2020 Freightliner Sprinter 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Freightliner Sprinter 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance342.9%
- Engine342.9%
- Exterior lighting114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
On May 22, 2023 around 19:00 after driving my vehicle for nearly 90 minutes the vehicle no longer responded to the gas pedal being depressed by increasing acceleration. The vehicle would not go over 2,500 RPMs even with the gas pedal fully depressed. No warning were shown on the driver display or in the messaging system. The manual gear shifting did not work to raise or lower the gears while the vehicle was in this state. The vehicle display showed the vehicle in "D" for Drive and I could not change it to any other value such as D1, D2, etc.. The vehicle had almost no power and would not accelerate except for very slowly taking over 1.5 minutes to reach 55 mph. This is a SEVERELY dangerous situation as without warning my vehicle stopped responding to driver input in a reasonable fashion and thus if I was attempting to turn onto a busy road or cross a road my vehicle would not have enough acceleration to do so and could cause an accident resulting in serious death or injury. No warnings or alerts were shown on driver console. Parking assistance was turned off. Lane departure was turned off. I cycled on/off the cruise control to no avail. I evened turned the engine off and on and the problem still persisted. It wasn't until I was able to safely pull off later and power off the vehicle and wait 5 minutes that the problem went away. It is incomprehensible to me why we allow car manufacturers to override user input and commands with faulty and buggy computer software. If I press the gas pedal it should respond!
Driving in center lane of three lane interstate highway in the evening so it was dark. I had cruise control set at 55 mph. Nothing to my right and at least 100 yards of nothing in front of me. A white sedan speeds by in the left lane staying entirely in their left lane. My vehicle slammed on the brakes for some unknown reason almost causing the vehicle behind me to collide with me. A red triangle appeared on dash display for 2 seconds or so (not long enough to know what the computer thought happened ). No explanation given. No messages in drive computer. Absolutely awful. This could have caused a major accident and it was all done by a computer with no explanation. I want a dealer to download the log from my car for 17:52-17:53 on 1/14/23 and issue a complete and detailed report. There’s a severe safety issue and it must be fixed.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The Cooling fan behind the radiator also known as the clutch fan fell off the water pump. I realized it before it fell on the highway during rush hour and caused a major accident and engine failure. This is a very common problem and is all over the internet. In most cases it will take out the radiator, fan assembly, belts and hoses as reported by many on the internet when you google “MB sprinter clutch fan falls off”.
Engine destroyed by oil and water accumulation in intercooler that was pulled through the turbo and entered cylinder 6. Bent connecting rod on Cylinder 6, Bent and torn turbo vanes. Sudden loss of power while operating. Mercedes is replacing the entire motor. No Symptoms before the event, check engine light after first restart.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
COLOR INSTRUMENT CLUSTER INCLUDING COLOR DISPLAY BETWEEN THE SPEEDOMETER AND TACHOMETER WILL NOT DIM AT NIGHT. THE RESULTING WASH OF LIGHT MAKES SEEING OUT THE SIDE MIRRORS OR ANYTHING AT NIGHT VERY DIFFICULT. VAN IS NOT SAFE TO DRIVE AT NIGHT. MANUFACTURE CONFIRMS THE PROBLEM BUT HAS NO FIX.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .