2003 Freightliner Sprinter 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Freightliner Sprinter 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical150.0%
- Engine150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2003 FREIGHTLINER SPRINTER 3500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT AN UNKNOWN FUSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER, THE FAILURE RECURRED THE NEXT DAY. THE CONTACT REPLACED THE FUSE BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND IT WAS DISCOVERED THAT THE SAME FUSE HAD FAILED. THE CONTACT REPLACED THE FUSE, HOWEVER, THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED THE FOLLOWING DAY AND THE SAME FUSE NEEDED REPLACEMENT WHICH CAUSED THE VEHICLE NOT TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DETERMINED BUT THE TECHNICIAN WAS ABLE TO START THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS NOT ABLE TO BE STARTED. AS A RESULT, THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ECM WAS MELTED AND NEEDED TO BE REPLACED. THE FAILURE RECURRED AFTER THE REPAIR AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THE CRANK SHAFT SENSOR AND THE CAM SHAFT SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2003 Freightliner Sprinter 3500. The contact received notification of NHTSA Campaign Number: 09V418000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .