2010 Freightliner Sprinter 3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2010 Freightliner Sprinter 3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags125.0%
- Driver assistance125.0%
- Engine125.0%
- Fuel system125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. UPON STARTING THE VEHICLE, THE SRS WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED AND WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 800 AND THE CURRENT MILEAGE WAS 1,000. THE VIN WAS UNAVAILABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THE HANDLING OF THIS VEHICLE IS VERY UNSTABLE AT 50 MILES HOUR OR LESS. WIND COULD BE SOME OF THE PROBLEMS. OTHER VEHICLES DID NOT APPEAR TO HAVE THIS PROBLEM, AS THEY WOULD PASS US AND NOT TO HAPPY THAT WE COULDN'T DRIVE FASTER.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. THE CONTACT STATED THAT THE CHECK ENGINE AND FUEL PRESSURE LOW WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO EXCEL TRUCK GROUP OF COLUMBIA (2790 SHOP RD, COLUMBIA, SC 29209) AND WAS REPAIRED. THE CAUSE OF THE FAILURE WAS NOT DISCLOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 13,402. *BF THE CONSUMER STATED THE SENSOR WAS BAD AND HAD IT REPLACED AT THE TUNE OF $1455.41. THE CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2010 FREIGHTLINER SPRINTER 3500. THE CONTACT STATED THAT THE CHECK ENGINE AND FUEL PRESSURE LOW WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO EXCEL TRUCK GROUP OF COLUMBIA (2790 SHOP RD, COLUMBIA, SC 29209) AND WAS REPAIRED. THE CAUSE OF THE FAILURE WAS NOT DISCLOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 13,402. *BF THE CONSUMER STATED THE SENSOR WAS BAD AND HAD IT REPLACED AT THE TUNE OF $1455.41. THE CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .