2005 GMC C5500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 GMC C5500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine266.7%
- Steering133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I PURCHASED THREE C-5500 TRUCKS. AS OF NOW I HAVE TWO TRUCKS WITH FAILED ENGINES DUE TO PREVIOUS INJECTOR FAILURE. I AM CURRENTLY OUT OF WARRANTY BUT NOT BEFORE I NOTICED THE ENGINE WAS MAKING MORE NOISE THAN NORMAL. I WAS TOLD THAT IT HAD TO BE BROKEN BEFORE IT COULD BE REPAIRED UNDER WARRANTY. THAT WAS 60,000 MILES AGO. WHICH SHOULD NOT BE MAJOR MILEAGE FOR A DIESEL ENGINE. *TR
I OWN 3 CHEVORLET C-5500 TRUCKS. TWO OUT OF THE THREE HAVE HAD INJECTOR FAILURE. AFTER THE INJECTOR FAILURE THE TRUCKS ENGINE SEEM TO BE NOISIER. I HAVE COMPLAINED ABOUT THE NOISE AND WAS TOLD IT HAS TO BE BROKEN BEFORE REPAIRSCAN BE PERFORMED UNDER WARRANTY. NOW I AM OUT OF WARRANTY AND HAVE TWO TRUCKS WITH MAJOR ENGINE DAMAGE DUE TO THE PREVIOUS INJECTOR FAILURES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
GM HAD A RECALL IN 2007 FOR MEDIUM SIZE TRUCK FOR STEERING BOX PROBLEM FOR STEERING WHEEL BEING OUT OF CENTER AND NOISE OR HARD SPOTS IN STEERING. THE RECALL NO. IS 07220. I BOUGHT THIS TRUCK APPX 2 YRS AGO NOT KNOWING ABOUT THE RECALL UNTIL A FRIEND SUGGESTED DOING SOME RESEARCH. VIN NUMBERS AFFECTED BY RECALL IN 2005 WERE [XXX]. MINE BEING [XXX] CLEARLY FALLS WITHIN THE RANGE. IT SAYS IF STEERING BOX NUMBER IS EARLIER THAN BUILD DATE IT HAS BEEN FIXED OR BUILD DATE IS AFTER SOME TIME IN 2007 THEY ARE OKAY.. MY TRUCK ONLY HAD 13,000 MILES WHEN I BOUGHT IT AND NOW HAS 20,000. IT SAYS IF MANUFACTURING DATE IS SAME AS TRUCK BUILD DATE IT HASN'T BEEN FIXED. THE STEERING BOX AND THE TRUCK HAVE THE SAME BUILD DATE APRIL 2005. (0405) I HAVE CONTACTED GM AND SINCE THE VIN CHECK COMES BACK CLEAN THERE IS NOTHING THEY WILL DO. I EVEN HAD A PARTS GUY AT GM DEALER TELL ME THAT A CLEAN VIN CHECK ISN'T ABNORMAL IF THE RECALL IS OLDER. IT SAYS IN THE RECALL THE BOX COULD CAUSE AN ACCIDENT IF NOT FIXED. ANY HELP YOU COULD DO FOR WOULD GREATLY BE APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .