2007 GMC Canyon Owner Complaints

While driving my vehicle the vehicle early in the morning going to work, the headlights went out. I pulled over, and turned it to auto and they worked there, but did not work when switching it to headlamps. That happened just the one time. Also, since I have owned the vehicle, after operating the vehicle when it is dark outside, and then getting out to get gas, and getting back in. I crank the vehicle over, and I have no dash lights. I cannot see how fast I am going. It only does this after operating the vehicle and turning it off, and then getting back in and starting it again. This has occurred many times for the past 4 years.

NHTSA ID

11726001

Incident

Mar 21, 2026

The contact owns a 2007 GMC Canyon. The contact stated that on several occasions the vehicle would not immediately start-up. The vehicle was taken to the local dealer who diagnosed that the ignition switch was faulty and needed to be replaced. The ignition switch was replaced but the failure reoccurred. The contact indicated that the ignition switch had been replaced on four separate occasions over several years. The manufacturer was notified of the failure. The failure mileage was 70,000.

NHTSA ID

11436735

Incident

Oct 1, 2010

Mileage

70,000 mi

I WAS STOPPED AT A LIGHT BEHIND ANOTHER CAR I WAS REAR ENDED WHICH PUSHED MY TRUCK INTO THE BACK OF THE CAR AHEAD OF ME SO HARD IT MADE MY TRUCK AIRBORNE AND ROLLED 6 TIMES THRU A CITY INTERSECTION. THE FRONT OF MY TRUCK WAS CRUSHED ALMOST TO NOTHING OUT OF THE 4 VEHICLES INVOLVED MINE WAS THE ONLY ONE WHERE THE AIRBAGS DIDN'T DEPLOY. CONTRIBUTING TO ALL THE INJURIES I SUSTAINED AND I WAS THE ONLY WHO HAD INJURIES.

NHTSA ID

11397427

Incident

Feb 2, 2021

Mileage

101,000 mi

AFTER FILLING UP FUEL SPITS BACK OUT OF THE FILLER TUBE. HAS OCCURED MULTIPLE TIMES FOR MANY YEARS. APPEARS TO BE GETTING WORSE. VEHICLE IS STATIONARY

NHTSA ID

11382929

Incident

Dec 10, 2020

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2007 GMC CANYON. THE CONTACT STATED THAT THE REAR SIDE CURTAIN AIR BAG WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE FAILURE WAS A KNOWN ISSUE FOR SIMILAR 2004 TO 2012 MODELS. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS 218,000.

NHTSA ID

11328856

Incident

Nov 15, 2019

Mileage

218,000 mi

ABS FAULT I HAVE REPLACED BRAKES WHEEL HUBS AND SENSERS 2 TIMES IN 3 MONTHS STILL ABS FAULT 98,000 MILES ON TRUCK THIS ISSUE IS ALL OVER THE INTERNET NEEDS TO BE ADDRESSED

NHTSA ID

11316316

Incident

Dec 1, 2019

Mileage

96,000 mi

BOUGHT OUR PRISTINE 2007 GMC CANYON SLE IN NOV 2017 WITH 45, 471 ORIGINAL MILES. BEEN VERY HAPPY WITH IT UNTIL LIGHTING QUIRKS STARTED ABOUT A YEAR AGO. THE LAST YEAR OR SO THE TURN SIGNAL AND BRAKE LIGHTS HAVE PULSES WHERE THEY DECIDE TO NOT WORK CORRECTLY. THEN WORK FINE FOR MONTHS, BEFORE ACTING UP AGAIN. WE ACTUALLY HAD OUR CANYON IN AT THE GMC DEALER IN DEC 2019 FOR LOOS INTAKE MANIFOLD REPAIR, 2ND TIME IN LAST 9 MONTHS.. THE SERVICE MANAGER TOLD US WE ALSO HAD NO BRAKE LIGHTS. I SAID I DID NOT KNOW THAT AND I WAS NOW CONCERNED HOW LONG THEY HAVE NOT BEEN WORKING, AND THAT WE HAVE HAD INTERMITTENT TURN SIGNAL ISSUES A NUMBER OF TIMES IN THE LAST YEAR. COMES AND GOES. I THEN ASKED IF THERE WAS ANY BRAKE LIGHT OR LIGHT SWITCH RECALL ON OUR CANYON. I SAID I REMEMBER SEEING A RECALL NOTICE ON CONSUMER REPORTS. HE SAID THEIR IS NO RECALL ON OUR CANYON. THEY SAID THEY FIXED THE BRAKE LIGHT WITH A NEW BRAKE PEDAL BRAKE LIGHT SWITCH. TONIGHT THE LIGHTS STARTED ACTING UP AGAIN. WHEN PUSH BRAKE PEDDLE, LEFT TURN SIGNAL TURNS ON. LEFT TURN SIGNAL WAS ALSO INTERMITTENT FUNCTION, OCCASIONALLY THIS LAST WEEK. TONIGHT IT HAD A HARD TIME FIGURING OUT HOW TO WORK, FLASH CORRECTLY. THEN, WHILE DRIVING HOME TONIGHT AND WITH MY KIDS FOLLOWING ME IN THEIR SUV, WHEN WE GOT HOME THEY SAID THE CANYON NEEDS TO STAY PARKED UNTIL REPAIRED. THEY SAID MY TURN SIGNALS AND BRAKES LIGHT ARE TOTALLY MESSED UP AND NOT WORKING. NO LEFT RUNNING LIGHT, NO LEFT BRAKE LIGHT, AND RIGHT BRAKE LIGHT ON FULL BRIGHTNESS THE WHOLE TIME. THEY COULD NOT TELL WHEN I WAS BRAKING OR USING THE TURN SIGNALS. INTERESTING HOW THE DEALER SERVICE MANAGER DID NOT RECOMMEND TO US THAT THEY REPLACE THE LIGHT SWITCH ANYWAYS, JUST TO BE SAFE.

NHTSA ID

11298648

Incident

Jan 12, 2020

Mileage

89,041 mi

WHEN YOU START YOUR TRUCK UP LET IT WARM UP YOU START DRIVING DOWN THE ROAD AND YOU TOUCH THE BRAKES AND THE RPM START GOING UP AND DOWN UP AND DOWN WITH VEHICLE DYING SPORADICALLY

NHTSA ID

11280526

Incident

Nov 10, 2019

Mileage

130,000 mi

THE AIR CONDITION BLOWER MOTOR SUDDENLY FAILED. UP INSPECTION AND TROUBLESHOOTING IT WAS DISCOVERED THAT THE PLUG CONNECTING TO THE MOTOR HAD MELTED.

NHTSA ID

11220800

Incident

Jun 12, 2019

Mileage

169,000 mi

TL* THE CONTACT CALLED ON BEHALF OF THE OWNER OF A 2007 GMC CANYON. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT BECAME NAUSEOUS. THE CONTACT PULLED THE VEHICLE OFF THE ROADWAY, EXITED THE VEHICLE, AND PASSED OUT FOR SEVERAL MINUTES ACCORDING TO A WITNESS. THE DRIVER EXPERIENCED SYMPTOMS DUE TO CARBON MONOXIDE POISONING. THE CONTACT ATTEMPTED TO MOVE THE VEHICLE ONCE SHE REGAINED CONSCIOUSNESS, BUT BECAME OVERWHELMED. THE CONTACT STOPPED THE VEHICLE AND, WHILE ATTEMPTING TO RETRIEVE DOCUMENTS FROM THE GLOVE BOX, SHE NOTICED FLAMES INSIDE THE GLOVE BOX. THE CONTACT EXITED THE VEHICLE. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE; HOWEVER, THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS NOT FILED. THE DRIVER WAS TRANSPORTED BY AMBULANCE TO A NEARBY HOSPITAL. THE DRIVER RECEIVED OXYGEN FOR SIX HOURS TO REMOVE THE CARBON MONOXIDE FROM HER LUNGS. THE VEHICLE WAS TOWED TO A PRIVATE LOT. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,003.

NHTSA ID

11169872

Incident

Jan 13, 2019

Mileage

85,003 mi

MY FRAME HAS A MAJOR RUST ISSUE ON THE DRIVERS SIDE UNDER TH GAS TANK. I HAVE READ SIMILAR COMPLAINTS ON THE INTERNET WITH THE RUST BEING ON THE DRIVER SIDE UNDER THE GAS TANK.

NHTSA ID

11162976

Incident

Dec 5, 2018

Mileage

200,000 mi

LOSS OF POWER STEERING, SLOW BREAKING AND UNABLE TO ACCELERATE. PROBLEM FIXES TEMPORARILY WHEN SHUTTING THE VEHICLE OFF AND THEN BACK ON.

NHTSA ID

11156838

Incident

Dec 5, 2018

Mileage

105,000 mi

VEHICLE WON'T START AFTER IT SHUT OFF WHILE DRIVING ON FRWY . PULL OVER AND STARTED AFTER A FEW MINUTES LIKE NOTHING HAD HAPPENED

NHTSA ID

10929747

Incident

Dec 3, 2016

THE VEHICLE HAS 9 BOLTS HOLDING THE EXHAUST MANIFOLD TO THE ENGINE. THE OWNER SMELLED STRONG EXHAUST SMELL IN THE CABIN. HE REMOVED THE EXHAUST MANIFOLD FROM VEHICLE AND FOUND THAT 4 OF THE 9 BOLTS HAD FAILED AND WERE BROKEN OFF FLUSH WITH THE ENGINE BLOCK. THERE WAS EXHAUST RESIDUE IN THE IMMEDIATE AREA OF THE 1ST AND 5TH CYLINDER PORT INDICATING THAT EXHAUST GAS WAS BEING DISCHARGED INTO THE ENGINE BAY. THE FAILURE IS AN ALARMING SAFETY EVENT BECAUSE OF THE POTENTIAL FOR HOT EXHAUST TO CAUSE A FIRE IN THE ENGINE COMPARTMENT AND THE POTENTIAL FOR ASPHYXIATION DUE TO CONTAMINATED CABIN AIR. THIS IS ALSO AN ENVIRONMENTAL CONTROL FAILURE BECAUSE A PORTION OF THE EXHAUST GAS ISS BYPASSING THE CATALYTIC CONVERTERS. THE OWNER IS THE ORIGINAL OWNER AND ALL EQUIPMENT IS ORIGINAL. HE IS A DEGREED MECHANICAL ENGINEER AND HAS WORKED IN AUTOMOTIVE COMPONENT MANUFACTURING. GM WAS CONTACTED DIRECTLY AND THE OWNER DIRECTED TO SEE THE DEALERSHIP. THE OWNER PROVIDED THE DEALERSHIP WITH THE ATTACHED PHOTOS BUT THEN REFUSED TO INSPECT THE VECHICLE WITHOUT FIRST COLLECTING A "DIAGNOSTIC FEE." THE OWNER REFUSED.

NHTSA ID

10817730

Incident

Jan 4, 2016

Mileage

125,000 mi

HEATER CONTROLS QUIT WORKING. UPON FURTHER INVESTIGATION, THE FACTORY WIRING HARNESS MAIN HVAC CONNECTOR IS BURNT.

NHTSA ID

10785865

Incident

May 15, 2015

Mileage

76,000 mi

VEHICLE IS A SMALL PICK UP EXTENDED CAB WITH HALF DOORS THAT HAVE REAR SIDE HINGES. AIR BAG SERVICE LIGHT WAS SET. UPON REPAIR DIAGNOSIS, IT WAS DISCOVERED THAT WIRES THAT TRAVEL BETWEEN THE BODY AND THE LEFT SIDE HALF DOOR -BEHIND THE DRIVERS DOOR WERE BROKEN FROM THE DOOR OPENING AND CLOSING. SINCE THIS HALF DOOR IS USED VERY LITTLE, THERE IS A DEFECT WITH THE QUALITY OF WIRE THAT CANNOT WITHSTAND FLEXING BY OPENING AND CLOSING THE DOOR. THESE WIRES CONTROL THE PRE TENSIONER ASSEMBLY IN THE HALF DOOR. WHEN THE WIRES ARE BROKEN IT DISABLES THE ENTIRE AIR BAG RESTRAINT SYSTEM. WIRES WERE NOT PHYSICALLY DAMAGED BY ANY OTHER MEANS. THESE WIRE SHOULD NOT BE BROKEN ON THIS AGE VEHICLE WITH LITTLE USE.

NHTSA ID

10721605

Incident

Apr 11, 2015

Mileage

77,150 mi

THE TRUCK'S SECURITY SYSTEM AND REMOTE START STOPPED WORKING. IT CONSISTENTLY HAS TO BE RESET FOR 10 MINUTES EVERY FAILED ATTEMPT AT TRYING TO GET THE VEHICLE STARTED. HAVE ALTOGETHER STOPPED USING THE SECURITY SYSTEM (WHICH IS NOT A GOOD IDEA IN AN APARTMENT COMPLEX). NOW THE AUXILIARY SYSTEM STILL REMAINS ON IF THE ONLY DOOR USED IS THE DRIVER'S SIDE DOOR. THE PASSENGER DOOR HAS TO BE OPENED AND CLOSED TO TURN THIS OFF. THIS IS NOT SAFE (ESPECIALLY WHEN PARKED IN A PARKING GARAGE, A COLD NIGHT, OR PARKING AWAY FROM A LIGHT). *TR

NHTSA ID

10672304

Incident

May 29, 2014

Mileage

84,000 mi

TL* THE CONTACT OWNS A 2007 GMC CANYON. THE CONTACT STATED THAT THE TIRE PRESSURE GAUGE REMAINED ILLUMINATED. THE DEALER STATED THAT THE FAILURE WAS DUE TO ELEVATION. THE TIRE PRESSURE GAUGE SENSOR WAS RESET, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 5. UPDATED 11/14/14*CN UPDATED 4/29/2015 *JS

NHTSA ID

10639909

Incident

Sep 1, 2008

Mileage

5 mi

VEHICLE CRANKS BUT DOES NOT START. SECURITY LIGHT FLASHING. AFTER 10 MINUTES WITH KEY ON AND SECURITY LIGHT OFF AFTER TURNING OFF THEN CRANK ENGINE STARTS. HAPPENED AT LEAST 15 TIMES. NOW, ENGINE SOMETIMES WILL CRANK ITSELF IN THE "ON" POSITION AND WILL NOT START AND SECURITY LIGHT FLASHING. HAPPENED THREE TIMES AND FINALLY AFTER THREE 10 MINUTE KEY ON WAIT CYCLES IN A DARK PARKING LOT SECURITY LIGHT STOPPED FLASHING AND STARTED AND MADE IT HOME. VEHICLE VERY UNRELIABLE NOW. I AM TIRED OF HAVING A VEHICLE THAT THINKS THE OWNER IS TRYING TO STEAL OWNED VEHICLE. AND AUTO CRANK IN THE ON - NOT START- POSITION WITHOUT RUNNING. HOW DO I BYPASS THIS AWFUL SYSTEM WITHOUT ANOTHER CAR PAYMENT TO ANOTHER AUTOMAKER? THIS DEFECT IS DANGEROUS AND HAZARDOUS WHEN STOPPING FOR FUEL AND HAVE TO LEAVE ENGINE ON OR HOLDING UP CUSTOMERS UNTIL ENGINE STARTS. ALSO HOLDING UP VEHICLES ON A FERRY BOAT. VERY EMBARRASSING WHEN FRIENDS AND CO WORKERS HAVE TO WAIT TILL VEHICLE DECIDES TO START AND RUN. AND BEING LATE TO WORK. I DO NOT WANT NEW PARTS THAT WILL FAIL AGAIN, I WANT IT BYPASSED. SEND ME A KIT WITH DIRECTIONS ASAP! *TR

NHTSA ID

10622352

Incident

Jun 18, 2014

Mileage

39,458 mi

TL* THE CONTACT OWNS A 2007 GMC CANYON. THE CONTACT STATED THAT WHILE STARTING THE IGNITION, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG WIRING HARNESS NEEDED TO BE PATCHED UP. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ID

10615298

Incident

Jun 5, 2013

Mileage

60,000 mi

SEVERAL OCCASIONS, I HAVE HAD INCIDENTS WITH THE IGNITION SWITCH ON MY VEHICLE. I PURCHASED IT NEW, AND THE MAKER CLAIMS NO PROBLEM WITH MY PARTICULAR VEHICLE, BUT IT HAS KEPT THE MOTOR FROM RUNNING AT TIMES, AND ENGINE STARTER WILL ENGAGE WITH SWITCH ONLY IN THE "ON" POSITION, WITHOUT TURNING TO START. THAT'S SCARY. VEHICLE NEVER DID ANY OF THIS WHILE UNDER WARRANTY,(OF COURSE), BUT GIVEN THE MAKER'S TRACK RECORD WITH IGNITION SWITCHES, THIS CERTAINLY HAS ME CONCERNED. *JS

NHTSA ID

10609052

Incident

Aug 30, 2012

Mileage

120,000 mi

---ISSUE WITH THE PASSLOCK SYSTEM--- SPORADICALLY, WHEN KEY IS INSERTED INTO THE IGNITION AND TURNED, THE VEHICLE PASSLOCK ENGAGES AND CUTS OFF FUEL TO THE VEHICLE. YOU MUST WAIT APPROXIMATELY 10 MINUTES FOR SECURITY LIGHT TO QUIT FLASHING AND THEN TRY TO START VEHICLE AGAIN. THE 10 MINUTE CYCLE HAS HAPPENED BACK TO BACK, AS MANY AS THREE TIMES IN MY EXPERIENCE. THE PROBLEM GETS WORSE IN TEMPERATURES BELOW FREEZING OR HIGH HUMIDITY. THE PROBLEM EXIST WITH BRAND NEW, NEVER USED, FACTORY KEY AS WELL AS THE NORMALLY USED KEY. THIS ISSUE IS VERY INCONVENIENT, BUT DOES RAISE VERY IMPORTANT SAFETY CONCERNS. THIS PARTICULAR VEHICLE HAS A STANDARD TRANSMISSION. IF VEHICLE IS ACCIDENTALLY STALLED IN THE MIDDLE OF AN INTERSECTION DURING SHIFTING, AND THE PASSLOCK PROBLEM OCCURS, YOU WOULD BE UNABLE TO RESTART THE VEHICLE. THIS WOULD POSE IMMEDIATE DANGER TO THE PEOPLE IN THE VEHICLE, AS WELL AS, ANY ONCOMING TRAFFIC. *TR

NHTSA ID

10604390

Incident

Sep 3, 2012

Mileage

84,000 mi

LEFT REAR BRAKE LAMP IS INOPERATIVE PERIODICALLY. I'VE REPLACED THE BULB 3 TIMES IN THE PAST BUT THIS TIME THE LIGHT WOULD NOT WORK. THE LAST BULB WAS PARTIALLY MELTED AT CONTACTS. NOT COVERED BY RECALL - I AM PAYING FOR SOCKET REPLACEMENT. DON'T KNOW IF THIS IS A CHRONIC PROBLEM. *TR

NHTSA ID

10513358

Incident

May 16, 2013

Mileage

25,000 mi

THE TRUCK EXPERIENCES ENGINE STUTTER AT LOW IDLE (>1000RPMS) VARYING FROM 1000 RPMS TO 200 RPMS WITH FELT LOSS OF POWER STEERING AT LOW RPMS. AT LOWER RPMS, TYPICALLY AT STOPS OR LOW IDLE TURNS, THE TRUCK WILL STALL WITH LOSS OF POWER STEERING AND BRAKE CONTROL (TAPPING THE BRAKE EQUALS SLAMMING THE BRAKE). RECENTLY, THE ISSUE IS NOW BECOMING MORE FREQUENT AND NOW OCCURRING WHILE MAKING LOW IDLE TURNS INTO TRAFFIC CAUSING A STALL. THE ONLY RESOLUTION IS TO DROP THE TRUCK IN NEUTRAL, IN TRAFFIC, AND RESTART HOPING THE BUMP START WILL OCCUR ON THE FIRST TRY BEFORE BEING HIT FROM BEHIND. I HAVE CALLED GM SERVICE SHOPS, THE SERVICE CENTER IN DETROIT AS WELL AS LOOKED FOR RECALLS ONLINE AND THERE ARE NO OFFICIAL POSTINGS OR KNOWLEDGE OF THESE PROBLEMS DESPITE NUMEROUS INDIVIDUAL ACCOUNTS FOUND IN GMC/CHEVY FORUMS. THIS ISSUE IS A DANGEROUS ISSUE IN MY OPINION AND NEEDS TO BE ADDRESSED. *TR

NHTSA ID

10499792

Incident

Feb 23, 2013

Mileage

82,410 mi

AUTOMATIC TRANSMISSION FAILURE WHERE OVERDRIVE AND 3RD GEAR CEASED TO FUNCTION. 2ND, 1ST AND REVERSE REMAINED OPERATIONAL. DEALER DIAGNOSED AS A FAILED SPRAG CLUTCH. COST TO REPAIR WAS $1,925.56. GM HAS KNOWN ABOUT THIS PROBLEM SINCE IT ISSUED A TECHNICAL SERVICE BULLETIN (TSB) #3931 ON SEPTEMBER 28, 2006, (NHTSA REFERENCE #10021018). THERE HAVE BEEN NUMEROUS COMPLAINTS PERTAINING TO THIS MECHANICAL DESIGN DEFECT EVER SINCE WITHOUT NOTICE OR REMEDY OFFERED TO VEHICLE OWNERS. *TR

NHTSA ID

10495319

Incident

Jan 10, 2013

Mileage

83,000 mi