2005 GMC Envoy Xl 370 Fuel system Problems

DRIVING CAR BRAKES GO GET IT FIX PAID 375 TO GET FIX NOW NO POWER STEERING FUEL GAUGE DOSEN. T WORK WHAT A MESS NEED HELP

NHTSA ID

11153687

Incident

Nov 21, 2018

Mileage

120,000 mi

STALLING OUT IN INTERSECTION,FUEL GAGE AND SPEED ODOMETER ,AIR BAGS DEFAULTING,SHACKING IN FRONT END , WHEN DRIVING. VERRY DANGEROUS.

NHTSA ID

10885262

Incident

Jul 16, 2016

Mileage

128,000 mi

FUEL GAUGE SENSOR 2005 ENVOY XL DENALI. 70153 MILES. AFTER FUELING THE VEHICLE FUEL GAUGE REGISTERS EMPTY UNTIL ABOUT AN EIGHTH OF A TANK HAS BEEN USED THEN THE FUEL GAUGE WORKS JUST FINE. HAVE TO DISCONNECT THE POSITIVE BATTERY TERMINAL FOR APPX. TEN MINUTES TO GET THE SERVICE ENGINE LIGHT TO STOP ILLUMINATING. OCCURS EVERYTIME I FILL THE VEHICLE. IT CAUSES AN INACCURATE FUEL READING. TURNING IN TO DEALER TOMORROW 06-19-2013 FOR REPAIRS. CODE PRODUCED P0463. *TR

NHTSA ID

10520340

Incident

Jun 18, 2013

Mileage

68,000 mi

I FILLED MY TANK AT A GAS STATION AND WHEN LEAVING THE "CHECK ENGINE" LIGHT CAME ON AND THE FUEL GAUGE DROPPED DOWN TO "E" AND LOW FUEL LIGHT CAME ON. AFTER 10-15 SECONDS THE FUEL GAUGE WENT ALL THE WAY TO "FULL". A FEW MINUTES LATER IT DID THE SAME THING AGAIN, AND HAS CONTINUED. *TR

NHTSA ID

10520249

Incident

Jun 17, 2013

Mileage

70,260 mi

WE STARTED NOTICING AFTER A FILL UP AT THE GAS STATION THE GAS GAUGE STILL SHOWED EMPTY. THE GAUGE TOOK OVER AN HOUR OF DRIVING TO MOVE UP TO FULL. IN THE MIDDLE OF THE WEEK LAST WEEK THE VEHICLE RAN OUT OF GAS AND STALLED. WE ADDED HALF A TANK, BUT THE GAUGE STILL SHOWED EMPTY THE NEXT FEW TIMES IT WAS DRIVEN SOMEWHERE. LAST WEEKEND I FILLED UP AGAIN AND THE GAUGE SHOWED EMPTY STILL WITH WARNING INDICATOR ON. AGAIN IT TOOK OVER AN HOUR OF DRIVING FOR THE GAUGE TO REGISTER THE TANK EVEN 3/4 FULL. *TR

NHTSA ID

10510240

Incident

Apr 10, 2013

Mileage

100,000 mi

AIR CONDITIONER QUIT WORKING ON LEVEL 5, WOULD WORK ON LEVEL 1-4, LEVEL 5 WOULD KEEP TURNING OFF. SHORTLY AFTER THIS WITHIN THE SAME DAY I COULD SMELL SOMETHING BURNING COMING THROUGH THE AIR VENTS. MECHANICS NOTED AND SHOWED ME THAT THE RESISTOR PLUGS ON THE BACK HAD BURNED AND MELTED TOGETHER, THAT'S WHAT WAS CAUSING THE BURNING SMELL. NEEDED A NEW RESISTOR, PIG TAIL, AND BLOWER. ALSO MY FUEL GAUGE AND RPM ARE BROKE, HAVE NOT BEEN WORKING FOR THE PAST 3 YEARS. *TR

NHTSA ID

10465981

Incident

Jul 1, 2012

Mileage

150,000 mi

FUEL GAUGE DOES NOT WORK. I WILL FILL UP THE TANK AND TURN ON THE CAR AND IT READS LOW FUEL AND THE INDICATOR LIGHT COMES ON. THEN I CAN BE DRIVING AND IT WILL JUMP UP TO PAST 1/4 TANK THEN SLOWLY GO DOWN TO E AND READ LOW FUEL.

NHTSA ID

10453450

Incident

Feb 3, 2012

Mileage

75,300 mi

THE FUEL SENSOR ON MY VEHICLE SWINGS WILDLY FROM EMPTY TO FULL EVEN WHEN THE FUEL TANK HAS JUST BEEN FILLED. THIS RESULTS IN THE CHECK ENGINE LIGHT TO CONSTANTLY BE ON. I AM UNABLE TO DETERMINE HOW MUCH GAS IS IN THE CAR DUE TO THE FAULTY SENSOR. I HAVE CHECKED THE INTERNET AND THIS APPEARS TO BE A WIDESPREAD PROBLEM THAT HAS BEEN REPORTED FOR YEARS. I CALLED GM AND THEY TOLD ME THAT THEY HAVE KNOWN ABOUT THE PROBLEM AND WILL COVER 50% OF THE COST ONLY IF I TAKE IT TO A GM DEALER AND THAT MY PORTION OF THE COST WOULD BE BETWEEN $500 - $600 DOLLARS. THEY WOULD NOT COVER ANY OF THE COST IF I TAKE IT TO MY LOCAL MECHANIC. THIS PROBLEM HAS BEEN KNOWN BY GM FOR YEARS AND THEY SHOULD HAVE ISSUED A COMPLETE RECALL TO REPAIR THE DEFECTIVE PART(S). *TR

NHTSA ID

10447242

Incident

Feb 1, 2012

Mileage

89,500 mi

AFTER FILLING FUEL TANK, SENSOR WENT TO EMPTY IMEDIATELY. CHIMES ACTIVATE AND FUEL GAUAGE READS EMPTY.

NHTSA ID

10444390

Incident

Dec 14, 2011

FAULTY FUEL GAUGE WENT OUT AGAIN FOR THE SECOND TIME. FIRST TIME IT HAPPEN THE VEHICLE WAS UNDER WARRANTY. THIS TIME IT IS NOT COVERED. WE HAVE TAKEN THIS TRUCK TO THE SHOP TWICE TO WORK ON THE DASH BOARD INSTRUMENT CLUSTER.(OIL, BATTERY , FUEL). *TR

NHTSA ID

10443627

Incident

Jan 3, 2012

Mileage

108,500 mi

MY FUEL GAUGE STOPPED WORKING IN MY 2005 ENVOY AT APPROXIMATELY 40,000 MILES. THE FUEL GAUGE INDICATES THAT THE CAR IS OUT OF FUEL AFTER FILL THE TANK FULL. I HAVE NOTICED NUMEROUS COMPLAINTS ABOUT THIS PROBLEM AND HAVE ALSO RECEIVED A LETTER FROM GM STATING THAT THEY ARE AWARE OF THE PROBLEM AND WILL COVER UP TO 50% OF REPAIR AS MY WARRANT HAS EXPIRED. THE PROBLEM WITH ONLY COVERING 50% IS PAYING WITH FOR MY HALF OF THE REPAIR. I HAVE BEEN UNABLE TO COME UP WITH APPROXIMATELY THE $200 FOR THE REPAIR THEREFORE UNABLE TO HAVE IT REPAIRED. I SPOKE WITH GM CUSTOMER SERVICE AND THEY INFORMED ME THAT WAS MY OPTION. WHEN I ASKED WHY THERE HAS NOT BEEN A RECALL ON THE PROBLEM THEY INFORMED ME THAT I SHOULD CONTACT THE NHTSA. MY CONCERN IS THAT I LIVE IN A STATE WITH COLD WEATHER THAT REQUIRES THAT CAR TO WARM UP PRIOR TO DRIVING. SO I WAS KEEPING TRACK OF MY MILEAGE KNOWING WHEN I NEEDED TO FILL UP WITH GAS. ALTHOUGH, THIS WILL NOT BE ACCURATE IN WINTER AND AFRAID THAT MY SPOUSE (PRIMARY DRIVER OF THIS VEHICLE) WILL GET STRANDED ON THE ROAD. I HOPE IF/WHEN THIS HAPPENS IT IS NOT DURING A SNOW STORM WHERE AN AUTO ACCIDENT WILL THEN BECOME LIKELY. WHEN TALKING TO GM ALONG WITH THE FUEL SENSOR I EXPRESSES CONCERNS ABOUT OTHER ISSUES THAT I HAVE BEEN HAVING. FOR EXAMPLE, MY LICENSE PLATE LIGHT STOPPED WORKING, CHANGED THE BULB AND CHECKED THE FUSES AND STILL DOES NOT WORK; ALONG WITH HEAT ISSUES AND WAS INFORMED TO TAKE IN FOR DIAGNOSIS. *TR

NHTSA ID

10439002

Incident

Sep 1, 2010

FUEL SENSOR, LOCATED IN GAS TANK, HAS FAILED. NO MATTER HOW MUCH GAS IS IN THE TANK, BE IT FULL, HALF FULL, OR LESS, THE SENSOR BELL RINGS AND THE GAUGE REGISTERS EMPTY. THIS ALSO CAUSES THE CHECK ENGINE LIGHT TO COME ON. GMC SHOULD RECALL, AS THIS IS VERY DANGEROUS. I THOUGHT I HAD MORE FUEL BUT RAN OUT OF GAS ON A MAJOR ROAD, THANKFULLY NO ACCIDENT. GMC HAS ADMITTED THERE IS A PROBLEM AND HAS AGREED TO PAY 50% OF REPAIRS, BUT THIS IS ONLY DONE UNDER A VEHICLE WARRANTY EXTENSION, NOT RECALL. *TR

NHTSA ID

10427997

Incident

May 31, 2010

Mileage

62,000 mi

FUEL GAUGE READINGS ARE INACCURATE, DEALER WANTS TO REPLACE THE GAUGING SYSTEM IN THE TANK AT CONSUMERS COST. I BELIEVE IT IS A KNOWN PROBLEM AND SHOULD BE A WARRANTIED ITEM. *TR

NHTSA ID

10423831

Incident

Sep 5, 2008

Mileage

40,000 mi

MY 2005 GMC ENVOY SL ONLY HAS 47,000 MILES. I EXPERIENCED DASH ELECTRONICS CONCERNING WARNING INDICATOR LIGHTS ("POWER TRAIN COOLOING FAN AT 46,000 MILES") AND GAS TANK LEVEL GAUAGE STOPPED WORKING AT 40,000 MILES. I HAVE BEEN TOLD THAT THIS ISSUE RELATED TO AN OVERALL SENSOR PROBLEM AND WILL EFFECT THE HEADLIGHTS AND OTHER SAFETY RELATED ISSUES. *TT

NHTSA ID

10421696

Incident

Aug 24, 2011

Mileage

40,000 mi

FILLED CAR UP WITH GAS AND LOW FUEL LIGHT CAME ON. SINCE THEN LOW FUEL LIGHT STAYS ON EVEN WHEN TANK IS FULL. *TR

NHTSA ID

10420957

Incident

Feb 12, 2010

Mileage

52,000 mi

TL* THE CONTACT OWNS A 2005 GMC ENVOY XL 370. THE CONTACT STATED THAT AFTER REFUELING THE TANK, HE NOTICED THAT THE FUEL GAUGE WOULD READ IMPROPERLY. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED THROUGH EMAIL AND HAD NOT YET REPLIED. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000. THE VIN WAS UNAVAILABLE. UPDATED 09/29/2011 *LN *TR

NHTSA ID

10420009

Incident

Aug 18, 2009

Mileage

49,000 mi

FUEL GAUGE NOT READING CORRECT FUEL LEVEL. VEHICLE READS FULL ONE MINUTE AND EMPTY THE NEXT. VEHICLE HAS STALLED WHILE DRIVING. THIS WAS FIXED ONCE UNDER WARRANTY AND THIS IS THE SECOND TIME IT HAS OCCURRED I AM THE ORIGINAL OWNER. THE DEALERSHIP WILL NOT COVER THE REPAIR. I UNDERSTAND THAT GMC IS BEING INVESTIGATED BY YOUR ORGANIZATION FOR THIS ISSUE AND I WOULD LIKE TO BE ADDED TO NHTSA ACTION NUMBER: PE11014 AS PART OF MY COMPLAINT. *KB

NHTSA ID

10416917

Incident

Feb 1, 2011

Mileage

99,870 mi

IN 2008, OUR VEHICLE'S GAS GAUGE WOULD FLUCTUATE ON THE AMOUNT OF GAS. WE WOULD FILL IT UP AND THE GAUGE WOULD SHOW FULL BUT AS SOON AS WE WOULD START DRIVING WOULD DROP DOWN TO EMPTY AND EVENTUALLY AS OF TODAY WHEN WE FILL OUT VEHICLE UP ALL THE WAY, THE GUAGE ONLY SHOWS LESS THAN A 1/4 FULL THEN DROPS TO EMPTY. AFTER FILLING UP THE GAS TANK AND THE GAUGE SHOWING FULL AND DROPPING TO 1/4 FULL THEN I RAN OUT OF GAS WITH MY CHILDREN IN THE VEHICLE ON THE HIGHWAY, CAUSING MY GMC ENVOY TO SHUT DOWN AND MY STEERING WHEEL TO LOCK UP, LUCKILY I WAS ABLE TO STEER OFF TO THE SHOULDER WITH MUCH FORCE TO THE WHEEL. AS OF TODAY, OUR GAUGE NO LONGER RISES TO SHOW ANY SORT OF AMOUNT OF FUEL IN THE TANK. WE USE THE GAS USED ON THE DASH TO KEEP TRACK OR MILEAGE TO TRACK WHEN WE NEED TO FILL UP AND MAKE SURE WE DON'T GET DOWN TO CLOSE TO EMPTY. WE HAVE NOT FIXED THIS PROBLEM BECAUSE WE HAVE READ SO MANY COMPLAINTS THAT THERE SHOULD BE A RECALL MADE BY GMC. I HAVE CALLED GMC AND ASKED IF THERE WAS A RECALL FOR OUR VEHICLE AND TO MY SURPRISE NONE! I BELIEVE GMC NEEDS TO CORRECT THEIR MANUFACTURER DEFECT! *TR

NHTSA ID

10416410

Incident

Jun 22, 2008

I FILLED UP MY 2005 GMC ENVOY XL SLT WHEN IT HAD 71,000 MILES. I HAD NO PREVIOUS FUEL GAUGE ISSUES. STARTED THE VEHICLE AND FUEL GAUGE WENT TO EMPTY EVEN THOUGH I HAD FILLED IT COMPLETELY. I DON'T HAVE THE MONEY TO REPAIR SO HAVE BEEN DRIVING IT FOR THE PAST MONTH AND THIS HAS BEEN A DAILY ISSUE WHILE DRIVING. THE FUEL GAUGE FLUCTUATES BETWEEN EMPTY AND FULL AND WILL STICK ON EMPTY AND THE BELL CHIMES CONSTANTLY EVEN WHEN I JUST FILLED IT UP. I HAVE NO WAY OF KNOWING EXACTLY HOW MUCH FUEL IS IN THERE EXCEPT TO MONITOR MILES DRIVEN AND FILL IT BACK UP MORE FREQUENTLY. I FEEL THIS IS A SAFETY ISSUE. WHAT IF MY CALCULATIONS ARE INCORRECT AND MY VEHICLE STALLS ON THE HIGHWAY. I HAVE TWO YOUNG CHILDREN AND AM AFRAID OF A STALL HAPPENING RESULTING IN A CRASH. THE FUEL GAUGE IS NOT WORKING. I HAVE NO WAY OF KNOWING EXACTLY HOW MUCH GAS IS IN THERE. AGAIN...THE GAUGE WILL GO BACK AND FORTH AS I AM DRIVING. I CAN START A DRIVE KNOWING IT IS FULL BUT THE GAUGE WILL SAY 1/4 TANK AND IT WILL JUMP ALL THE WAY BACK UP TO FULL AND THEN DOWN TO EMPTY WHICH CAUSES THE LOW FUEL SIGNAL AND BEEP TO GO OFF. THIS HAPPENS DAILY. I HAVE DONE RESEARCH AND AM SEEING ALOT OF COMPLAINTS FROM GMC ENVOY OWNERS EXPERIENCING THIS SAME ISSUE AND GM DOES NOT CONSIDER THIS A PROBLEM. THIS IS A SAFETY ISSUE AND SHOULD BE CORRECTED BY GENERAL MOTORS. IT SHOULDN'T TAKE SOMEONE TO DIE TO GET GM'S ATTENTION ON THIS ISSUE! *TR

NHTSA ID

10415139

Incident

Jul 1, 2011

Mileage

71,000 mi

PROBLEM WITH SEVERE FLUCTUATIONS OF FUEL GAUGE. RESEARCH SHOWS YOUR ONGOING INVESTIGATION # IS DP10001. UPON FILLING TANK TO APROX. TANK THE GAUGE SUDDENLY STARTED GOING WILD AND WITHIN 1 MILE OF DRIVING THE "CHECK ENGINE LIGHT" APPEARED. AFTER INVESTIGATING NUMEROUS ON-LINE RESOURCES IT IS CLEAR THAT THIS PROBLEM IS NOT ONLY LIMITED TO THIS VEHICLE BUT IS A SERIOUS PROBLEM IN THE GM LINEUP. DEALERSHIP REPAIR COSTS ARE ESTIMATED IN THE $800.00 TO $1000.00 RANGE. THIS IS UNACCEPTABLE FOR A PROBLEM THAT GM KNOWS TO EXIST YET REFUSES TO TAKE ANY UNILATERAL ACTION ON. *KB

NHTSA ID

10414048

Incident

Jul 21, 2011

Mileage

91,377 mi

I HAVE A 2005 GMC ENVOY. THE GAS GAUGE HAD STARTED HAVING PROBLEMS AT 60,000 MILES. IT COMPLETELY STOPPED WORKING AT 77,000 TO 80,000 MILES. I BOUGHT THE CAR USED IN 2008 WITH ONLY 45,000 MILES. MY JOB HAS ME ON THE HIGHWAY A LOT. I TRIED TO ESTIMATE THE MILES. BUT THIS IS VERY DANGEROUS I HAVE RAN OUT OF GAS ON HIGHWAY 820 AT 260 MILES AFTER FILLING UP. I RAN OUT ON HIGHWAY 30 AT 320 MILES. IN THE COUNTRY ON PRIVATE GOVERNMENT PROPERTY WITH NO ONE TO BE FOUND AT 150 MILES, EVERY TIME I COMPLETELY FILLED THE CAR UP WITH GAS BEFORE RESETTING THE FUEL GAUGE. I CAN NOT AFFORD TO GET IT FIXED. I CAN NOT TRADE THE CAR IN. I AM A SINGLE MOTHER TWITH THREE CHILDREN THAT HAS BEEN BLESSED SO FAR TO RUN OUT WITH OUT THEM IN THE CAR. I DID REALIZE SO MANY OTHERS WERE HAVING THE SAME PROBLEM. *TR

NHTSA ID

10412359

Incident

Aug 15, 2010

Mileage

80,000 mi

FUEL GAUGE MALFUNCTIONS AND WILL NOT WORK PROPERLY. WHEN VEHICLE IS FILLED TO FULL TANK LEVEL, THERE IS A CLICK SOUND AND THE GAUGE GOES ALL THE WAY TO THE EMPTY POSITION, THEN WARNING LIGHT AND VERY LOW FUEL INDICATOR LIGHT COMES ON. THIS IS THE 2ND GM VEHICLE I HAVE HAD PROBLEMS WITH. ONCE THE WARRANTY EXPIRES EVERYTHING STARTS TO GO WRONG SUCH AS FUEL PUMP/SENSOR, RADIATOR/FAN MOTOR, A/C, FRONT WHEEL BEARINGS. THE MORE I TRY TO MAINTAIN THESE VEHICLES THE MORE PROBLEMS. I WILL PURCHASE A HONDA, NISSAN, TOYOTA NEXT TIME. *TR

NHTSA ID

10410392

Incident

May 15, 2011

Mileage

67,000 mi

THE FUEL GAUGE STOPPED WORKING STALLING OUT ON THE ROAD. *TR

NHTSA ID

10399276

Incident

Jan 1, 2008

Mileage

70,000 mi

2005 GMC ENVOY FUEL GAUGE IN ACCURATE READING. VEHICLE FUEL GAUGE READING OVER 1/4 TANK OF FUEL TRAVELING DOWN FREEWAY VEHICLE RAN OUT OF FUEL IN CENTER LANE LOSS OF POWER STEERING SYSTEM AND POWER BRAKES. WAS ABLE TO GET VEHICLE OFF TO SIDE OF ROAD WITHOUT ANY ISSUES. *TR

NHTSA ID

10399164

Incident

Mar 4, 2011

Mileage

131,273 mi

FUEL GAUGE NEVER READS CORRECTLY EVEN AFTER TANK IS FUEL GAUGE DOESN'T REGISTER ANYMORE THAN HALF A TANK WHEN MOVING, ANYTIME VEHICLE COMES TO A COMPLETE STOP THE GAUGE GOES TO EMPTY AND THE LOW FUEL LIGHT COMES ON. ALSO GAUGE NEVER READS THE SAME AT ANY TIME VERY INCONSISTENT. *TR

NHTSA ID

10399073

Incident

Apr 17, 2011

Mileage

127,200 mi