2023 GMC Hummer EV Pickup Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2023 GMC Hummer EV Pickup, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine133.3%
- Fuel system133.3%
- Powertrain (other)133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
My 2023 GMC Hummer EV 3X has experienced repeated thermal-protection failures in the high-voltage battery and drive-motor cooling system, causing the vehicle to enter limp mode and drop to as low as 12 mph without warning. Stored fault codes: P0C12, P0C13, P2EE0, P2EE1 (battery and drive-unit overheating). A sudden, unannounced drop to 12 mph in a 9,000-lb EV is a serious safety hazard — on highways it creates rear-end collision risk, in intersections it leaves the vehicle stranded in traffic, and on remote roads it can strand the driver with no safe shoulder. Visit 1 (Covert Buick GMC of Bee Cave, TX): 02/09/2026–03/24/2026, 43 days out of service. Repairs: replaced both EV coolant pumps (PN 85605761), replaced Drive Motor Inverter Module 2 (PN 24059125), coolant flush, software update. RO #BUCS138101. GM TAC Case #88689105. Six days after return, on 03/30/2026, the same defect recurred with the same fault codes. Vehicle has now been back at the dealer 38+ additional days with no resolution. GM had pre-sale knowledge of this exact defect on this exact VIN. The vehicle was a GM corporate evaluation unit (factory option code OAR — EVALUATION VEHICLE) operated out of GM Tech Center in Warren, MI. GM took it out of service on 08/07/2025 at 30,169 miles. I took delivery 16 miles later at 30,185 miles. A GM Driver Inspection Form left inside the vehicle at delivery is handwritten with "Limited Speed 12 mph" — the exact limp-mode behavior. GM auctioned the vehicle through CVO Warren Distribution Center without disclosing this condition. I request ODI open a preliminary evaluation of cooling-system thermal-protection failures on 2022–2024 Hummer EV Pickups and SUVs, particularly units with prior corporate/fleet use.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
My 2023 GMC Hummer EV 3X has experienced repeated thermal-protection failures in the high-voltage battery and drive-motor cooling system, causing the vehicle to enter limp mode and drop to as low as 12 mph without warning. Stored fault codes: P0C12, P0C13, P2EE0, P2EE1 (battery and drive-unit overheating). A sudden, unannounced drop to 12 mph in a 9,000-lb EV is a serious safety hazard — on highways it creates rear-end collision risk, in intersections it leaves the vehicle stranded in traffic, and on remote roads it can strand the driver with no safe shoulder. Visit 1 (Covert Buick GMC of Bee Cave, TX): 02/09/2026–03/24/2026, 43 days out of service. Repairs: replaced both EV coolant pumps (PN 85605761), replaced Drive Motor Inverter Module 2 (PN 24059125), coolant flush, software update. RO #BUCS138101. GM TAC Case #88689105. Six days after return, on 03/30/2026, the same defect recurred with the same fault codes. Vehicle has now been back at the dealer 38+ additional days with no resolution. GM had pre-sale knowledge of this exact defect on this exact VIN. The vehicle was a GM corporate evaluation unit (factory option code OAR — EVALUATION VEHICLE) operated out of GM Tech Center in Warren, MI. GM took it out of service on 08/07/2025 at 30,169 miles. I took delivery 16 miles later at 30,185 miles. A GM Driver Inspection Form left inside the vehicle at delivery is handwritten with "Limited Speed 12 mph" — the exact limp-mode behavior. GM auctioned the vehicle through CVO Warren Distribution Center without disclosing this condition. I request ODI open a preliminary evaluation of cooling-system thermal-protection failures on 2022–2024 Hummer EV Pickups and SUVs, particularly units with prior corporate/fleet use.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
My 2023 GMC Hummer EV 3X has experienced repeated thermal-protection failures in the high-voltage battery and drive-motor cooling system, causing the vehicle to enter limp mode and drop to as low as 12 mph without warning. Stored fault codes: P0C12, P0C13, P2EE0, P2EE1 (battery and drive-unit overheating). A sudden, unannounced drop to 12 mph in a 9,000-lb EV is a serious safety hazard — on highways it creates rear-end collision risk, in intersections it leaves the vehicle stranded in traffic, and on remote roads it can strand the driver with no safe shoulder. Visit 1 (Covert Buick GMC of Bee Cave, TX): 02/09/2026–03/24/2026, 43 days out of service. Repairs: replaced both EV coolant pumps (PN 85605761), replaced Drive Motor Inverter Module 2 (PN 24059125), coolant flush, software update. RO #BUCS138101. GM TAC Case #88689105. Six days after return, on 03/30/2026, the same defect recurred with the same fault codes. Vehicle has now been back at the dealer 38+ additional days with no resolution. GM had pre-sale knowledge of this exact defect on this exact VIN. The vehicle was a GM corporate evaluation unit (factory option code OAR — EVALUATION VEHICLE) operated out of GM Tech Center in Warren, MI. GM took it out of service on 08/07/2025 at 30,169 miles. I took delivery 16 miles later at 30,185 miles. A GM Driver Inspection Form left inside the vehicle at delivery is handwritten with "Limited Speed 12 mph" — the exact limp-mode behavior. GM auctioned the vehicle through CVO Warren Distribution Center without disclosing this condition. I request ODI open a preliminary evaluation of cooling-system thermal-protection failures on 2022–2024 Hummer EV Pickups and SUVs, particularly units with prior corporate/fleet use.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .